R
Trademark
Please do not return unit to retailer.
Por favor, no devuelva el aparato al lugar de compra.
Veuillez ne pas retourner l’outil au détaillant.
1-800-554-6723
Instruction Manual
Manual de Instrucciones
Manuel d’Instructions
HTC2200
WARNING:
Read and follow all Safety Rules and Operating Instructions before
using this product. Read instructions carefully before assembling.
Failure to do so can result in serious injury.
ADVERTENCIA:
Lea el manual del operador y siga todas las advertencias e instruc-
ciones de seguridad. Antes de ensamblar el producto lea cuidado-
samente el instructivo. El no hacerlo puede resultar en lesiones gra-
ves.
AVERTISSEMENT:
Veuillez lire le manuel de l’utilisateur et bien respecter tous les
avertissements et toutes les instructions de sécurité. Bien lire les
instructions avant d’assembler l’outil. Tout défaut de le faire pourrait
entraîner des blessures graves.
WEED EATER
1030 Stevens Creek Road
Augusta, GA 30907
WEED EATER
850 Matheson Blvd. West
Mississauga, Ontario L5V 0B4
545117506 Rev. 2 4/15/09 BRW
Download from Www.Somanuals.com. All Manuals Search And Download.
IDENTIFICATION OF SAFETY SYMBOLS
This unit is for household use only and not for commercial
use.
When servicing unit, use only identical replace-
ment parts.
Never allow children to operate this unit.
Hazard zone for thrown objects
S Blades can throw objects violently.
S Others can be blinded or injured.
S Keep people and animals 30 feet (10 m) away.
SAFETY RULES
IMPORTANT SAFETY INSTRUCTIONS
terial from blades. Do not grab or hold unit by
blades.
WARNING: When using electric gar-
dening appliances, basic safety precautions
must always be followed to reduce the risk of
fire, electric shock, and serious injury. Read
and follow all instructions.
S Dress properly. Always wear safety
glasses or similar eye protection when op-
erating, or performing maintenance on your
unit. (Safety glasses are available.) Always
wear face or dust mask if operation is dusty.
Always wear heavy, long pants, long
sleeves, boots, and gloves. Secure hair
above shoulder length. Do not go barefoot
or wear short pants, sandals, jewelry, loose
clothing, or clothing with loosely hanging
straps, ties, tassels, etc. They can be
caught in moving parts.
S Always wear hearing protection when us-
ing this unit.
S Being fully covered also helps protect you
from debris and pieces of toxic plants such
as poison ivy thrown by the blades, which
could be more of a hazard than touchingthe
plant itself.
This power unit can be dangerous! Operator
is responsible for following the warnings and
instructions in this manual and on the unit.
Read entire instruction manual before using
unit! Be thoroughly familiar with the controls
and the proper use of the unit. Restrict theuse
of this unit to persons who read, understand,
and follow unit and manual warnings and
instructions. Never allow children to operate
this unit. Close attention is necessary when
used near children.
OPERATOR SAFETY
DANGER: RISK OF CUT; KEEP
HANDS AND FEET AWAY FROM BLADE.
Keep both hands on handles when power is
on. Do not attempt to clear away cut material
when blades are in motion. Remove battery
pack from unit before removing jammed ma-
S Stay Alert. Do not operate unit when you are
tired, ill, upset or under influence of alcohol,
drugs, or medication. Watch what you are do-
ing; use common sense.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
S Avoid unintentional starting of the unit. Nev-
er carry unit with your finger on the trigger
switch.
ELECTRICAL SAFETY
UNIT SAFETY
S Inspect unit before use. Damaged parts
must berepaired or replacedby your autho-
rized service dealer.
S Inspect entire unit, including blade and
handguard, before each use. Have dam-
aged parts repaired or replaced by your au-
thorized service dealer. Make sure all han-
dles, guards, and fasteners are in place and
securely fastened.
S Before using the unit, have your service
dealer replace blades or parts that are
cracked, chipped, broken, or damaged in
any other way. Throw away damaged or
bent blades.
S Use only WEED EATER blades and other
replacement parts and accessories as re-
commended.
WARNING: Avoid a dangerous envi-
ronment. To reduce the risk of electrical shock,
do not use on wet hedges or shrubbery. Do not
use in rain, in damp or wet locations, or around
swimming pools, hot tubs, etc. Do not expose to
snow, rain, or water to avoid the possibility of
electrical shock.
S Only use the charger provided with your
unit when charging the battery pack. Use of
any other charger could permanently dam-
age the battery pack and the hedge trim-
mer.
S Use charger with standard household elec-
trical outlets only (120 volt). Do not abuse
the charger or charger cord. Never carry
the unit by the charger cord or yank cord to
disconnect from receptacle. Do not use the
charger if the charger or charger cord is
damaged.
S Use the charger indoors only.
S Store and charge this unit in a dry location
and out of the reach of children.
CUTTING SAFETY
WARNING:
Inspect area to be
trimmed before each use. Remove objects
(rocks, broken glass, nails, wire, string, etc.)
which can wrap around or be thrown by blades
or otherwise cause injury or damage during op-
eration.
S Do not use hedge trimmer without hand-
guard attached.
S Don’t force unit; it will do the job better and
with less likelihood of a risk of injury at the
rate for which it was designed.
S Keep children away. Keep others including
children, animals, bystanders and helpers
at least 30 feet (10 meters) away from the
work area. Stop the unit immediately if you
are approached.
S Always keep unit in front of your body. Hold
handles firmly with both hands.
S Avoid dangerous situations. Do not charge
the battery pack or use the unit in an explo-
sive or corrosive environment. Avoid areas
where flammable liquids or gases are pres-
ent to avoid creating a fire or explosion and/
or causing damage to unit.
S Do not attempt to repair unit, battery pack or
charger. Inspect insulation and connectors on
the unit and charger before each use. If there
is any damage, do not use until damage is re-
paired by your authorized service dealer.
S Do not insert any object into the motor area.
S Battery-powered units do not have to be
plugged into an electrical outlet to operate;
therefore, they are always in operating condi-
tion. Be aware of possible hazards when you
are not using your battery-powered unit.
S Do not dispose of the battery pack in a fire.
The cell may explode. Check with local code
for proper disposal. Do not open or mutilate
the battery pack. Released electrolyte is cor-
rosive and may cause damage to the eyes or
skin. It may be toxic if swallowed.
S Don’t overreach or stand on unstable sup-
port such as ladders, stools, truck beds,
etc. Keep firm footing and balance at all
times.
S Do not raise unit above your shoulders.
S Keep all parts of your body away from the
blades.
S Use unit properly. Use only for jobs ex-
plained in this manual.
S Use only in daylight or in good artificial light.
MAINTENANCE SAFETY
S When handling batteries, take care not to
short the battery pack with conducting materi-
als such as rings, bracelets, and keys. The
battery pack or conductor may overheat and
cause burns.
WARNING: Remove battery pack
from unit before performing maintenance.
S Maintain unit according to recommended
procedures.
S Have all service and maintenance not ex-
plained in this manual performed by an au-
thorized service dealer to avoid creating a
hazard.
S Never douse or squirt the unit or charger
with water or any other liquid. Clean unit
and labels with a damp sponge. Keep han-
dles dry, clean, and free from oil and
grease.
S Keep the blades and air vents clean and
free of debris to avoid overheating the mo-
tor. Clean after each use.
S Do not use the unit if the switch levers do not
turn the unit on and off properly. Repairs to the
switch levers must be made by your autho-
rized service dealer.
S Remove battery pack from unit before ser-
vicing, cleaning or storing.
S Never immerse any part of the unit or char-
ger into any liquid.
S Inspect charger cord periodically and if
damaged, have it repaired or replaced by
an authorized service dealer.
S Disconnect charger from receptacle when
not in use to reduce the risk of electric
shock or serious personal injury.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
TRANSPORTING AND STORAGE
S Carry the unit with motor stopped and the
blades away from your body.
IMPORTANT!
DISPOSE OF YOUR OLD
BATTERIES SAFELY.
DO NOT CUT OPEN, BURN OR
INCINERATE.
S Secure the unit before storing or transport-
ing it in a vehicle.
S Store unit so blades cannot accidentally
cause injury.
DOUBLE INSULATION
CONSTRUCTION
S Do not store near fertilizers or chemicals
which can corrode metal parts.
The charger supplied with this unit is double
insulated to help protect against electric
shock. Double insulation construction con-
sists of two separate “layers” of electrical in-
sulation instead of grounding.
S Store unit indoors in a high, dry place out of
the reach of children.
S Do not hang unit so that the trigger switch is
depressed.
Tools built with this insulation system are not
intended to be grounded. No grounding
means is provided on this unit, nor should a
means of grounding be added to this unit.
Safety precautions must be observed when
operating any electrical tool. The double in-
sulation system only provides added protec-
tion against injury resulting from an internal
electrical insulation failure.
BATTERY CARE
S If over a period of time the battery pack
quickly runs down after a full 5--6 hour
charging period,
pack is needed.
S There will be some charge present in the bat-
tery pack, but to ensure maximum running
time, recharge your battery pack for 5--6
hours before use.
a
replacement battery
S To prevent permanent battery damage, never
store in a discharged condition.
S Contact your authorized service dealer for
a replacement battery pack and for safe
disposal of your old battery pack.
S Battery
WARNING: All electrical repairs to
this unit, including housing, switch, motor,
wires, etc., must be diagnosed and repaired
by qualified service personnel. Replacement
parts for adouble insulated appliance must be
recommended by the manufacturer. A double
insulated appliance is marked with the words
“double insulation” or “double insulated”. The
Use only the following type and sizebat-
tery pack:
18 Volt, 1.3 Amp/Hour
Sealed for Life
symbol (square within a square)
may also
No maintenance required
be marked on the appliance. Failure to have
the unit repaired by qualified service person-
nel can cause the double insulation construc-
tion to become ineffective and result in seri-
ous injury.
WINTER STORAGE
S Fully charge for 5--6 hours before winter
storage.
S Recharge the battery pack every 3 to 4
months for a 5--6 hour charging period to
fully charge the battery pack during winter
storage.
S Avoid extended storage without recharge.
S Store in a cool dry place.
SAVE THESE INSTRUCTIONS
ASSEMBLY
NOTE: If you need assistance or find parts
missing or damaged, call 1-800-554-6723.
WARNING: Before using the hedge
trimmer, ensure all fasteners are secure.
ASSEMBLY
Your hedge trimmer is fully assembled; no as-
sembly is necessary.
Examine parts for damage. Do not use dam-
aged parts.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION
KNOW YOUR HEDGE TRIMMER
READ THIS INSTRUCTION MANUAL AND SAFETY RULES BEFORE OPERATING YOUR UNIT.
Compare the illustrations with your unit to familiarize yourself with the location of the various controls
and adjustments. Save this manual for future reference.
Switch
lever
Rear
handle
Motor Housing
Front
handle
Switch
lever
Battery Pack
Handguard
Blade
Charger
SWITCH LEVERS
FRONT HANDLE AND REAR
HANDLE
The SWITCH LEVERS are used to turn on
the unit (rear handle and front handle switch
levers). Bothswitch levers must be held in op-
erating position for the unit to start. Release
either switch lever to stop the unit.
The FRONT HANDLE and REAR HANDLE
are used to maintain control of the unit.
CHARGER
The CHARGER is used to charge the battery
pack.
2. Place battery pack in charger. When
properly connected, the red charge indi-
cator light (LED) will glow.
NOTE: The charge indicator light (LED) on
the charger glows red continuously during
charging and will change to green when the
battery pack is fully charged and ready for
use.
CHARGING BATTERY PACK
WARNING: Never charge battery
pack in an explosive or corrosive environment.
Avoid areas where flammable liquids or gasses
are present to avoid creating a fire or explosion.
S Only use the charger provided with your
unit when charging the battery pack. Use of
any other charger could permanently dam-
age the battery pack and the hedge trim-
mer.
S Use the charger with standard household
electrical outlets only. See the voltage
specifications on the charger.
S Ensure the charger is not exposed to mois-
ture. Keep the charger and the hedge trim-
mer dry at all times.
ger
S Keep the charger well ventilated during
charging. Do not place the charger in an
area of extreme heat or cold. It will work
best at normal room temperature.
S Use the charger indoors only.
S The battery pack should becharged for 5--6
hours before use.
S During charging, the battery pack becomes
warm. This is normal and means the char-
ger is operating correctly.
Charge
Indicator
Light (LED)
TO CHARGE BATTERY PACK:
1. Plug the charger into a standard house-
hold electrical outlet.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
RECHARGING YOUR BATTERY
CORRECT OPERATING POSITION
PACK
S Recharge the battery as soon as thecutting
power of your cordless hedge trimmer is no
longer effective.
S Avoid running the battery into full dis-
charge, i.e. avoid draining the battery com-
pletely.
S Follow the procedure outlined in the
CHARGING BATTERY PACK section.
S Recharging the battery pack according to
these instructions should ensure maximum
battery life.
When operating unit, stand as shown and
check for the following:
S Do not recharge the battery pack in an area of
extreme heat or cold. The charger will work
best at normal room temperature.
S Wear eye protection and heavy clothing.
S Grip rear handle with right hand and front
handle with left hand.
TO INSTALL BATTERY PACK
S Place the battery pack in your hedge trim-
mer (see illustration). Ensurethe latches on
each side of the battery pack snap in place
and battery pack is securely connected to
hedge trimmer.
S Keep unit below waist level.
STOPPING YOUR UNIT
To stop the unit, release one of the switch lev-
ers, allow blades to stop, then move the
hedge trimmer away from the cutting area.
STARTING YOUR UNIT
Press both switch levers by gripping front and
rear handles firmly. Both switch levers must
be pressed for the unit to start.
OPERATING THE UNIT
S Read important safety instructions before
operating.
S Do not cut stems greater than 3/8 inch (1
cm) thick.
Top Cutting
Use a wide sweeping motion for top cutting. A
slight downward tilt of the cutting blades inthe
direction of motion gives the best cutting re-
sults.
TO REMOVE BATTERY PACK
S Press both latches on side of battery pack
to release battery pack from hedge trimmer
(see illustration).
Side Cutting
When trimming the sides of a hedge, begin at
the bottom and cut upwards.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
MAINTENANCE
CUSTOMERRESPONSIBILITIES
WARNING: Remove battery from unit before performing maintenance.
CARE & MAINTENANCE TASK
Check for loose fasteners and parts
Check for damaged or worn parts
Inspect and clean unit and labels
Lubricate blades
WHEN TO PERFORM
Before each use
Before each use
After each use
After each use
GENERALRECOMMENDATIONS
The warranty on this unit does not cover items
that have been subjected to operator abuse
or negligence. To receive full value from the
warranty, the operator must maintain unit as
instructed in this manual. Various adjust-
ments will need to be made periodically to
properly maintain your unit.
LUBRICATE BLADES
S Stop the unit and remove the battery pack.
S Remove any debris on blades.
S Clean allparts andcheck for damage. Have
damaged parts replaced. Be cautious of
sharp edges.
S Apply a light machine oil along the edge of
the top and bottom straps.
NOTE: Ensure handles remain clean and
dry.
BEFORE EACH USE
CHECK FOR LOOSE
FASTENERS AND PARTS
S Housing screws
S Handguard
S Blade
CHECK FOR DAMAGED OR
WORN PARTS
Contact an authorized service dealer for re-
placement of damaged or worn parts.
S Switch levers -- Ensure switch levers func-
tion properly by pressing and releasing the
levers. Make sure motor stops once either
lever is released.
AFTER EACH USE
INSPECT AND CLEAN UNIT AND
LABELS
S After each use, inspect complete unit for
loose or damaged parts. Clean the unit us-
ing a damp cloth with a mild detergent.
S Use a soft brush to remove debris from all
air intakes and the cutting blade.
BATTERY PACK
The battery pack for your hedge trimmer is
equipped with nickel--cadmium rechargeable
batteries. Length of service from each charg-
ing will depend onthe typeof work you are do-
ing.
The battery in this tool has been designed to
provide maximum trouble--free life. However,
like all batteries, it will eventually wear out. Do
not disassemble battery pack and/or attempt
to replace the batteries.
To obtain the longest possible battery life:
S Do not store or charge the battery pack in
an area of extreme heat or cold. It will work
best at normal room temperature.
S Never store battery pack in a discharged
condition. Recharge the battery pack im-
mediately after use.
S Wipe off unit with a clean dry cloth.
S All batteries gradually lose their charge.
The higher the temperature, the quicker
they will lose their charge. If you store your
hedge trimmer for long periods without us-
ing it, recharge the battery pack every
month to help prolong battery life.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
USER REPLACEABLE SERVICE PARTS
REPLACEMENT PART
PART NUMBER
Battery Pack
Charger
545124416
545124415
STORAGE
S To preserve natural resources, please re-
cycle or dispose of batteries properly.
S This product contains nickel--cadmium batter-
ies. Local, state or federal laws may prohibit
disposal of nickel--cadmium batteries in ordi-
nary trash.
S Consult your local waste authority for infor-
mation regarding available recycling and/or
disposal options.
WARNING: Perform the following
steps after each use.
S Stop the unit and remove the battery pack
when not in use.
S Carry the unit with motor stopped.
S Store the unit so the blades cannot cause
injury.
S Store unit indoors in a high, dry place out of
the reach of children.
S Store unit with all guards in place. Position
unit so that any sharp object cannot acci-
dentally cause injury.
BATTERY DISPOSAL
WARNING: Remove the battery pack
from the hedge trimmer. Cover the terminals
with heavy duty adhesive tape. Do not attempt
to destroy or disassemble battery pack or re-
move any of its components. Nickel--cadmium
batteries must be recycled or disposed of prop-
erly. Also, never touch both terminals with metal
objects and/or body parts to avoid short circuit-
ing the battery pack. Keep away from children.
Failure to comply with these warnings could re-
sult in fire or serious personal injury.
TROUBLESHOOTING TABLE
WARNING: Always stop unit and remove battery pack before performing all of the
recommended remedies below except remedies that require unit to be operating.
TROUBLE
Unit fails to
operate
CAUSE
REMEDY
1. Remove battery and check connectors.
Replace battery.
1. Battery not attached to
unit correctly.
2. Charge battery pack.
3. Remove debris.
2. Battery needs charging.
3. Debris stopping blade.
Cutting blades
stop under a
load or do not
move when
trigger switch
is pressed
1. Cut at a slower pace.
1. Forcing blade into
material being cut.
2. Blades clogged with
debris.
3. Battery needs charging.
4. None of the above
2. Clean debris from blades.
3. Charge battery pack.
4. Contact your authorized service dealer.
Poor cutting
quality
1. Unit is being used
incorrectly.
1. Ensure the product is being used
correctly.
2. Blades clogged with
debris.
2. Clean debris from blades.
3. Damaged blades.
1. Damaged blades.
3. Contact your authorized service dealer.
1. Contact your authorized service dealer.
Excessive
vibration
9
Download from Www.Somanuals.com. All Manuals Search And Download.
LIMITED WARRANTY
WEED EATER, a division of Husqvarna Con-
In Canada, contact:
sumer Outdoor Products N.A., Inc., warrants to
the original consumer purchaser that each new
WEED EATER brand electric or cordless pro-
duct is free from defects in material and work-
manship and agrees to repair or replace under
this warranty any defective WEED EATER
brand electric or cordless product within two (2)
years from the original date of purchase.
WEED EATER
850 Matheson Blvd. West
Mississauga, Ontario L5V 0B4
Giving the model number, serial number and
date of purchase of your product and the name
and address of the authorized dealer from
whom it was purchased.
THIS WARRANTY GIVES YOU SPECIFIC
LEGAL RIGHTS, AND YOU MAY HAVE OTH-
ER RIGHTS WHICH VARY FROM STATE TO
STATE.
NO CLAIMS FOR CONSEQUENTIAL OR
OTHER DAMAGES WILL BE ALLOWED,
AND THERE ARE NO OTHER EXPRESS
WARRANTIES EXCEPT THOSE EX-
PRESSLY STIPULATED HEREIN.
SOME STATES DO NOT ALLOW LIMITA-
TIONS ON HOW LONG AN IMPLIED WAR-
RANTY LASTS OR THE EXCLUSION OR
LIMITATIONS OF INCIDENTAL OR CONSE-
QUENTIAL DAMAGES, SO THE ABOVE LIM-
ITATIONS OR EXCLUSION MAY NOT APPLY
TO YOU.
This is a limited warranty within the meaning of
that term as defined in the Magnuson--Moss Act
of 1975.
The policy of WEED EATER is to continuous-
ly improve its products. Therefore, WEED
EATER reserves the right to change, modify,
or discontinue models, designs, specifica-
tions, and accessories of all products at any
time without notice or obligation to any pur-
chaser.
If your WEED EATER brand electric or cord-
less product should fail within the limitedwar-
ranty period, you may return it in complete
condition, prepaid, with proof of purchase, to
the dealer from whomit was purchased for re-
pair or replacement at the option of WEED
EATER.
This warranty is not transferable and does not
cover damage or liability caused by improper
handling, improper maintenance or alteration, or
the use of accessories and/or attachments not
specifically recommended by WEED EATER
for this product. Additionally, this warranty does
not cover parts that will wear and require re-
placement with reasonable use during the war-
ranty period. This warranty does not cover pre-
delivery set--up or normal adjustments
explained in the instruction manual.
Should you have any unanswered questions
concerning this warranty, please contact:
WEED EATER, a division of Husqvarna
Consumer Outdoor Products N.A., Inc.
1030 Stevens Creek Road
Augusta, GA 30907
1--800--554--6723
10
Download from Www.Somanuals.com. All Manuals Search And Download.
|