SMOKEY MOUNTAIN
™
COOKER SMOKER
19 inch
(49 cm)
63230
Download from Www.Somanuals.com. All Manuals Search And Download.
3
Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Assembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-9
Helpful Hints . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Getting Started . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Brine Cure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Cooking Charts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-15
Recipes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-23
Barbecuing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24-26
Steaming . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Download from Www.Somanuals.com. All Manuals Search And Download.
4
ꢀ DANGER
Failure to follow the Dangers, Warnings and Cautions contained
in this Owner’s Manual may result in serious bodily injury, death,
or fire causing damage to property.
ꢀ WARNINGS
ꢀ This smoker is designed for outdoor use only. If used indoors,
toxic fumes will accumulate and cause serious bodily injury or
death.
ꢀ Do not add charcoal lighter fluid or charcoal impregnated with
charcoal lighter fluid to hot or warm coals. Cap starter fluid after
use, and place a safe distance away from the barbecue.
ꢀ Do not use gasoline, alcohol, or other highly volatile fluids to
ignite charcoal. If using charcoal lighter fluid, remove any fluid
that may have drained through the bottom vents, before lighting
the charcoal.
ꢀ Do not leave infants, children, or pets unattended near a hot
smoker.
ꢀ Do not attempt to move a hot smoker.
ꢀ Do not use this smoker within five feet of any combustible
material.
ꢀ Do not use this smoker unless all parts are in place.
ꢀ Do not remove ashes until all coals are completely burned out
and are fully extinguished.
ꢀ Do not wear clothing with loose flowing sleeves while lighting or
using the smoker.
ꢀ Do not use smoker in high winds.
ꢀ Keep the smoker in a level position at all times.
Download from Www.Somanuals.com. All Manuals Search And Download.
5
ꢀ Combustion by-products produced when using this product
contain chemicals known to the state of California to cause
cancer, birth defects, or other reproductive harm.
ꢀ Remove the lid from the smoker while lighting and getting the
coals started.
ꢀ Always put charcoal on top of the charcoal grate and not
directly into the bottom of the bowl.
ꢀ Never touch the cooking or charcoal grate, or the smoker,
to see if they are hot.
ꢀ Barbecue mitts or hot pads should always be used to
protect hands while barbecuing or adjusting the vents.
ꢀ Use proper barbecue tools with long, heat-resistant handles.
ꢀ To extinguish the coals, place the lid on the bowl and close all
vents. Do not use water, it will damage the porcelain finish.
ꢀ To control flare-ups, place lid on smoker. Do not use water.
ꢀ Handle and store hot electric starters carefully.
ꢀ Keep electrical cords away from the hot surfaces of the smoker.
Lining the bowl with aluminum foil will obstruct the air flow,
instead use a drip pan to catch drippings from meat when
cooking by the Indirect Method.
ꢀ Using sharp objects to clean the cooking grate or remove ashes
will damage the finish.
ꢀ Using abrasive cleaners on the cooking grate or the smoker
itself will damage the finish.
Download from Www.Somanuals.com. All Manuals Search And Download.
6
1
Check Package Contents
Lid
Three legs
Center ring
Charcoal chamber
Bowl
Water pan
Door assembly
Four grill straps
No-handled cooking grate
You should have received the parts listed at right.
While we give much attention to our product, an
occasional error may occur. If a part is missing, do
not go back to the store. Call the Weber-Stephen
Products Customer Service Center toll-free at
1-800-446-1071 to receive immediate assistance.
Charcoal grate
Handled cooking grate
Hardware Pack Contents:
14 - 1⁄4-20 x 5⁄8" screws
14 - 1⁄4-20 nuts
8 - Fiber washers
6 - 1⁄4" steel washers
2
Assemble Legs
You will need: bowl, three legs, six screws, six steel washers, six nuts, an adjustable wrench and
a screwdriver.
Set bowl on the ground. Place leg against bowl and insert one screw into each end of leg. Slip
a steel washer over each screw, add a nut and hand tighten.
Repeat this for the other two legs.
With the three legs in position, tighten
assembly using an adjustable wrench
and screwdriver.
Download from Www.Somanuals.com. All Manuals Search And Download.
7
3
Assemble Charcoal Grate
and Charcoal Chamber
You will need: charcoal grate and charcoal chamber.
Set charcoal grate into bowl. Set charcoal chamber
on charcoal grate.
4
Attach Grill Straps to Center Ring
You will need: four grill straps, eight fiber washers, eight screws, eight nuts, center ring, an
adjustable wrench and screwdriver.
Place a fiber washer on each of the screws and insert into each hole in center ring, with heads
of screws on the outside. Place grill straps inside the ring over the screws, making sure the
two “ledges” are at the bottom. Place a nut on each of the screws and tighten securely with an
adjustable wrench and screwdriver.
Download from Www.Somanuals.com. All Manuals Search And Download.
8
5
Install Center Ring and Bowl
You will need: center ring assembly from
Step 4 and bowl assembly from Step 3.
Place center ring assembly onto bowl.
6
Install Door Assembly
You will need: door assembly and center
ring to bowl assembly.
Holding door assembly on a slight angle,
place door assembly into opening in
center ring. To open or close, turn knob.
Download from Www.Somanuals.com. All Manuals Search And Download.
9
7
Complete Assembly
You will need: lid, water pan, no-handled cooking
grate and handled cooking grate. Place water pan
on the bottom ledge of grill strap. Place
no-handled cooking grate on middle ledge of
strap. Place handled cooking grate on very top
ledge of strap. Set lid on top.
8
Steaming and Barbecuing
To steam: arrange the charcoal grate, charcoal
chamber, and water pan on the middle ledge grill
strap. Place no-handled cooking grate on top of
the water pan. Place handled cooking grate aside.
To barbecue: arrange the charcoal grate and
charcoal chamber on the middle ledge grill strap.
Set aside no-handled cooking grate and water
pan. Place handled cooking grate on very top
ledge of strap.
Download from Www.Somanuals.com. All Manuals Search And Download.
10
Helpful Hints
Please read all instructions before using your smoker.
• Always cook with the cover on your smoker.
• Use tongs for turning meats to avoid piercing meat and losing natural juices.
• Resist the temptation to look at the foods during cooking time—every time the lid is lifted it
will be necessary to add 15 minutes to the cooking time.
• Use a meat thermometer to determine the internal temperature of meat—it should be inserted
into the thickest part of the meat and should not touch fat or bone.
• Charcoal should be stored in a dry place—damp charcoal will not burn well.
• Always use barbecue mitts or hot pads to protect your hands.
• Adjust vents as indicated for each method of cooking in your smoker:
Smoking—all vents partially closed.
Barbecuing—all vents wide open.
Steaming—top vent closed, bottom vents open.
• All vents should be wide open when preparing the fire.
• Close all vents to extinguish the coals when you are finished cooking. Do not use water to
extinguish coals as it may damage the porcelain finish.
• There are many variables that influence smoking, fortunately most of them can be controlled
by the person doing the cooking. However, there are some things that we cannot control,
such as weather, wind and altitude. So, to be on the safe side, add extra time to your cooking
schedule when necessary, usually half to 1 hour is adequate.
• Smoker should be placed on a level heat proof surface away from buildings and out of the
general traffic path. The smoker is for outdoor use only and not recommended for use on
carpeted surfaces. Since the aroma of smoke can linger it is best to find a place away from
the house to do your smoke-cooking.
• Experiment with different varieties of wood and amounts used. You can also add bay leaves,
garlic cloves, mint leaves, orange or lemon peel and various spices to the charcoal for added
flavor. Keep a record of your experiments—it’s easy to forget what you did last time.
Note: Do not use charcoal that has been impregnated with a starter fluid in your smoker. This is
especially important when adding charcoal during the cooking time, because it can give
an unpleasant taste to your food.
Download from Www.Somanuals.com. All Manuals Search And Download.
11
Cleaning
It isn’t necessary to clean the inside walls of your smoker, however, if you wish, they may
be wiped down occasionally. The outside of the unit may be cleaned with a sudsy cloth and
rinsed with a damp cloth.
If you use aluminum foil to completely cover the water pan it will aid the clean-up chore.
Grease tends to build up on the inside and outside of the water pan. When the grease
build-up is baked onto the pan it may flake off—this is not porcelain flaking off—it is
hardened, baked-on grease and can be cleaned off with a spray-on oven cleaner. Follow
the manufacturers directions on oven cleaner.
Frequently remove ashes from the bottom section of the smoker.
Download from Www.Somanuals.com. All Manuals Search And Download.
12
Getting Started
• Remove top and center ring before starting the fire. Open all vents.
• Fill charcoal chamber with the amount of charcoal recommended on chart for food being
cooked. Heap charcoal in center of grill. Ignite the charcoal.
• When the coals have a light coating of gray ash (about 30 minutes) spread them evenly
across the inside of the charcoal chamber.
• Place the water pan in position on the lower bracket of the center ring. Fill pan with hot tap
water.
• Put the lower cooking grill in place on bracket above water pan. The 181⁄2" cooking grill should
be positioned on the top bracket.
• Carefully set the center ring in place on top of the bottom section of the smoker.
• Arrange food in a single layer on the cooking grills leaving space between each piece of food.
(Both grills may be used for food.)
• Open door on front of smoker to place wet wood chunks on top of the hot coals.
• Partially close all vents while smoke-cooking. Use barbecue mitts to protect your hands while
adjusting the vents.
• PIace recommended amount of wood chunks in a pan of water to soak at least 1 hour
before using.
• Shake excess water off wood chunks before placing them on top of the hot coals.
• Different hardwoods will impart a variety of flavors. Do some experimenting to find the type
of hardwood, or combination of hardwoods, that you like best. Start with the lowest amount of
wood chunks recommended—more can be added to suit your own taste. Some experimenting
will be necessary to find the amount of smoke flavor you prefer. (Use pieces of wood
approximately 2" x 3" in size.)
• By keeping records of your smoke-cooking experiences—a beginner can quickly become an
expert. Notes you make will be an invaluable aid in your future endeavors. By referring to your
notes at a later date you will be able to repeat your successes.
• Smoke-cooked foods look different than oven cooked foods—they may be pink or red when
completely cooked. A good meat thermometer is the most accurate way to determine the
internal temperature of large cuts of meat.
• Beer, wine, cola, fruit juices, marinades, herbs and spices can be combined with water, in the
waterpan, to give additional flavor to your food.
• Meat can be smoke-cooked without curing, or it can be cured before smoking with either a
dry cure or in a brine.
Download from Www.Somanuals.com. All Manuals Search And Download.
13
Brine Cure
Salting, or curing, reduces the moisture content of meat, retards formation of bacteria and adds
flavor as it is absorbed in the meat. When meats require 2 hours or less of curing they may be
kept at room temperature, otherwise they should be refrigerated.
Salt is the basic ingredient used in most seasonings and brines for smoking and curing foods.
Rock salt, pickling salt or canning salt are less expensive to use than iodized table.
Sugar is also a basic ingredient used in brines and dry cures—it is used during curing to
counteract the effects of salt. Sugar can be in the form of white or brown sugar, honey,
molasses or syrup—each imparts its own flavor.
Seasoning is more or less a matter of personal taste—spices can be used during or after the
curing process to give additional flavor to the meat or fish.
Stone crocks and glass or plastic containers are ideal containers for use in brining or storing
leftover brine. (Never use metal containers.)
Meat should be completely submerged in the brine. A weighted plate will be helpful to keep the
meat from coming to the surface of the brine.
Contents of the brine solution should be stirred occasionally with a wooden spoon. This is
called overhauling. When overhauling a large container of meat it is best to remove the meat
from the container, stir the brine, put meat back in container and pour the brine over meat,
weighing it down to keep meat completely submerged in the brine.
After a piece of meat or fish is removed from the brine solution it should be given a quick rinse
in fresh water and dried before smoking.
Dry cures can be used instead of a brine
solution. They are applied in a dry form
directly to the surface of the meat or fish.
Meats should be kept at 35° during dry
curing. Foods should be rinsed in fresh
water and dried before smoking.
Sweet Pickle Brine
1 gal. water
21⁄2 cups salt
1
⁄
3
cup light brown sugar
1 tablespoon Liquid garlic
1 oz. pickling spices
Basic Dry Cure
Basic Brine
1 quart of water
2 cups salt
1
⁄
2
cup sugar
1
⁄
2
2
cup of salt
1
⁄
cup light brown sugar
teaspoon Liquid garlic
teaspoon pepper
Add spices and seasonings of your choice
to this mixture. Start with 1⁄2 teaspoon of
each—experiment to find the combinations
you like best with the meat and fish you
smoke.
1
⁄
2
1
⁄
2
Download from Www.Somanuals.com. All Manuals Search And Download.
14
Smoking Cooking Charts
Please note: The amount of wood chunks, water or charcoal is not indicated in each recipe.
Please refer to this chart.
• The cooking times listed in the charts are for foods that have been completely thawed.
• Add 12 to 14 briquettes every 11⁄2 hours. When coals are added check the waterpan and add
water as necessary to fill pan. Use door on front of unit to add charcoal or water.
Beef
Weight
Water
Pan
Charcoal Cooking
Wood
Chunks
Internal
Temp
Layers
Time
Beef Roast,
Beef Brisket
3-4 lbs.
5-7 lbs.
Full
Full
2
2
4-5 hrs.
5-6 hrs.
4-6
4-6
145° rare
160° med
Lamb Roast,
Venison
Large cuts
of game
7-9 lbs.
Full grill
Full
Full
2
1
6-8 hrs.
3-4 hrs.
4-6
2-4
170° well
160° well
Beef ribs
Pork
Weight
Water
Pan
Charcoal Cooking
Wood
Chunks
Internal
Temp
Layers
Time
Pork Roast
Pork Ribs
3-4 lbs.
4-8 lbs.
Full
Full
2
2
5-6 hrs.
6-8 hrs.
4-6
4-6
160° med
170° well
Full grill
Full
Full
Full
Full
1
1
2
1
4-6 hrs.
2-3 hrs.
8-12 hrs.
3-4 hrs.
4-6
2-4
6-8
4-6
160° med
170° well
Pork Chops
Full grill
160° med
170° well
Fresh Ham 10-18 lbs.
Whole
160° med
170° well
Whole Ham 10-14 lbs.
Cooked
140° med
Download from Www.Somanuals.com. All Manuals Search And Download.
15
• Always use hot water to fill or replenish the water pan. You might find that a watering can
works well.
• If your fire seems to be fizzling out—take the door on the front of the smoker off for a short
period of time. The additional oxygen will get the fire going again.
Poultry
Weight
Water
Pan
Charcoal Cooking
Wood
Chunks
Internal
Temp
Layers
Time
Cut up
Whole
1-4 fryers
1-4 fryers
Full
Full
1
2
3-4 hrs.
4-5 hrs.
2-4
2-4
180° well
180° well
Whole
5 lbs. roaster
8-12 lbs.
12-18 lbs.
3-5 lbs.
Full
Full
Full
Full
Full
Full
2
2
2
2
2
2
5-6 hrs.
7-8 hrs.
8-10 hrs.
4-6 hrs.
4-6 hrs.
7-8 hrs.
2-4
6-8
6-8
2-4
2-4
4-6
180° well
180° well
180° well
185° well
185° well
185° well
Turkey
Unstuffed
Duck
Pheasant
Goose
3-5 lbs.
8-10 lbs.
Fish
Weight
Water
Pan
Charcoal Cooking
Wood
Chunks
Internal
Temp
Layers
Time
Small whole
Fillets
Full grill
Full grill
3-6 lbs.
Full
Full
Full
1
1
1
1 1⁄2 - 3 hrs.
1 1⁄2 - 3 hrs.
3-4 hrs.
2-4
2-4
2-4
Flakes
with a
fork.
Large whole
Lobster,
Shrimp
Full grill
Full
1
1 hr.
2-4
firm/pink
Download from Www.Somanuals.com. All Manuals Search And Download.
16
Pork Roast
1 rolled pork loin roast, 5-6 lbs.
1 garlic clove, cut into slivers
1
⁄
2
2
teaspoon celery salt
teaspoon rosemary
teaspoon sweet basil
teaspoon pepper
1
⁄
1
⁄
2
1
⁄
4
1 teaspoon caraway seed
Make small slits in top of roast and insert a garlic sliver in each slit. Combine seasonings and
sprinkle over roast. Place meat in center of cooking grill. Cover and smoke-cook about 6 hours
or until done.
Barbecued Pork Roast
4 lbs. pork back ribs or spareribs
1
⁄
4
4
cup molasses
cup Soy sauce
cup vinegar
1
⁄
1
⁄
4
1
⁄
3
cup prepared mustard
2 teaspoons Worcestershire sauce
1
⁄
2
teaspoon hot pepper sauce (more if desired)
Place ribs in a plastic or glass dish. Combine remaining ingredients and pour over ribs. Cover
and refrigerate 5 hours or overnight. Turn ribs occasionally to completely coat with marinade.
Remove ribs from marinade and place on the cooking grill or in a rib rack. Cover and
smoke-cook 41⁄2 to 5 hours or until done.
Pork Tenderloin Tarragon
2 whole pork tenderloins
1
⁄
2
cup white tarragon vinegar
1 teaspoon Worcestershire sauce
2 teaspoons soy sauce
1 teaspoon dried tarragon
Place pork tenderloins in a shallow glass or plastic dish. Combine remaining ingredients and
pour over meat. Cover with plastic wrap and refrigerate 3 to 4 hours. Turn meat in marinade
occasionally. Place pork tenderloins on cooking grill. Pour marinade over meat allowing excess
to drain into the water pan. Smoke-cook 3 to 4 hours. Serve with pineapple sauce.
Pineapple Sauce:
Combine equal parts of drained crushed pineapple and sour cream.
Approximately 8 oz. of each.
Download from Www.Somanuals.com. All Manuals Search And Download.
17
Smoked Glazed Ham
1 fully cooked ham, 10-14 lbs.
Whole cloves
1 quart apple cider
Remove any rind left on ham and score fat diagonally to give a diamond effect. Insert a whole
clove in center of each diamond. Place ham fat side up on cooking grill. Pour apple cider over
ham allowing excess to go into water pan. Cover and smoke-cook 3-4 hours brushing with
glaze occasionally during the last hour of cooking time.
Glaze
1 – 9 oz. jar currant jelly
1
⁄
4
cup orange juice concentrate, undiluted
1 teaspoon prepared horseradish
1 teaspoon dry mustard
1 teaspoon lemon juice
Combine all ingredients in a saucepan. Heat, stirring until jelly melts.
Smoked Fresh Ham
1 fresh ham, 6-7 lbs.
Sweet pickle Brine (page 7)
Brown sugar
Prepare sweet pickle brine. Brine ham for 3 days in brine. Remove from brine. Rinse ham in
cold water and pat dry with paper towel. Let ham dry in refrigerator for 1 day. Rub outside
surfaces of ham with brown sugar. Place ham in center of cooking grate. Cover and smoke
approximately 8 hours. May be served immediately, however, flavor is enhanced by refrigerating
a day or two before serving.
Download from Www.Somanuals.com. All Manuals Search And Download.
18
Beef Ribs
2-3 lbs. beef back ribs
2 – 8 oz. cans tomato sauce
1
⁄
4
cup red wine vinegar
2 tablespoons prepared mustard
1 tablespoon prepared horseradish
1 tablespoon instant minced onion
1
⁄
4
2
teaspoon garlic powder
teaspoon pepper
1
⁄
Place ribs in a shallow glass or plastic dish large enough to accommodate them in a single
layer. Combine remaining ingredients and pour over ribs. Turn meat over to completely coat with
marinade. Cover with plastic wrap and refrigerate at least 4 hours turning occasionally. Remove
ribs from marinade and place on cooking grill. Pour remaining marinade over ribs allowing
excess to drain into water pan. Smoke-cook 31⁄2 to 4 hours.
Beef Brisket
1 beef brisket, 5-6 lbs.
1 envelope dry onion soup mix
2 tablespoons port wine
2 cups barbecue sauce
Combine soup mix and wine to make a paste. Spread over surface of the brisket. Allow brisket
to stand at room temperature 2 hours before cooking. Add barbecue sauce to the water in the
water pan. Position brisket in center of cooking grill. Cover and smoke-cook approximately 6
hours or until tender.
Glazed Meat Loaf
11⁄2 lbs. lean ground beef
1
⁄
2
2
cup soda crackers, coarsely crumbled
cup onion, finely chopped
1
⁄
2 eggs, slightly beaten
1 teaspoon salt
1
⁄
2
2
teaspoon garlic salt
teaspoon paprika
teaspoon pepper
cup milk
1
⁄
1
⁄
4
3
⁄
4
11⁄2 cups sharp cheddar cheese, cubed
2 slices bacon
Combine ground beef, crumbs, onion and seasonings in a large bowl. Add eggs, milk and
cheese cubes; mix lightly until blended. Turn mixture into an aluminum foil pan and shape into
a loaf. Place bacon slices lengthwise on top of meat loaf. Position foil pan with meat loaf in
center of cooking grill. Smoke-cook 4 hours or until top of loaf feels firm.
Download from Www.Somanuals.com. All Manuals Search And Download.
19
Glazed Hickory Smoked Turkey
Glaze:
1 turkey, thawed, 8-10 lbs.
Seasoned salt
1 tablespoon paprika
1
⁄
2
cup currant jelly
cup port wine
1
⁄
2
Combine currant jelly and wine in a saucepan
and cook over medium low heat stirring
constantly until jelly is melted. If glaze gets
too sticky during use, reheat it.
Stuffing:
2 oranges, cut into 8 chunks
Large onion, cut into 8 chunks
2-3 ribs celery, cut into 1" pieces
Rinse turkey thoroughly with cold water. Pat bird dry. Season inside and outside with
seasoned salt. Sprinkle outer surface with paprika. Stuff turkey with orange, onion and celery
chunks alternating the three different items. Fasten neck skin over back with skewer; lock
together. Place turkey on cooking grill. Cover with wine-jelly glaze during the last 2 hours of
cooking time.
Smoked Duck
1 duckling, thawed, 5 lbs.
6 green onions with tops, cut up
4-5 sprigs parsley
1 clove garlic, minced
1
⁄
3
cup soy sauce
2 tablespoons lemon juice
2 tablespoons honey
Rinse bird thoroughly with cold water, drain and pat dry with paper toweling. Stuff cavity of
duckling with onion, parsley and garlic. Use a sharp knife to make a small cut between the wing
joints and breast to permit draining of excess fat during cooking. Lock wings behind back and
tie legs and tail together. Fasten neck skin over back with a skewer. Heat soy sauce, honey and
lemon juice, in a saucepan, to make a glaze. Place duckling in center of cooking grill. Cover
and smoke-cook 5-6 hours until done. Brush duckling with glaze occasionally. Serve with plum
sauce.
Plum Sauce
1 – 16 oz. can purple plums
1
⁄
4
teaspoon orange peel, grated
3 tablespoons orange juice
2 tablespoons sugar
1
⁄
2
4
teaspoon cinnamon
teaspoon Worcestershire sauce
1
⁄
Drain plums reserving 1⁄4 cup syrup. Force plums through a sieve. Combine plum puree and
reserved plum syrup with remaining ingredients in a saucepan. Heat to boiling; reduce heat
and simmer 15 minutes.
Download from Www.Somanuals.com. All Manuals Search And Download.
20
Cornish Hens
2 to 4 Cornish game hens, about 1 lb. each
Seasoned salt
Lemon pepper
1 large carrot, cut into julienne strips
1 medium onion, cut into wedges
Madeira Wine Sauce
Wash Cornish hens thoroughly with cold water and pat dry with paper toweling. Season inside
with seasoned salt and lemon pepper. Put carrot strips and onion wedges inside each hen. Lock
wings behind the back and tie legs together securely. Wrap a bacon strip around each hen and
secure with a toothpick. Sprinkle with lemon pepper and seasoned salt. Place hens on cooking
grill. Cover and smoke-cook 3 hours or until done. Baste with Madeira wine sauce during last
15 minutes of cooking time. Serve with remaining sauce.
Madeira Wine Sauce
1 cup crabapple jelly
1
⁄
4
2
teaspoon ginger
teaspoon salt
cup Madeira Wine
1
⁄
1
⁄
4
1 orange peeled, cut orange peel into 3" julienne strips
Combine jelly, ginger, salt and wine. Cook over low heat until jelly melts; add orange strips and
simmer for 2 minutes.
Smoked Turkey
1 turkey, 12 lbs. completely thawed
Sweet Pickle Brine (see page 7)
Maple syrup
Rinse turkey thoroughly with cold water, drain and pat dry. Prepare sweet pickle brine. Brine
12 lb. turkey for 3 days. Remove from brine, rinse thoroughly in cold water and pat dry. Allow
to dry in refrigerator for 24 hours. Lock wings behind back and tie legs and tail together. Baste
bird with maple syrup before putting in the smoker and every 2 hours during smoking. Position
turkey on cooking grill. Smoke-cook 7 hours or until done. Cool turkey in the refrigerator for
24 hours before serving to enhance the smoked flavor. Turkey may be served immediately if
you wish.
Brine:
8-12 lb. bird — 3 days
13-16 lb. bird — 4 days
17-22 lb. bird — 5 days
Download from Www.Somanuals.com. All Manuals Search And Download.
21
Smoked Whole Chicken
1 whole broiler-fryer chicken, 21⁄2-3 lbs.
Seasoned salt
White wine (optional)
Wash chicken thoroughly with cold water and pat dry with paper toweling. Lock wings behind
back and tie legs together securely. Sprinkle seasoned salt generously on chicken. Pour white
wine into water pan. Cover and smoke-cook 3 hours.
Fish
Any edible saltwater or freshwater fish can be smoked. If you wish, fish may be
smoke-cooked without curing, or they can be cured before smoking with either a dry cure
or in a brine. Grills in the smoker should be lightly oiled to prevent fish from sticking. Fish
may be placed in an aluminum foil pan or on a sheet of aluminum foil, which have been
lightly oiled. Fish should be checked occasionally during cooking time because some of
them tend to dry out rapidly and may require basting—brushing with cooking oil will help
to keep them moist. If you prefer fish dry—allow it to remain in the smoker for an extra
hour or two after it is done. When fish flakes easily with a fork it is done.
To prepare fish for cooking: thoroughly rinse exterior in fresh, cold water; remove scales
and internal organs; thoroughly clean the body cavity. Small fish can be left whole. Large
fish may be left whole or cut into smaller pieces. Use short sticks to wedge crosswise
inside split fish to hold the cavity open while smoking so the smoke can circulate inside
the fish.
Smoked Whole Fish
1 large whole fish, 8 to 10 lbs., cleaned
Red Snapper, Salmon, Trout or Sea Bass
cup lemon juice
1
⁄
2
1 tablespoon Worcestershire sauce
1 tablespoon prepared mustard
1
⁄
2
2
teaspoon basil
teaspoon garlic salt
teaspoon salt
1
⁄
1
⁄
2
1 medium onion, thinly sliced
1 lemon, thinly sliced
Melted oil or butter
Combine lemon juice, Worcestershire sauce, prepared mustard, basil and salts; mix and brush
in cavity of fish. Arrange 1⁄2 of the onion and lemon slices alternately in a row in cavity of fish.
Brush outside of fish with melted oil or butter. Overlap remaining onion and lemon slices on top
of fish. Place fish on cooking grill. Drizzle remaining lemon juice mixture over the fish allowing
excess to go into the water pan. Cover and smoke-cook 3-4 hours or until done.
Download from Www.Somanuals.com. All Manuals Search And Download.
22
Halibut Steak
4 Halibut steaks, 3⁄4" thick
1
⁄
4
cup butter or margarine, melted
Juice of 1 lemon
Salt and pepper
Worcestershire sauce
If halibut is frozen, thaw. Grease an aluminum foil tray. Place steaks in tray and pour melted
butter over them. Squeeze lemon juice on steaks. Sprinkle with salt, pepper and Worcestershire.
Place foil tray on cooking grill. Cover and smoke-cook until the fish flake easily when tested
with a fork, approximately 1 hour.
Whole Pan Fish
6 small whole pan fish, cleaned
1 teaspoon salt
1
⁄
2
teaspoon pepper
Juice of 1 lemon
3 bacon slices, halved
If fish are frozen, thaw. Clean and dry fish. Sprinkle cavities with lemon juice, salt and pepper.
Brush outside of fish with oil. Place a half strip of bacon lengthwise on top of each fish.
Arrange fish on the cooking grill and smoke-cook 1 to 11⁄2 hours or until they flake when tested
with a fork. Serve with lemon butter.
Lemon Butter:
1 cup softened butter or margarine
1
⁄
4
cup lemon juice
1 tablespoon minced parsley
3
⁄
4
4
teaspoon grated lemon peel
teaspoon salt
1
⁄
Combine all ingredients.
Smoked Lobster Tail
Lobster tails, thawed (1 per person)
Melted butter
Lemon wedges
Cut away underside membrane on lobster. To prevent curling while cooking, hold lobster tail in
both hands and bend backward to crack the shell. Brush with melted butter and position on the
cooking grill. Cover and smoke-cook about 1 hour or until flesh is white and firm. Serve with
melted butter and lemon wedges.
Download from Www.Somanuals.com. All Manuals Search And Download.
23
Smoke Flavoring
Introduce family and friends to a new flavor treat—try smoking cheese, nuts and eggs.
This should be done at a low degree of heat—the best time to do smoke flavoring is after
you have smoke-cooked something and the coals have burned down and are producing a
low heat.
NUTS
Any kind of nuts or seeds can be smoke flavored for a tasty snack. Place nuts in a single
layer, on a wire screen, on top of the cooking grill. Place 3-4 wet chunks of wood on top
of coals. Smoke for 45-60 minutes. (Do not use water in water pan.)
CHEESE
Any mild-flavored cheese may be given a smoke flavor; try Colby, Monterey Jack or
Muenster. Make a shallow tray of extra-heavy duty aluminum foil or use a shallow foil
pan. Place cheese in tray and position on the cooking grill. Place 3-4 chunks of wet wood
on top of the coals. Smoke about 1 hour. Make sure the fire is not too hot, watch carefully
so the cheese doesn’t melt. (Do not use water in the water pan.)
EGGS
Chilled, peeled hard-cooked eggs. Arrange eggs on the cooking grill. Place 3-4 chunks
of wet wood on top of the coals. Smoke 25-30 minutes or until lightly browned. Remove
eggs from smoker and serve immediately or wrap in plastic wrap and refrigerate. Great
for deviled eggs!
NOTE: We used hickory or apple wood for smoke flavoring and soaked it in water for
45-60 minutes before using. Experiment—perhaps you will find a different type of
hardwood you like better.
Download from Www.Somanuals.com. All Manuals Search And Download.
24
Barbecuing
Position the charcoal grate and charcoal chamber as shown in step 8 (pg. 9) of this book.
Pour charcoal one layer deep on charcoal grill. Heap charcoal in center of grill. Ignite
charcoal. When coals have a light coating of gray ash (approximately 30 minutes) spread
them one layer deep again. Put cooking grill in place on the top bracket. Place meat on the
cooking grill. Cover smoker. All vents should be wide open.
This method of cooking is used for fast cooking of flat meats. Food is cooked on one side
and must be turned to expose both sides of the meat to the heat.
Steak
Rib, T-bone, Club, Porterhouse,
Sirloin or Filet, 3⁄4 - 1 lb. per person
Salt and pepper
To prevent steak from curling during cooking slit fat at 11⁄2 - 2 inch intervals. Refer to steak
cooking chart below for cooking times. Cover steaks when cooking. Covering helps to
eliminate flare-ups. If you prefer searing steak, leave cover off for the first minute or two on
each side. Use meat tongs when turning steak to prevent piercing and loss of natural juices.
STEAK COOKING CHART
RARE
MEDIUM
WELL- DONE
1st side /2nd side 1st side /2nd side
1st side /2nd side
Steak Thickness
1"
"
2"
2 min./3 min.
5 min./6 min.
7 min./8 min.
4 min./4 min.
7 min./8 min.
9 min./9 min.
5 min./6 min.
9 min./10 min.
10 min./11 min.
11⁄2
Download from Www.Somanuals.com. All Manuals Search And Download.
25
Hamburgers
1 lb. ground beef, lean
1
⁄
4
4
teaspoon black pepper
teaspoon salt
teaspoon dried minced onions or 1 tablespoon minced fresh onion
3
⁄
3
⁄
4
Combine all ingredients, mix well. Shape into 4-6 patties on cooking grill and follow cooking
times given below. Cover hamburgers while cooking. This helps to eliminate flare-ups. Always
use a spatula or tongs when turning patties to prevent piercing and loss of natural juices. If you
prefer searing patties, leave cover off for first minute on each side.
BURGER COOKING CHART
RARE
MEDIUM
WELL- DONE
Per side
3 min.
4 min.
5 min.
Gyro Burgers
1 lb. ground chuck
1 lb. ground lamb
1 egg
1
⁄
2
4
cup water
cup bread crumbs
teaspoon garlic powder
teaspoon cinnamon
teaspoon allspice
1
⁄
1
⁄
4
1
⁄
4
1
⁄
4
1
⁄
2
teaspoon thyme
teaspoon sweet basil
1
⁄
2
2 teaspoons oregano
Combine all ingredients; mix well. Shape into patties 4 1⁄2" diameter 1⁄2 inch thick. Place patties
on cooking grill and cook 4 min. on each side. Serve on a hamburger bun or Pita bread (pocket
bread) with chopped lettuce, sliced onions, tomato and yogurt sauce.
Yogurt Sauce:
1 cup yogurt
5 tablespoons sour cream
2 tablespoons parsley flakes
1
⁄
4
4
cup cucumber, chopped
cup onion, chopped
1
⁄
Mix all ingredients together; refrigerate. Spoon onto Gyro burgers before serving.
Download from Www.Somanuals.com. All Manuals Search And Download.
26
Brats-in-Beer
1 can beer, 12 oz.
6 bratwurst
Pour beer into an aluminum foil pan large enough to hold brats in one layer. Place pan of
beer on one side of cooking grill. Brown brats on cooking grill watching carefully turning
as necessary to brown evenly. When brats are brown; place in beer. Cover smoker and
cook 25 minutes.
Kabobs
Any combination of foods that will go onto a skewer can be tried as kabobs. Use your
imagination and try different combinations—do fruit or vegetable kabobs for an unbeatable
flavor addition to your brunch or dinner menu; or combine meat or seafood with vegetables
for a delicious entree. Keep in mind that if you choose foods that require similar cooking
times everything will be done at the same time. Use less charcoal when preparing fire for
kabob cooking. The coals should be sparsely spaced so heat is not too intense.
Land and Sea Kabobs
1
⁄
4
cup lemon juice
1 envelope onion soup mix
1
⁄
4
4
cup soy sauce
cup vegetable oil
1
⁄
1 can pineapple chunks, 8 oz., drained—reserve liquid
1
⁄
2
2
lb. sirloin steak, cut into 1" cubes
lb. shrimp, peeled and deveined
1
⁄
16 cherry tomatoes
8 mushroom caps
1 green pepper, cut into 1" squares
Combine first four ingredients plus reserved pineapple liquid in non-metal bowl. Add beef
cubes; stir meat to coat completely. Cover; refrigerate at least 3 hours. Add shrimp to beef
mixture and refrigerate 1 hour longer. Arrange ingredients alternately on skewers. Place kabobs
on cooking grill and cook approximately 15 minutes. Turn occasionally and baste with marinade.
Download from Www.Somanuals.com. All Manuals Search And Download.
27
Steaming
Position the charcoal grate and charcoal chamber as shown in step 8 (pg. 9) of this
book. Fill the charcoal chamber about 1/2 full with charcoal, arrange the charcoal so it
will conform to the shape of the water pan (higher on sides and lower in center). When
the coals are ash gray place the water pan on top of the charcoal chamber; add boiling
water (approximately 4 quarts). Seasonings or marinades may be added to the water for
additional flavor. Place the no-handled cooking grate on top of the water pan; add meat.
Place cover on smoker. Top vent should be closed, bottom vents open while steaming.
Lobster Tails
Lobster tails (1 per serving)
Melted butter
Seasoned salt
If using frozen lobster allow it to thaw; cut away underside membrane. To prevent curling while
cooking, hold tail in both hands and bend backward to crack the shell. Brush with melted butter
and sprinkle with seasoned salt. Place on the cooking grill and steam 20 minutes or until shell
is bright red.
Clams
Scrub clams under running water until free of sand. Place clams on cooking grill. Cover and
steam until shells open. Approximately 15 minutes.
Shrimp
1 lb. fresh shrimp, peeled, cleaned and deveined, ready to cook
1
⁄4
cup butter, melted
Juice of 1⁄2 lemon
1 clove of garlic, crushed
1
⁄
4
4
teaspoon oregano
teaspoon sweet basil
1
⁄
Combine butter with lemon juice, garlic and seasonings. Pour over shrimp and marinate for
at least 1⁄2 hour. Remove shrimp from marinade. Large shrimp can be placed directly on the
cooking grill. If shrimp are small lay them on a piece of aluminum foil that has been punctured
with a fork. Steam approximately 15 minutes or until pink and tender.
Download from Www.Somanuals.com. All Manuals Search And Download.
®
®
Weber-Stephen Products Co., (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber One-Touch Silver,
®
®
®
™
One-Touch Gold, One-Touch Platinum, Smokey Mountain Cooker , and Ranch grills, that it will be free from defects in material and
workmanship from the date of purchase as follows:
Cooking / Charcoal grates
1 year
®
™
Stainless Steel One-Touch Cleaning System (One-Touch Platinum)
Bowl and lid against rust / burn-through
Nylon handles
10 years
10 years
10 years
®
Thermoplastic/Thermoset Parts(One-Touch Platinum)
All remaining parts
10 years excluding fading
5 years
When assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof of your date of purchase.
THEREFORE, YOU SHOULD RETAIN YOUR SALES SLIP OR INVOICE AND RETURN THE WEBER LIMITED WARRANTY REGISTRATION CARD IMMEDIATELY.
This Limited Warranty shall be limited to the repair or replacement of parts which prove defective under normal use and service and which on examination
shall indicate to Weber’s satisfaction they are defective. If Weber confirms the defect and approves the claim, Weber will elect to repair or replace such parts
without charge. If you are required to return defective parts, transportation charges must be prepaid. Weber will return parts to the purchaser, carriage or
postage prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration, misapplication, vandalism,
improper installation or improper maintenance or service, or failure to perform normal and routine maintenance. Deterioration or damage due to severe
weather conditions such as hail, hurricanes, earthquakes or tornadoes, discoloration due to exposure to chemicals, either directly or in the atmosphere, is
not covered by this Limited Warranty.
There are no other express warranties except as set forth herein, and any applicable implied warranties of merchantability and fitness are limited in duration
to the period of coverage of this express written Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this
limitation may not apply to you.
Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the exclusion or limitation of incidental or consequential
damages, so this limitation or exclusion may not apply to you.
Weber does not authorise any person or company to assume for it any other obligation or liability in connection with the sale, installation, use, removal,
return or replacement of its equipment; and no such representations are binding on Weber.
WEBER-STEPHEN PRODUCTS CO.
®
©2003 The following trademarks are registered in the name of Weber-Stephen Products Co., an Illinois corporation, located at
®
200 East Daniels Road, Palatine, Illinois 60067 U.S.A. Australia; Smokey Joe, Weber, Kettle Silhouette , Genesis, Austria; Kettle
®
®
Silhouette , Smokey Joe, Weber, Benelux; Kettle Silhouette , Smokey Joe, Weber, Compact Grill Configuration, Botswana;
®
®
Weber, Canada; Smokey Joe, Genesis, China; Kettle Silhouette , Denmark; Kettle Silhouette , Smokey Joe, Weber, Finland;
®
Smokey Joe, France; Kettle Silhouette , Smokey Joe, Weber, One-Touch, Germany; Smokey Joe, Weber, One-Touch, Greece;
®
Smokey Joe, Ireland; Kettle Silhouette , Smokey Joe, Italy; Smokey Joe, Weber, Japan; Smokey Joe, Weber, Korea; Smokey
Joe, Weber, New Zealand; Weber, Smokey Joe, Nigeria; Weber, Norway; Smokey Joe, Weber, Portugal; Weber, South Africa:
®
Smokey Joe, Weber, Kettle Configuration, Spain; Smokey Joe, Weber, Sweden; Kettle Silhouette , Smokey Joe, Switzerland;
®
Kettle Silhouette , Smokey Joe, Weber, United Kingdom; Smokey Joe, Weber, Weber One-Touch, U.S.A..; Kettle Configuration,
®
Kettle Silhouette , Smokey Joe, Weber, One-Touch, Firespice, Go-Anywhere, U.S.A.;Kettle Configuration, Kettle Silhouette,
Genesis, Flavorizer, Crossover, Flamgo, Performer, Rapidfire, Tuck ‘N Carry, Jumbo Joe, Bar-B-Kettle, Master-Touch, Spirit, Grill
®
Out, Summit, Platinum, 1-800-Grill-Out, Ranch, Matchless Flame, Zimbabwe; Weber, Kettle Configuration, Kettle Silhouette .
Printed in U.S.A.
Download from Www.Somanuals.com. All Manuals Search And Download.
63230 4/10/05
|