User’s Manual
Wine Captain
Download from Www.Somanuals.com. All Manuals Search And Download.
Safety Precautions
Do not attempt to install or operate your unit until you have read this
manual completely. Safety items throughout this manual are labeled
with a Danger, Warning or Caution based on the risk type.
Definitions
DANGER
!
Danger means that failure to follow this safety statement may
result in severe personal injury or death.
WARNING
!
Warning means that failure to follow this safety statement may
result in extensive product damage, serious personal injury, or
death.
CAUTION
Caution means that failure to follow this safety statement may
result in minor or moderate personal injury, property or
equipment damage.
Download from Www.Somanuals.com. All Manuals Search And Download.
Table Of Contents
Wine Selection Suggestions . . . . . . . . . . . . . . . . . . . 1
Suggestions For Matching Wine And Food . . . . . . . . 2
Common Food And Wine Matches . . . . . . . . . . . . . 2
Guide To Common Styles Of Wine . . . . . . . . 3
Common Tasting Terms . . . . . . . . . . . . . . . . . 4
Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Grille Installation . . . . . . . . . . . . . . . . . . . . . . 6
Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Level Installation . . . . . . . . . . . . . . . . . . . . . . 6
Electrical Requirement . . . . . . . . . . . . . . . . . 7
Reversing The Door . . . . . . . . . . . . . . . . . . . . 7
Door Adjustment . . . . . . . . . . . . . . . . . . . . . . 7
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Initial Start-up . . . . . . . . . . . . . . . . . . . . . . . . 8
Stocking Recommendations . . . . . . . . . . . . . 8
Door Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Light Switch And Bulb . . . . . . . . . . . . . . . . . . 9
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . 9
Cleaning And Maintenance . . . . . . . . . . . . . . . . . . 10
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
If Service Is Required . . . . . . . . . . . . . . . . . . . . . . . 11
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . . 11
Troubleshooting Guide . . . . . . . . . . . . . . . . . . . . . 12
Download from Www.Somanuals.com. All Manuals Search And Download.
U-Line Corporation Limited Warranty
U-Line Corporation warrants each U-Line product to be free from defects in materials and
workmanship for a period of one year from the date of purchase; and warrants the sealed sys-
tem (consisting of the compressor, the condenser, the evaporator, the hot gas bypass valve,
the dryer and the connecting tubing) in each U-Line product to be free from defects in materials
and workmanship for a period of five years from the date of purchase. During the initial one-
year warranty period for all U-Line products U-Line shall: (1) at U-Line’s option, repair any
product or replace any part of a product that breaches this warranty; and (2) for all Marine,
RV and Domestic U-Line products sold and serviced in the United States (including Alaska and
Hawaii)and Canada, U-Line shall cover the labor costs incurred in connection with the
replacement of any defective part. During years two through five of the warranty period for the
sealed system, U-Line shall:. (1) repair or replace any part of the sealed system that breaches
this warranty; and (2) for all Marine, RV and Domestic U-Line products sold and serviced in
the United States (including Alaska and Hawaii) and Canada, U-Line shall cover the labor costs
incurred in connection with the replacement of any defective part of the sealed system. All
other charges, including transportation charges for replacements under this warranty and
labor costs not specifically covered by this warranty, shall be borne by you. This warranty is
extended only to the original purchaser of the U-Line product. The Registration Card includ-
ed with the product should be promptly completed by you and mailed back to U-Line, or you can
register online at www.U-LineService.com.
The following are excluded from this limited warranty: installation charges; damages caused
by disasters or acts of God, such as fire, floods, wind and lightening; damages incurred
or resulting from shipping, improper installation, unauthorized modification, or misuse/abuse of
the product; customer education calls; food loss/spoilage; door and water level adjustments
(except during the first 90 days from the date of purchase); defrosting the product; adjusting
the controls; door reversal; or cleaning the condenser.
If a product defect is discovered during the applicable warranty period, you must promptly
notify either the dealer from whom you purchased the product or U-Line at P.O. Box 23220,
Milwaukee, Wisconsin 53223 or at 414-354-0300. In no event shall such notification be
received later than 30 days after the expiration of the applicable warranty period. U-Line may
require that defective parts be returned, at your expense, to U-Line’s factory in Milwaukee,
Wisconsin, for inspection. Any action by you for breach of warranty must be commenced with-
in one year after the expiration of the applicable warranty period.
This limited warranty is in lieu of any other warranty, express or implied, including, but not
limited to any implied warranty of merchantability or fitness for a particular purpose; provid-
ed however, that to the extent required by law, implied warranties are included but do not
extend beyond the duration of the express warranty first set forth above. U-Line’s sole
liability and your exclusive remedy under this warranty is set forth in the initial paragraph
above. U-Line shall have no liability whatsoever for any incidental, consequential or special
damages arising from the sale, use or installation of the product or from any other cause
whatsoever, whether based on warranty (express or implied) or otherwise based on contract,
tort or any other theory of liability.
Some states do not allow limitations on how long an implied warranty lasts or the exclusion
or limitation of incidental or consequential damages, so the above limitations may not apply
to you. This warranty gives you specific legal rights, and you may also have other rights which
vary from state to state.
Download from Www.Somanuals.com. All Manuals Search And Download.
Wine Selection Suggestions
Selecting the right wine for the right occasion can
sometimes be a seemingly awkward or difficult task for
the beginning wine enthusiast. We would therefore like
to present you with a few suggestions which may provide a little more
confidence and enjoyment when choosing and serving your wines.
When selecting wines, keep an open mind
and do not be afraid to be adventurous. Do not view
the subject of wine so seriously it discourages you
from learning and discovering for fear of
embarrassment if something is incorrect. Wine is
best viewed as a hobby and enjoyed.
When assembling your collection, try not to
become obsessed with “Vintages.” Although a chart
can provide itself as a useful tool, generalizations
about a specific year have led more than one
collector to disappointment. In many instances an
“Off Year” will provide a better value and more near
term drinking enjoyment.
The primary guideline to the subject of wine you need to
follow is your own palate. Do not be afraid to make mistakes.
Experiment, discover, but most of all, enjoy yourself and your new
®
Wine Captain .
1
Download from Www.Somanuals.com. All Manuals Search And Download.
Suggestions For Matching Wine And Food
Although there are no hard fast rules for matching wine to food, some
guidelines should be observed. Delicate dishes should be accompanied by
lighter more delicate wines. Full flavored foods should be matched with
fuller bodied wines.
As a general rule one should aim to ascend in flavor and quality of
wines served.
A DRY WINE Before A SWEET WINE
A WHITE WINE Before A RED WINE
A YOUNG WINE Before An OLD WINE
A LIGHT-BODIED WINE Before A FULL-BODIED WINE
Any step back in quality will be noticed. If a fine wine were to be
tasted prior to a lesser wine, many of the fine wine’s subtle qualities may
be missed.
Common Food And Wine Matches
Fish, Shell Fish, Crab, Oysters
Dry White Wines, Light Sparkling or
Extra Dry Champagne
Beef, Venison
Full Bodied Red Wines
Pork, Veal, Lamb & Poultry
Light Bodied Red Wines
Fruit
Sweet White and Sparkling Wines
2
Download from Www.Somanuals.com. All Manuals Search And Download.
Guide To Common Styles Of Wines
Red Wines
Full-Bodied Dry:
(Calif.)
Zinfandel, Cabernet
(French)
(Italian)
Rhone, Chateauneuf-du-Pape
Barbaresco, Barolo
Medium-Bodied Dry:
Light-Bodied Dry:
(Calif.)
(French)
Pinot Noir
Bordeaux, Burgundy
(French)
(Italian)
Beaujolais
Chianti, Bardolino
White Wines
Full-Bodied Dry:
(Calif.)
Chardonnay
(French)
Montrachet, Meursault
Puligny-Montrachet
Medium-Bodied Dry:
Light-Bodied Dry:
(Calif.)
(French)
Sauvignon Blanc
Pouilly-Fuisse, Sancerre
Vouvray, Graves
(French)
Chablis, Muscadet
Pouilly-Fume
Full-Bodied
Very Sweet:
(Germany)
(French)
(Hungary)
Beerenauslese
Sauternes
Tokay
Medium-Bodied
Semi-Sweet:
(Calif.)
(Germany)
Gewurtztraminer
Liebfraumilch
Light-Bodied Off Dry: (Germany)
Rhine, Mosel, Riesling
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Common Tasting Terms
Acidity-
A critical element of wine, preserves the wine’s freshness.
In excess results in an overly tart and sour wine.
Balance-
A desired trait where tannin, fruit and acidity are in total
harmony. Wines with good balance tend to age
gracefully.
Body-
The weight and presence of wine in the mouth provided
by the alcohol and tannin level. Full-bodied wines tend
to have this strong concentration.
Bouquet-
Complex-
The blending of a wine’s aroma within the bottle over a
period of time. Caused by volatile acidity.
A subjective term often used in tasting. A wine is said to
be complex if it offers a variety of flavors and scents that
continue to evolve as it develops.
Flabby-
A wine that lacks structure, or is heavy to the taste, lacks
acidity.
Full-Bodied- Wine high in alcohol and extract, generally speaking fills
the mouth, powerful.
Lean-
Oaky-
Generally wines that are slim, lacking of generosity or
thin.
A desirable flavor imparted to wine if done in
moderation. Most wines are aged in oak barrels 1 to 3
years, thereby receiving this toasty oak characteristic.
However, if a weak wine is left in contact too long with
an oak barrel it will tend to be overpowered with an oaky
taste.
Tannin-
Tannins are extracted from the grape skins and stems
and are necessary for a well balanced red wine. Tannins
are easily identified in wine tasting as the drying
sensation over the gums. Tannins generally fade as a
wine ages.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Safety Precautions
Do not attempt to install or operate your Wine Captain until you
have read the safety precautions. The precautions are labeled with
DANGER, WARNING OR CAUTION.
DANGERS - Indicate hazards or unsafe practices which could
result in severe personal injury or death.
WARNINGS - Indicate hazards or unsafe practices which could
result in personal injury or death.
CAUTIONS - Indicate hazards or unsafe practices which could result
in damage to the Wine Captain.
DANGER
!
RISK OF CHILD ENTRAPMENT: Before you discard your
Wine Captain, remove the door and leave the shelves in place
so that children may not easily climb inside.
WARNING
!
Never attempt to repair or perform maintenance on the Wine
Captain until the electricity has been disconnected.
Do not alter or deform electrical plug in any way. The use of an
extension cord is not recommended.
Altering, cutting of power cord, removal of power plug, or
direct wiring can cause serious injury, fire, and/or loss of prop-
erty and/or life and will void the warranty.
CAUTION
Do not lift unit by door handle.
Failure to clean the condenser on a regular basis can cause the
Wine Captain to malfunction. This could void the warranty.
The unit must not be installed behind closed doors. Be sure the
front grille is free of obstruction. Obstructing free air flow can
cause the Wine Captain to malfunction, and may void the war-
ranty.
Use only genuine factory replacement parts.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
The Wine Captain is manufactured in two different sizes. The
15WC will accommodate thirty two (32) 750 ml wine bottles and the
75WC will accommodate sixty (60) 750 ml wine bottles. Unless other-
wise noted all documentation pertains to both units.
Grille Installation
The lower grille should be affixed prior to installing the Wine
Captain. To affix the grille complete the following:
1. With a standard blade screwdriver, remove the screw (located toward
the middle of the unit, below the door) needed to attach the grille.
2. If the control knob is located in the grille area, remove it by pulling it
toward you.
3. Carefully remove the grille from inside the unit. A small screw hole
is located toward the top of the middle recessed section of the grille.
4. Place the two hook-hinges (located on the rear bottom side of the
grille) on the front lip of the unit base. Swing the grille up into
position, aligning the grille and cabinet screw holes.
5. The control knob may only be installed correctly. If you have to force
the installation of the knob you may not have it properly aligned with
the two control knobs.
Preparation
Your Wine Captain may be installed as a built-in or freestanding unit.
It uses a front vented fan cooled condenser system which provides the
ability to be built-in tightly without the need for additional clearance on
the sides, top or rear for ventilation. It is recommended that you leave a
minimal amount of clearance to install and remove the Wine Captain in
the event service is required.
The Wine Captain must not be installed behind closed doors. The
front grille must be free from obstruction. Obstructing free air flow can
cause the Wine Captain to malfunction and may void the warranty.
For the best performance the location of the Wine Captain should
not be in direct sun light or near a heat source.
Level Installation
Position the unit on a flat, level surface, capable of supporting the
entire weight of the unit when full.
75WC and 15WC
This unit contains four adjustable leveling legs. Turn the legs
clockwise to raise and counterclockwise to lower.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Electrical Requirement
Provide a 115 volt, 60 cycle, AC only (normal household) three prong
grounded electrical outlet. DO NOT use an extension cord. DO NOT use
an adapter to bypass the ground. DO NOT alter or deform the electrical
plug in any manner.
Reversing The Door
Depending upon the location of the unit, it may be desirable to
change the side on which the door is mounted.
To reverse the door mounting on the 15WC Wine Captain, perform
the following:
1. Remove top hinge from cabinet (3 screws).
2. Lift door off bottom hinge.
3. Remove bottom hinge from cabinet (2 screws) and install on opposite
side of cabinet.
4. Remove top hinge plate (2 screws) from door and install on bottom,
opposite side of door.
5. Remove bottom hinge plate (2 screws) from door and install on top
opposite side of door.
6. Replace plastic spacer on bottom hinge and set door in place.
7. Replace plastic spacer on top hinge and install top hinge on cabinet.
8. Adjust as required to assure proper door seal.
To reverse the door mounting on the 75WC Wine Captain, perform
the following:
1. Remove the bottom hinge (2 screws) from door.
2. Remove top hinge (2 screws) from door.
3. Remove door.
4. Remove top hinge (3 screws) from cabinet. Invert and install on
bottom, opposite side of cabinet.
5. Remove bottom hinge (3 screws) from cabinet. Invert and install on
top, opposite side of cabinet.
6. Attach top hinge to door.
7. Attach bottom hinge to door.
8. Adjust as required to assure proper door seal.
Door Adjustment
The Wine Captain door should always be squared to the cabinet to
ensure a proper seal. To properly adjust the door, please follow this
procedure:
1. Loosen (do not remove) the three screws in the door hinge
plate on the top of the cabinet.
2. Align the door so that it is squared to the cabinet.
3. Tighten the three screws on the top hinge plate.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Operation
Initial Start-Up
The Wine Captain is designed to provide different temperature
zones within the cabinet. (See introduction for specific temperatures.)
This is done so that different types of wine may be maintained at varying
temperatures. The coolest temperature is at the bottom and it is warmer
at the top of the cabinet. White and sparkling wines should be
maintained on the bottom to middle racks and red wine on the top racks.
Your Wine Captain is preset for a mid point setting (4-1/2) in order
to achieve the recommended temperature range when installed in a 72°F
ambient room temperature. To achieve a warmer setting turn the control
counter clockwise (lower number) and clockwise (higher number) for a
cooler temperature.
Factors which affect the internal temperatures of the cabinet include:
1. Temperature setting.
2. Room temperature where installed.
3. The number of times the door is opened and closed.
4. The amount of time the internal light is illuminated. This affects
primarily wines on the top racks.
5. Installation in direct sun light or near a heat source.
Stocking Recommendations
The wine racks allow for the proper horizontal storage of wine. The
bottles are properly positioned so that the wine remains in contact with
the cork to assure that the cork does not become dry.
The racking system is designed with three parallel braces (rear,
middle, and front) per shelf. The procedure listed below may be used to
load your Wine Captain.
75WC
Start at the left hand side of the
shelf and place the first bottle on
the rear and middle parallel braces
with the neck facing towards the
tinted glass door. The next bottle
should be placed on the front and
middle parallel braces with the neck
facing towards the rear. Alternate
this stocking sequence moving left
to right on the shelf.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
The same stocking procedure may be used on all remaining full
shelves. The bottom half-shelf wine bottles should be stocked crosswise.
15WC
Start at the left hand side of the shelf and
place the first bottle on the front and middle
parallel braces with the neck facing towards the
rear. The next bottle should be placed on the
rear and middle parallel braces with the neck
facing the tinted glass door. Alternate this
stocking procedure left to right.
The same stocking procedure may be used
on all full shelves. The bottom half-shelf wine
bottles should be stocked crosswise.
Door Lock
All Origins Wine Captains contain a door lock located in the mid-
dle of the upper portion of your door. The lock is a deterrent to keep
children out and is not intended to keep your valuable wine collection
safe. The reversing of the door will not effect the locking mechanism.
Additional keys may be ordered as a separate part.
Light Switch and Bulb
Your Wine Captain has an interior light that is illuminated when the
door is opened. If you wish to display your wines for those “special
occasions” while the door is closed just depress the switch located below
the control knob in the grille to the ON position.
Please note that when the light is on for an extended perior of time
it will slightly increase the cabinet temperature.
Bulb Replacement
To replace the light bulb:
1. Remove the light housing cover
1
by sliding the cover towards the
tab, swinging the end opposite
of the tab down and pulling
down and away.
2. Replace bulb with genuine
U-Line replacement.
TAB
2
3. Replace the light housing cover
by inserting the tab FIRST and
pushing up the other end. You
should hear a snap/click.
3
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Cleaning And Maintenance
Periodic cleaning and proper maintenance will ensure efficiency and
top performance.
Interior - The Wine racks may be removed by removing the security
tabs at the rear of each rack if desired. Clean the interior of the cabinet
with mild soap and water and rinse with clear water. The lock tabs at the
rear of the wine racks must be properly secured with the snap rivets.
The upright rear brace should not be touching the evaporator on the
rear wall of the Wine Captain.
Avoid the use of solvent cleaning agents, abrasives, and cleaners.
Exterior - The exterior may be cleaned with mild cleaners or mild
soap and water.
Glass Door - The glass door may be cleaned using a glass cleaner or
mild soap and water. Avoid use of abrasive cleaners.
Condenser - The condenser coil, located behind the front grille,
should be cleaned three to four times per year. Using a brush or vacuum
cleaner remove dirt, lint and other accumulations from the condenser
coil.
WARNING
!
The condenser fins are sharp. DO NOT run hands or fingers
over condenser fins.
To remove and replace the grille to obtain access to the condenser
fins please follow this procedure:
1. Using a standard blade screwdriver, remove the screw (located toward
the middle of the grille).
2. Remove the cabinet knob.
3. Grasp the grille in both hands and pull up and forward.
4. Clean the condenser coil using a brush or vacuum cleaner.
5. To install the grille place the two hook hinges (located on the back
bottom side of the grille) on the front lip of the unit’s base. Swing
the grille up into position, aligning the grille and cabinet’s screws.
6. Insert the grille screw and tighten being careful not to overtighten.
7. Install the control knob.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting
Before Calling For Service
If the unit appears to be malfunctioning, read through NORMAL
OPERATION first. If the problem persists, check the TROUBLE-
SHOOTING GUIDE. Locate the problem in the guide and refer to the
cause and its remedy before calling for service. The problem could be
something very simple which can be solved without a service call.
If Service Is Required
If the need for service arises, contact the dealer from whom the
unit was purchased. State the Model and Serial number and explain
the problem. The Model and Serial number plate is located inside unit
at upper right hand corner.
If you do not know the name of the selling dealer or local service com-
Replacement Parts
Use only genuine U-Line replacement parts. Genuine U-Line
parts are designed to work correctly with U-Line products and offer
superior service life. The use of non-U-Line parts can damage the unit
and may void the warranty.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Troubleshooting Guide
WARNING
!
Never attempt to repair or perform maintenance on the unit
until the main electrical power has been disconnected.
PROBLEM
POSSIBLE CAUSE
REMEDY
Unit not cold enough.
Control set too
warm
Turn control knob
CLOCKWISE to set
temperature colder:
Allow 24 hours for
temperature to stabilize
Check temperatures
(see introduction for
specific temperatures)
Light staying on
Adjust door so light
switch bracket contacts
switch plunger: See
DOOR ADJUSTMENT
Airflow to front
grille blocked
Airflow must not be
obstructed to front grille.
See INSTALLATION
Dirty condenser
coils
Clean condenser:
See CLEANING AND
MAINTENANCE
Door gasket not
sealing properly
Adjust door: See
DOOR ADJUSTMENT
Unit is too cold.
Control set too cold Turn control knob
COUNTER-CLOCKWISE
Check temperatures
(see introduction for
specific temperatures)
to set temperature
warmer: Allow 24 hours
for temperature to
stabilize.
No interior light
Loose or burned
out bulb
Tighten or replace
bulb: See BULB
REPLACEMENT.
Light won’t go out
when door is closed
Light on/off switch
is turned to ON.
Turn switch to off.
See LIGHT SWITCH
AND BULB.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
P. O. Box 245040
Milwaukee, Wisconsin 53224-9540
(414) 354-0300
FAX (414) 354-7905
P/N 41739 (Rev. 5/03)
Download from Www.Somanuals.com. All Manuals Search And Download.
|