INSTRUCTION
BOOK
GAS
COOKER
SG211X
Download from Www.Somanuals.com. All Manuals Search And Download.
Important safety information
•
The cooker gets hot when it is in use.
Children should be kept away until it has
cooled.
You MUST read these warnings carefully
before installing or using the appliance. If
you need assistance, contact our Customer
Care Department on 08705 950950.
•
•
Children can also injure themselves by
pulling pans or pots off the cooker.
This appliance is not intended for use by
persons (including children) with reduced
physical, sensory or mental capabilities, or
lack of experience and knowledge, unless
they have been given supervision or
instruction concerning use of the
appliance by a person responsible for their
safety.
Installation
•
This cooker must be installed by qualified
personnel, according to the manufacturer’s
instructions and to the relevant British
Standards.
•
•
•
•
•
This cooker is heavy. Take care when
moving it.
Any gas installation must be carried out by a
registered CORGI installer.
During Use
•
This appliance is intended for cooking
purposes only. It must not be used for
other purposes, for example room heating,
commercial or industrial purposes.
When in use a gas cooker will produce
heat and moisture in the room in which it
has been installed. Ensure there is a
continuous air supply, by keeping air vents
in good condition or installing a cooker
hood with a venting hose.
When using the cooker for a long period
time, the ventilation should be improved,
by opening a window or increasing the
extractor speed.
Any electrical installation must be carried out
by a qualified electrician/competent person.
Remove all packaging before using the
cooker.
This cooker must not be connected to a
combustion products evacuation device. It
shall be installed and connected in
accordance with current installation
regulations. Particular attention shall be given
to the relevant requirements regarding
ventilation.
•
•
•
•
This cooker is designed to be connected to a
230-240V, 50Hz electrical supply.
• Do not use this cooker if it is in contact with
water. Do not operate the cooker with wet
hands.
• The grill pan will become hot during use,
always use oven gloves when removing or
replacing a hot grill pan.
Ensure that the gas and electrical supply
complies with the type stated on the rating
plate, located near the gas supply pipe.
Do not attempt to modify the cooker in any
way.
•
•
Ensure the control knobs are in the ‘OFF’
position when not in use.
When using other electrical appliances,
ensure the cable does not come into
contact with the hot surfaces of the
cooker.
Child Safety
This cooker is designed to be operated by
•
•
adults. Do not allow children to play near
or with the cooker.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Environmental Information
•
Unstable or misshapen pans should not be
used on the hob burners as unstable pans
can cause an accident by tipping or
spillage.
•
After installation, please dispose of the
packaging with due regard to safety and
the environment.
•
•
•
Never leave the cooker unattended when
cooking with oil and fat.
Never pull the appliance by the oven
handle.
This cooker should be kept clean at all
times. A build-up of fat or foodstuff could
result in a fire.
Never use steam or high pressure
appliances for cleaning the oven.
Never use plastic dishes in the oven or on
the hob burners. Never line any part of the
oven with aluminium foil.
Always ensure that the oven vent, which is
located at the centre back of the hob, is left
unobstructed to ensure ventilation of the
oven cavity.
Perishable food, plastic items and aerosols
may be affected by heat and should not be
stored above the cooker.
•
When disposing of an old appliance,
make it unusable, by cutting off the cable.
The symbol
on the product or on its
packaging indicates that this product may not
be treated as household waste. Instead it shall
be handed over to the applicable collection
point for the recycling of electrical and
electronic equipment. By ensuring this product
is disposed of correctly, you will help prevent
potential negative consequences for the
environment and human health, which could
otherwise be caused by inappropriate waste
handling of this product. For more detailed
information about recycling of this product,
please contact your local city office, your
household waste disposal service or the shop
where you purchased the product.
•
•
•
•
Keep this instruction book for future
reference and ensure it is passed on to any
new owner.
Service
•
This cooker should only be repaired or
serviced by an authorised Service
Engineer and only genuine approved
spare parts should be used.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Instructions for the user
Use and care
Control panel
SG211X
2
3
4
5
6
1
1. Back left burner control knob
2. Front left burner control knob
3. Front right burner control knob
4. Back right burner control knob
5. Ignition switch
6. Oven/Grill burner control knob (selector)
Hob
1
2
4
3
1. Back left burner (auxiliary)
2. Front left burner (rapid)
3. Front right burner (semi-rapid)
4. Back right burner (semi-rapid)
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Use of appliance
Before the First Use of the Cooker
The oven has four shelf levels, and is
supplied with one shelf.
The shelf positions are counted from the
bottom of the oven as shown in the
diagram.
Remove all packaging both inside and
outside of the cooker, before using it.
Before first use, the oven should be heated
without food. During this time, an unpleasant
odour may be emitted. This is quite normal.
1. Remove the oven accessories and ensure
all packaging has been removed.
Oven Safety device
The cooker features a thermocouple; if for
any reason the flame should extinguish, the
device will stop the gas flow.
2. Ignite the oven burner (see instructions)
and turn the control knob to maximum.
3. Open a window for ventilation.
4. Allow the oven to run empty for
approximately 45 minutes.
This procedure should be repeated with the grill
function for approximately 5-10 minutes.
Use
The oven can be used for traditional
cooking, or for grilling, but not both functions
simultaneously.
The symbol on the knob corresponds to the
symbol on the control panel.
Off
Using the Oven
“8”
Maximum
“1” Minimum
Grill function
The cooker gets hot when it is in use.
Children should be kept away until it has
cooled.
Stand clear when opening the drop down
oven door. Do not allow it to fall open -
support the door using the door handle, until
it is fully open.
Attention: when turning on the oven and grill
burner the oven door has to be opened.
4
3
2
1
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Ignition
If for any reason the flame should extinguish
turn the control knob to the off position, after at
least 1 minute, try to re-ignite the oven.
To adjust the flame, turn the oven knob to the
position corresponding to the temperature
desired, after a few minutes of operation.
Attention: when turning on the oven and
grill burner the oven door has to be opened.
•
Open the oven door, push and turn the
control knob to the left to position 8,
keeping the control knob pressed.
Turning off the oven burner
•
At the same time, push the electronic
ignition knob (see fig). Keep it pushed until
the gas ignites (1 spark / second).
Turn the knob clockwise to mark « ».
Cooking in the Oven
Traditional cooking is made by natural
convection; the heated air circulates on the
principle of ascending and descending
draughts. It is necessary to pre-heat the oven.
All cookers vary and it is important to be
aware of the approximate cooking
temperatures before you use the cooker.
The chart shows the gas mark
•
Release the knob after 10 seconds and
check that the burner is ignited through the
holes in the burner cover.
temperatures
together
with
the
approximate equivalent temperatures in oC.
OR
It may be necessary to adjust the temperature
to suit your individual requirements. Only
experience will enable you to determine the
correct setting for your personal requirements.
During a power cut
•
Open the oven door, push and turn the
control knob to the left to position 8, and
hold a flame near the hole in the bottom;
Release the knob after 10 seconds and
check that the burner is ignited through the
holes in the burner cover.
•
Gas Mark
Temperature oC
1
2
3
4
5
6
7
8
150
165
180
195
205
220
235
250
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Using the Grill
•
Upon ignition, keep the knob pressed for
approximately 10 seconds (until the
safety valve automatically keeps the grill
burner lit).
When grilling, the accessible parts of the
appliance are hot and the appliance should
not be left unattended. Take care that
children do not play near it. While the grill is
operating leave the oven door half open and
put the grill deflector “A” into place.
OR
During a power cut
•
•
Open the oven door.
Hold a flame to the gas grill burner holes
(see fig.).
•
Press the oven/grill function control knob,
then turn it to the “grill symbol”. Upon
ignition, keep the knob pressed for
approximately 10 seconds (until the
safety valve automatically keeps the
grill burner lit).
A
Grill burner ignition
Attention: when turning on the oven and
grill burner the oven door has to be opened.
OR
During a power cut
•
•
•
Open the oven door push and turn the
control knob to the right to the “grill symbol”
and keep the control knob pressed.
At the same time, push the electronic
ignition knob (see fig). Keep it pushed until
the gas ignites (1 spark / second).
Open the oven door.
Hold a flame to the gas grill burner holes
(see fig.).
Press the oven/grill function control knob,
then turn it to the “grill symbol”. Upon
ignition, keep the knob pressed for
approximately 10 seconds (until the
safety valve automatically keeps the
grill burner lit).
•
•
If for any reason the flame should extinguish
turn the control knob to the " " position, leave
for at least 1 minute and then re-ignite.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
•
•
Slide the roasting grid in the guide 4 and
the roasting tray in the guide 3.
When the first side is brown, turn the
meat without pricking it in order that the
juices are not lost.
The grill pan will become hot during use,
always use oven gloves when removing or
replacing a hot grill pan.
•
Grill the second side.
Grilling
Cooking time is determined by the thickness
of the piece to be grilled not by its weight.
When using the grill it has to be supervised,
the oven door opened and the grill deflector
“A” in its place.
4
3
When grilling, only the top burner is heating. It is
not necessary to preheat the grill.
2
1
•
•
•
Insert the grill pan on the fourth level.
Turn the knob to position “grill”.
Adjust the grid and pan position to allow for
different thicknesses of food. Position the
food close the grill for faster cooking and
further away for gentler cooking.
Browning
•
•
•
Turn the oven/grill control knob to the
“grill” position.
Place the dish on the grid and slide it on
shelf guide 4.
Leave the dish under the grill for a few
minutes.
Heat comes from the top of the oven. It is
suitable for grilling meat (beef bacon, pork
bacon …) that remains tender, for toast or to
brown dishes already cooked dishes.
Grilling meat
When using the grill it has to be supervised,
the oven door opened and the grill deflector
“A” in its place.
•
Prepare the meat to be grilled, lightly brush it
with oil on both sides.
•
•
Place it on the roasting grid.
Turn the oven/grill control knob to position
“grill”.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Cooking chart\
Preheating
Thermo-
Cooking
Time
Tray type or
dimension
(dxwxh) cm
No.
of
tray
Material of
the tray
Shelf
position
Thermo
-stat
pos.
Food
Time
stat
(min)
(min)
pos.
Roasting meal
20 min. for each 0.5 Kg / rare
- beef
1
3
5
20
5
25 min. for each 0.5 Kg/ medium
30min. for each 0.5 Kg/well done
25 min. for each 0.5 Kg/ medium
30min. for each 0.5 Kg/well done
30 min. for each 0.5 Kg/ medium
35min. for each 0.5 Kg/well done
Roasting tray
delivered with Enamelled
the cooker
- lamb
1
1
3
3
5
5
20
20
5
5
- pork and veal
Poultry
- chicken
1
1
1
1
3
3
3
3
5
4
4
5
20
20
20
20
5
5
5
5
25-30 min. for each 0.5 Kg
25 min. for each 0.5 Kg
25 min. for each 0.5 Kg
25 min. for each 0.5 Kg
Roasting tray
delivered with Enamelled
the cooker
- turkey below 4.5 Kg
- turkey over 4.5 Kg
- duck
Cakes
- scones
33x28x0.6
33x28x0.6
Ø 26x5
Aluminum
Aluminum
Aluminized
2
1
1
1
2 and 4*
3***
8
8
4
1
20
20
15
15
8
8
4
1
15-20
15-20
- fettles sponge cake
- rich fruit cake
3***
30-40
Ø 23x7.6
Tinned
steel
3***
120-140
- small cake
33x28x0.6
33x28x0.6
Aluminum
2
1
2
1
2
1
2 and 4*
3***
4
4
15
15
15
15
15
15
4
4
30-40
30-40
20-30
20-25
70-90
70-90
Aluminum
- Victoria sandwich
- apple pie
Ø 20.5x3.5 Aluminized
Ø 20.5x3.5 Aluminized
2 and 4*
3***
5
5
5
5
Ø 20x5
Ø 20x5
Aluminized
Aluminized
3**
5 - 6
5
5 - 6
5
3***
Yeast mixture
- bread 1.35 Kg
19.5x9.3x5.5
19.5x9.3x5.5
Tinned
steel
Tinned
steel
3
1
3
7
7
20
20
7
7
35-45
30-40
- bread 0.45 Kg
1***
NOTE: d = deepness; w = width; h = height
Remarks: The recommended cooking conditions give the best results.
* if you should cooking more than one tray, you can take the top tray out of the oven when the
cakes are finished and move the lower tray to the higher shelf to finish the cooking (about 5 min.)
** these two pans are positioned on the same shelf, at the diagonal of the oven grid
*** put the dishes in the center of the shelf
The dishes indicated for cakes and yeast mixture you can find in the shops.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
•
Upon ignition, adjust the flame as required.
Using the Hob
OR
The Hob Burners
The symbol on the control panel shows which
burner is operated by the knob. (See control
panel).
Off
Power Cut
•
Push the corresponding knob in
completely and turn it left to the “large
flame“ symbol and ignite with a match.
Release the knob and check that the
burner has ignited.
•
•
Maximum level
Upon ignition, adjust the flame as required.
Minimum level
If for any reason the flame should extinguish
turn off the relevant control knob, leave for at
least one minute and then re-ignite.
If after a few attempts the burner does not
ignite, check that the burner ring and its cap
are correctly positioned.
Turning off the burners
Turn the control knob clockwise to mark « ».
Use the maximum level for boiling and the minimum
for simmering.
Always choose positions between the minimum
and maximum, never between maximum and off.
Do not put anything on the hob that is
liable to melt.
Selecting the Correct burner
Above every knob there is a symbol for the
Ignition of the burners
•
•
Push the knob and turn it left to the “large flame“
symbol.
At the same time, push the electronic ignition
knob (see fig). Keep it pushed until the gas
ignites (1 spark / second).
corresponding burner.
For good cooking results, always choose
pans, which correctly fit to the diameter of the
burner used (see figs). Choose thick, flat
bottom pots.
We recommend the flame is lowered as soon
as the liquid starts boiling.
•
Release the knob and check that the burner
has ignited.
Good use
Bad use
(Power waste)
11
Download from Www.Somanuals.com. All Manuals Search And Download.
For a correct ignition always keep the burner ring
and the spark plugs clean.
In addition to the accessories supplied we
recommend you only use heatproof
dishes/pans (according to the manufacturer’s
instructions).
The following diameter pans can be used:
Power
(kW)
3,00
Diameter (mm)
Burner
min.
max.
280
240
180
Rapid
160
140
120
Semi-Rapid 2,00
Auxiliary 1,00
Accessories delivered with the appliance
The following accessories are supplied with your
appliance.
•
Grill Deflector
To be used when the grill is operation.
Shelf for placing dishes on (roast, pastry
mounds)
•
The dish should be put in the middle of the
shelf to balance the weight.
•
•
A roasting tray with roasting grid on it.
It is used to collect juice when cooking in it,
place it on the shelf 2.
If you do not use the roasting tray, remove it
from the oven.
Removable handles
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Hints and Tips
Condensation and steam
•
The thickness, the material and the colour
of the pan will influence the cooking
results.
When cooking, certain dishes increase in
volume, ensure the pan is large enough.
To prevent fat dripping when roasting use
tall rim pans proportional to the item being
roasted.
When food is heated it produces steam in the
same way as a boiling kettle. The oven vents
allow some of this steam to escape. However,
always stand back from the oven when
opening the oven door to allow any build up of
steam or heat to release.
If the steam comes into contact with a cool
surface on the outside of the oven, e.g. a trim, it
will condense and produce water droplets. This is
quite normal and is not a fault with the oven.
To prevent discolouration, regularly wipe away
condensation and also soilage from surfaces.
•
•
•
•
Prick the skin of poultry and sausages with
a fork before cooking to avoid spitting.
Use heatproof glass dishes for soufflés.
The effects of dishes on cooking results
Dishes and tins vary in their thickness,
conductivity, colour, etc. which affects the way
they transmit heat to the food inside them.
Cookware
Use any ovenproof cookware, which will
withstand temperatures of 250°C.
A
Aluminium, earthenware, oven glassware
and bright shiny utensils reduce cooking
and base browning.
Oven dishes, etc. should not be placed
directly on the oven base.
Oven Cooking
B
Enamelled cast iron, anodised aluminium,
aluminium with non-stick interior and
coloured exterior and dark, heavy utensils
increase cooking and base browning.
•
Turn off the oven 5 minutes before the end of
cooking time, and use residual heat to
complete the cooking.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Maintenance and cleaning
•
•
Household detergent and bleaches
Impregnated pads unsuitable for non
stick saucepans
The oven should be kept clean at all times. A build-
up of fats or other foodstuffs could result in a fire.
Before cleaning, ensure all control knobs are in
the OFF position, and the appliance has cooled
completely.
•
•
•
•
Brillo/Ajax pads or steel wool pads
Chemical oven pads or aerosols
Rust removers
Bath/Sink stain removers
Before any maintenance or cleaning can be
carried out, you must DISCONNECT the cooker
from the electricity supply.
Oven Cavity
The enamelled oven cavity is best cleaned whilst
the oven is still warm.
Wipe the oven over with a soft cloth soaked in
warm soapy water after each use. From time to
time it will be necessary to do a more thorough
cleaning, using a proprietary oven cleaner.
Cleaning materials
Before using any cleaning materials on your oven,
check that they are suitable and that their use is
recommended by the manufacturer.
Hob
After every use wipe with a soft cloth well wrung
out in warm water to which a little washing up
liquid has been added, avoiding any leakage
through the holes of the hob. Rinse and dry with
a soft cloth.
Cleaners that contain bleach should NOT be
used as they may dull the surface finishes. A
steam cleaner is not to be used. Harsh
abrasives should also be avoided.
To remove more stubborn stains, wet and leave
to dissolve, do not scratch and avoid the use of
abrasive or caustic products that could damage
the enamel.
External cleaning
We recommend for cleaning cleaners that do not
scratch the surface; Avoid use of metall objects,
steel wool or nylon pads, abrasive or caustic
products, or diluents. Regularly wipe over the control
panel, oven door and door seal using a soft cloth
well wrung out in warm water to which a little
washing up liquid has been added.
In the case of stainless steel parts, you may use
commercially available stainless steel cleaners with
care. These also provide a protective film against
finger marks.
Burners
The burner caps and crowns can be removed for
cleaning. Wash the burners caps and crowns using
hot soapy water, and remove marks with a mild
paste cleaner. A well-moistened soap impregnated
steel wool pad can be used with caution, if the
marks are particularly difficult to remove.
After cleaning, be sure to wipe dry with a soft cloth.
To prevent damaging or weakening the door
glass panels avoid the use of the following:
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Oven door
Removing oven door from its hinges
To make it easier to clean the oven, the oven
door can be removed.
Open the oven door into the horizontal position.
Then lift up the clips on the two door hinges as
far as they will go (a).
Slowly close the door again as far as the stop
and lift the door until the hinges come out (b).
Replacing the oven door on its hinges
When putting the door back on its hinges,
reverse the procedure for removing the door from
its hinges.
Re-insert the door’s hinges into the slots (c).
When you do this, make sure the hinges engage
properly and evenly.
Then slowly lower the door downwards. When
you do this, make sure the corners of the door do
not touch the bottom of the frame (if this
happens, lift the door up again and realign the
hinges).
Finally fold the clips back down towards the oven
(d). So that the door closes properly, press down
on the clips with something (e.g. a screwdriver)
(e).
Slowly check the correct operation of the door.
Important: Never leave the door hinge levers
standing up. Otherwise the spring action can lead
to injury.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Something not working
If the appliance is not working correctly, please
carry out the following checks, before contacting
your local Service Force Centre.
IMPORTANT: If you call out an engineer to a
fault listed below, or to repair a fault caused by
incorrect use or installation, a charge will be
made even if the appliance is under guarantee.
Symptoms
Solutions
1. No burner ignition
Check that:
•
•
•
•
Gas supply is completely open
The position of gas pipe is correct
The burner is not wet
The burner cap and ring burner have been replaced
correctly after cleaning
2. The gas ring burns unevenly Check that:
•
The main jet is not blocked and the ring burner is clean of
food particles
•
The burner cap and ring burner have been replaced
correctly after cleaning
3. One of the oven or grill Check that:
burners does not ignite
•
•
•
The burner is in its correct place
The burner is not wet
The control knob has been pressed for 10 seconds upon ignition
4. Cooking results are not Check that:
satisfactory
•
•
•
The correct temperature has been selected
The cooking time is adapted
The grill is placed correctly in the oven
5. Cooking time is too long
6.The oven smokes
Check that:
•
The temperature is correct for the type of food to be cooked.
Check that:
•
•
•
•
The oven does not need cleaning
The food does not spill over
There is no excessive fat / juice on the oven sides
Check the fuses.
If after these checks, the appliance still does not
operate correctly, contact your local Service Force
Centre. When you contact the Service Force Centre
you will need to give the following details:
1. Your name, address and post code.
2. Your telephone number
4. The model and serial number of the
appliance (found on the rating plate*)
5. The purchase date
* The rating plate can be found on the lower
left hand corner of the front frame of the cavity.
Please note that a valid purchase receipt or
guarantee documentation is required for in-
guarantee service calls.
3. Clear and concise details of the fault
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Service and spare parts
Zanussi-Electrolux
Electrolux Group (Ire) Ltd
Long Mile Road
Dublin 12
Republic of Ireland
In the event of your appliance requiring service,
or if you wish to purchase spare parts, please
contact your local Service Force Centre by
telephoning:-
Tel: + 353 (0) 1 4090 751
Email: [email protected]
08705 929929
Your telephone call will be automatically routed to
the Service Force Centre covering your post
code area.
For the address of your local Service Force
Centre and further information about Service
electrolux.co.uk
In-guarantee customers should ensure that
the checks under the heading “Something
Not Working” have been made as the
engineer will make a charge if the fault is
not a mechanical or electrical breakdown.
Please note that it will be necessary to
provide proof of purchase for any in-
guarantee service calls.
For Customer Service in the Republic of Ireland
please contact us at the address below:
Customer care
For general enquiries concerning your Zanussi-
Electrolux appliance and or for further information
on our products, contact our Customer Care
Department by letter or telephone at the address
below:
Tel: 08705 727727 (*)
(*) calls to this number may be recorded for
training purposes.
Major Appliances - Customer Care Department
To buy accessories, consumables and spare
parts at our online shop please visit:
Zanussi-Electrolux
Addington Way
Luton
Bedfordshire
LU4 9QQ
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Guarantee conditions
Standard Guarantee Conditions
Products of Zanussi-Electrolux manufacture
which are not marketed by Zanussi-
Electrolux.
We Zanussi-Electrolux undertake that if, within 12
months of the date of the purchase, this Zanussi-
Electrolux appliance or any part thereof is proved to
be defective by any reason only of faulty
workmanship or materials, we will, at our option,
repair or replace the same FREE OF ANY CHARGE
for labour, materials or carriage on condition that:
European Guarantee
If you should move to another country within
Europe then your guarantee moves with you to
your new home subject to the following
qualifications:
•
•
•
•
The appliance has been correctly installed and
used only on the electricity supply stated on the
rating plate.
The appliance has been used for normal
domestic purposes only, and in accordance with
the manufacturer's instructions.
The appliance has not been serviced maintained,
repaired, taken apart or tampered with by any
person not authorised by us.
All service work under this guarantee must be
undertaken by a Zanussi-Electrolux Service
Force Centre.
•
The guarantee starts from the date you first
purchased your product.
The guarantee is for the same period and to
the same extent for labour and parts as exist
in the new country of use for this brand or
range of products.
This guarantee relates to you and cannot be
transferred to another user.
Your new home is within the European
Community (EC) or European Free Trade
Area.
•
•
•
•
•
Any appliance or defective part replaced shall
become the Company's property.
This guarantee is in addition to your statutory and
other legal rights.
•
The product is installed and used in
accordance with our instructions and is only
used domestically, i.e. a normal household
The electrical supply complies with the
specification given in the rating label.
The product is installed taking into account
regulations in your new country.
•
•
Home visits are made between 8.30am and 5.30pm
Monday to Friday. Visits may be available outside
these hours, in which case a premium will be charged.
Before you move, please contact your nearest
Customer Care Centre, listed below, to give them
details of your new home. They will then ensure
that the local Service Organisation is aware of your
move and able to look after you and your
appliances.
Exclusions
This guarantee does not cover:
•
•
•
Damage or calls resulting from transportation,
improper use or neglect, the replacement of any
light bulbs or removable parts of glass or plastic.
Costs incurred for calls to put right an appliance
which is improperly installed or calls to appliance
outside the United Kingdom.
Appliances found to be in use within a
commercial or similar environment, plus those,
which are the subject to rental agreements.
France Senlis
Germany Nürnberg +49 (0) 800 234 7378
Italy Pordenone +39 (0) 800117511
Sweden Stockholm +46 (0) 20 78 77 50
UK Luton +44 (0) 8705 727727
+33 (0) 3 44 62 20 13
18
Download from Www.Somanuals.com. All Manuals Search And Download.
Instructions for the installer
Technical features
Free standing
Class 1
Hob
Pan support
Enamelled
Semirapid
Semirapid
Rapid
Front right burner
Back right burner
Front left burner
Back left burner
Hob ignition
2000 W
2000 W
3000 W
1000 W
Spark
Auxiliary
Oven
Oven
Oven burner power
Grill
Gas
3000 W
Gas
Grill burner power
Oven ignition
Cleaning
2000 W
Spark
Manual
Cavity dimensions Height
267 mm
405 mm
381 mm
41,2 l
Width
Depth
Oven volume
Accessories
Dimensions
Oven shelf
Roasting tray
Roasting grid +2 handles
Grill deflector
Height
Width
Depth
900 mm
500 mm
600 mm
This appliance complies with the following EEC Directives :
93/68 ; 2006/95 (Low Voltage Directive) and subsequent
modifications,
89/336, 90/31, 93/68 (Electro- magnetical Compatibility Directive)
and subsequent modifications,
90/396 (Gas Appliance Directive) 93/68 (General Directives) and
subsequent modifications.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Advice for safety
Gas connections
-
-
Specification for installation of low
pressure gas pipe work of up to 20mm
(R1) in domestic premises (2nd family
gas) – BS 6891 Current editions;
Pipe threads for tubes and fittings where
pressure-tight joints are made on the
threads (metric dimensions) – BS 21
Current editions;
Flexible hoses, end fittings and sockets
for gas burning appliances – BS 669
Current editions;
Installation of domestic gas cooking
appliances (1st, 2nd and 3rd family gases)
– BS 6172: 1990 Current editions;
•
Before installation ensures that the local
distribution conditions (gas type and
pressure) and the pre-setting of the appliance
are consistent.
•
•
This appliance must be installed only in a
room with good ventilation.
This appliance must not connect to a
chimney. It has to be installed and connected
in accordance with the rules in force. Special
attention should be paid to the applicable
disposal concerning ventilation.
-
-
•
•
The adjacent furniture panels have to be heat
proof or protected by such material.
The adjusting conditions of this appliance are
mentioned on the rating plate.
For appliances installed in the Republic of
Ireland please refer to NSAI-Domestic Gas
Installation IS813 Current editions.
Connection to gas supply.
Electrical connections
Check that the gas flow and the diameter of the
supply pipe is sufficient to supply all the
appliances of the installation.
•
•
Check that all connections are tight.
Install an accessible and visible gas tap to
isolate the appliance.
Any electrical work required to install this
cooker should be carried out by a qualified
electrician or competent person, in
accordance with the current regulations.
THIS COOKER MUST BE EARTHED.
The manufacturer declines any liability
should these safety measures not be
observed.
The manufacturer declines any responsibility
for possible damages resulting from an
installation, which doesn't comply with
current legislation.
This cooker is designed to be connected to a
230-240V AC 50Hz electrical supply.
Before switching on, make sure the electricity
supply voltage is the same as that indicated on
the cooker rating plate. The rating plate is
located on the oven frame.
-
Installation of flues and ventilation for gas
appliances of rated input not exceeding 60
kW (1st, 2nd and 3rd family gases) – Part 2
Specification for installation of ventilation for
gas appliances – BS 5440 Current editions;
Gas burning appliances – Part 3 Domestic
cooking appliances burning gas – BS 5386
Current editions;
-
20
Download from Www.Somanuals.com. All Manuals Search And Download.
The cooker is supplied with a 3 core flexible
supply cord incorporating a 13amp plug fitted. In
the event of having to change the fuse, a 13amp
ASTA approved (BS 1362) fuse must be used.
Should the plug need to be replaced for any
reason, the wires in the mains lead are coloured
in accordance with the following code:
Before connecting check that:
• The plug used for connection is
easily accessible when the
appliance is installed.
Green and Yellow
Blue
Brown
- Earth
- Neutral
- Live
-
Connect the green and yellow (earth) wire to
the terminal in the plug, which is marked
with the letter 'E' or the earth symbol
coloured green and yellow.
or
-
-
Connect the blue (neutral) wire to the
terminal in the plug, which is marked with
the letter 'N' or coloured black.
Connect the brown (live) wire to the terminal
in the plug, which is marked with the letter 'L'
or coloured red.
Permanent Connection
In the case of a permanent connection, it is
necessary that you install a double pole switch
between the cooker and the electricity supply
(mains), with a minimum gap of 3mm, between
the switch contacts and of a type suitable for
the required load in compliance with the
current electric regulations.
NOTE: The earth wire should be about 2 cm
longer than the live and neutral wires.
Upon completion there must be no cut, or stray
strands of wire present and the cord clamp must
be secure over the outer sheath.
The switch must not break the yellow and
green earth cable at any point.
Ensure that the cooker supply cord does
not come into contact with surfaces with
temperatures higher than 50 deg. C.
A cut off plug inserted into a 13 amp socket is
a serious safety (shock) hazard.
Ensure that the cut off plug is disposed of
safety.
21
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Location of appliance
The appliance must not be installed in a bed-sitting
room of volume less than 20m3 or in a bathroom or
shower room. It is essential that the appliance is
positioned as in the enclosed figure i.e. shelves, wall
cabinets and cooker hoods must be fitted a
minimum of 690mm directly above the hob and
400mm above the hob when fitted in line with the
outside of the appliance. If the units are intended to
be fitted adjacent to the appliance but less than
400mm above the hob, then a minimum space of
100mm must be maintained between the sides of
the unit and the appliance (see fig).
If fitted next to or between two base units a
minimum space of 1mm must be left between
each unit and the sides of the appliance. The
levelling feet fitted to the appliance will achieve a
nominal height to hob of 900mm+10mm.
The cooking appliance must be fitted with a
stability chain firmly secured to the wall (see
fig).
Stability hook
Firmly fix
chain to rear
of cooker
Stability chain
Chain to be as short
as possible.
Ventilation
The room containing the cooker should have an air
supply in accordance with B.S. 5440: Part 2:
Current Editions.
The following requirements for ventilation must
be met.
The appliance must be installed in accordance
with EN 1116-1995, regarding the depth of the
superior furniture.
The cooker should not be installed in a bed sitting
room with a volume of less than 20m3, if it is
installed in a room of volume less 5m3 an air vent
of effective area of 110cm2 is required; if it is
installed in a room of volume between 5m3 and
10m3, an air vent of effective area 50cm2 is
required, while if the volume exceeds 11m3 no air
vent is required. However, if the room has a door,
which opens directly to the outside, no air vent is
required even when the volume is between 5m3
and 11m3.
max 400
100
min 600
min 570
less than
400
If there are other fuel burning appliances in the
same room, B.S. 5440: Part. 2: Current
Editions should be consulted to determine the
requisite air vent requirements.
The appliance must be set on a heatproof floor.
The adjustable feet must not be removed.
L.P.G. cookers or ovens MUST NOT be installed
below ground level, i.e. in a basement, or aboard
any boat, yacht or other vessel.
22
Download from Www.Somanuals.com. All Manuals Search And Download.
Levelling
The appliance is provided with adjustable small
feet placed in the back and front corners of the
base.
By adjusting the small feet it is possible to
change the height of the appliance so as to
ensure a better levelling with other surfaces and
a uniform distribution of the liquids contained in
pans or pots.
Gas connections
Gas connection must be carried out according to
the rules in force.
Your cooker is delivered adjusted for the kind of
gas stated on the rating plate.
If the appliance is converted to natural gas and
the pressure for natural gas is 20mbar. The
following methods of connection to the gas
supply must be used:
Right Hand Connection (from front)
Ensure that the rubber hose and power cord
not in contact with any part of the hatched
area shown in the diagram. It will be
necessary to fit the maximum length hose
when using this method.
connection
of flexible
hose
Left Hand Connection (from front)
Ensure that the rubber hose and power cord are
not in contact with any part of the hatched area
shown in the diagram and that the loop of the
hose when connected is not in contact with the
floor when the appliance is in position.
power cord
Rigid Connection
Where it is not possible to make the
connection using a rubber hose, a rigid pipe
work connection must be used.
connection
of flexible
hose
Recommendations when using an appliance
flexible connector are as follows:
- For NATURAL the gas installation pipes to
the termination point shall comply with:
Specification for installation of low-pressure
gas pipe work of up to 20mm (R1) in domestic
premises (2nd family gas) – BS 6891;
power cord
23
Download from Www.Somanuals.com. All Manuals Search And Download.
Connection shall be by means of an appliance
flexible connector for use with a self-sealing plug-
in device, complying with:
Flexible hoses, end fittings and sockets for
gas burning appliances – BS 669;
-
The appliance flexible connector should
be positioned such that it will not suffer
mechanical damage, e.g. abrasion from
the surrounding kitchen furniture, which
may be moved in use such as a drawer
or door, or by being trapped by any
stability device.
-
The appliance flexible connector should not
be subjected to undue forces either in
normal use or whilst connected or
disconnected; The socket which the plug of
the appliance flexible connector fits should
be permanently attached to a firmly fixed
gas installation pipe and positioned such
that the appliance flexible connector hose
hangs freely downwards (see fig.);
The plug-in-connector bayonet should be
accessible for disconnection after moving
the appliance.
Right angled
bayonet socket
incorporating
spring loaded
valve
Adaptor
backplate
Copper pipe
Alternative
backplate
elbow
Cooker hose with
bayonet fixing
Distributor pipe
Cooker hose with
bayonet fixing
24
Download from Www.Somanuals.com. All Manuals Search And Download.
Conversion of gas
Your cooker is designed to work with natural gas,
and is convertible for use with propane or butane.
The LPG conversion kit is available from your
Service Force Centre and must be fitted by a
Corgi Registered engineer.
•
•
adjust the minimum level (hob and oven);
check the gas connection;
Stick the label supplied with the appliance
(in the nozzles bag) corresponding to the
gas type utilised.
For changing the gas type it is necessary to:
•
replace the nozzles (hob, oven and grill);
Specification nozzles
Table no.1
(Cat: II 2H3+
)
Normal Simme
power rpower
By-
pass
(mm)
Nozzle
diameter
(mm)
Cons
g/h
Pressure
(mbar)
Burner
Gas Type
(kW)
(kW)
Natural Gas
Butane
Propane
Natural Gas
Butane
Propane
Natural Gas
Butane
Propane
Natural Gas
Butane
20
28-30
37
20
28-30
37
20
28-30
37
20
28-30
37
1.19
0,88
0,88
0.96
0,71
0,71
0.70
0,50
0,50
1.16
0,87
0,87
0,96
0,71
0,71
-
RAPID
3,00
0,72
0,42
0,32
0,29
0,52
-
218,1
214,2
-
145,4
142,8
-
72,7
71,4
-
218,1
214,2
-
SEMI-RAPID
AUXILIARY
OVEN
2,00
1,00
3,00
2,00
0,43
0,35
1,10
-
Propane
Natural Gas
Butane
20
28-30
37
GRILL
145,4
142,8
Propane
25
Download from Www.Somanuals.com. All Manuals Search And Download.
Replace the nozzles of the hob burners
The top burners do not need adjustment of
primary air.
Check that, turning the knob quickly from the
maximum position to the minimum one, the
flame does not go out.
Before any modifications or conversion to a
kind of different gas, you must DISCONNECT
the cooker from the electricity supply and
ensure that all control knobs are in the OFF
position, and the appliance has cooled
completely.
excess of
air
correct
adjustment
no air
Hob burners
•
•
•
Remove the pan supports;
Hob burners
To adjust the minimum level:
Remove the caps and the burner crowns;
Using a No 7 socket spanner unscrew the
nozzles and replace them with those
required for the type of gas in use (see table
no. 1).
•
•
Light the burner
Turn the knob to the position of the
minimum flame;
•
•
Remove the knob;
Reassemble the parts following the same
procedure in reverse.
These burners do not need any primary air
regulation.
Unscrew or screw the by-pass screw (on
the right above of tap shaft) until a regular
small flame is reached.
•
For LPG screw completely the by-pass
screw.
Reassemble the parts following the same
procedure in reverse.
Check that, when turning the knob quickly
from the maximum position to the minimum
one, the flame does not go out.
Adjustment of minimum level for the hob
burners
The burner is correctly adjusted when the flame
is stable silent and goes out without any noise.
When changing the type of gas check that the
minimum level is correct. The air admission is
correct when the flame is about 4 mm in length.
26
Download from Www.Somanuals.com. All Manuals Search And Download.
Replace the nozzles of the oven burners
Adjustment of minimum level
Oven burner
Oven burner
To replace the gas oven nozzle, follow this
procedure:
•
Light the burner knob on position
maximum and leave the oven door closed
for about 10 min.
•
•
•
•
•
Check the table no.1 for diameter of nozzle;
Remove the oven removable base panel;
Remove the screw 1 on the oven burner
Remove the oven burner by pulling it forwards.
Replace the nozzle by means of a No 7
socket spanner;
•
Turn the knob slowly to position
minimum.
•
•
Pull off the knob to adjust minimum flow.
Unscrew or screw the by-pass screw (is it
above of tap shaft) until a regular small
flame is reached.
Reassemble the parts following the same
procedure in reverse.
Before fixing of the screw 1, ensure that the oven
burner is pushed correctly to the back panel.
•
For LPG screw completely the by-pass
screw.
The flame shouldn’t extinguish when closing
the oven door.
by-pass
Grill burner
Grill burner
The grill temperature cannot be adjusted. To
obtain a lower temperature or slower cooking
time the grill pan must be lowered away from
the flame.
To replace the gas grill nozzle, follow this procedure:
•
•
•
Remove the grill burner after removing the
fixing screws.
Replace the nozzle by means of a No 7
socket spanner;
Refit all parts and test.
Before fixing of the screws, ensure that the grill
burner is pushed correctly to the back panel.
After completion of any repairs, conversion
or adjustments, the statutory safety tests
must be carried out.
27
Download from Www.Somanuals.com. All Manuals Search And Download.
Albania
+35 5 4 261 450
+32 2 363 04 44
Rr. Pjeter Bogdani Nr. 7 Tirane
Belgique/België/Belgien
Bergensesteenweg 719, 1502
Lembeek
Česká republika
Danmark
+420 2 61 12 61 12
+45 70 11 74 00
Budějovická 3, Praha 4, 140 21
Sjællandsgade 2, 7000 Fredericia
Deutschland
+49 180 32 26 622
Muggenhofer Str. 135, 90429
Nürnberg
Eesti
+37 2 66 50 030
+34 902 11 63 88
Pärnu mnt. 153, 11624 Tallinn
España
Carretera M-300, Km. 29,900
Alcalá de Henares Madrid
France
+44 8705 929 929
Great Britain
Addington Way, Luton,
Bedfordshire LU4 9QQ
Hellas
Hrvatska
Ireland
Italia
+30 23 10 56 19 70
+385 1 63 23 338
+353 1 40 90 753
+39 (0) 434 558500
4, Limnou Str., 54627 Thessaloniki
Slavonska avenija 3, 10000 Zagreb
Long Mile Road Dublin 12
C.so Lino Zanussi, 26 - 33080
Porcia (PN)
Latvija
+37 17 84 59 34
Kr. Barona iela 130/2, LV-1012,
Riga
Lietuva
+370 5 2780609
+352 42 431 301
+36 1 252 1773
Ozo 10A, LT 08200 Vilnius
Luxembourg
Magyarország
Rue de Bitbourg, 7, L-1273 Hamm
H-1142 Budapest XIV, Erzsébet
királyné útja 87
Nederland
+31 17 24 68 300
Vennootsweg 1, 2404 CG - Alphen
aan den Rijn
Norge
+47 81 5 30 222
+43 18 66 400
Risløkkvn. 2 , 0508 Oslo
Herziggasse 9, 1230 Wien
ul. Kolejowa 5/7, Warszawa
Österreich
Polska
+48 22 43 47 300
28
Download from Www.Somanuals.com. All Manuals Search And Download.
Portugal
+35 12 14 40 39 39
Quinta da Fonte - Edificio
Gonçalves Zarco - Q 35 -2774-518
Paço de Arcos
Romania
+40 21 451 20 30
+41 62 88 99 111
Str. Garii Progresului 2, S4, 040671
RO
Schweiz - Suisse - Svizzera
Industriestrasse 10, CH-5506
Mägenwil
Slovenija
+38 61 24 25 731
Gerbičeva ulica 98, 1000 Ljubljana
Slovensko
+421 2 43 33 43 22
Electrolux Slovakia s.r.o.,
Electrolux Domáce spotrebiče SK,
Seberíniho 1, 821 03 Bratislava
Suomi
Sverige
+46 (0)771 76 76 76
Electrolux Service, S:t
Göransgatan 143, S-105 45
Stockholm
Türkiye
+90 21 22 93 10 25
+7 495 937 7837
Tarlabaşı caddesi no : 35 Taksim
İstanbul
Россия
129090 Москва, Олимпийский
проспект, 16, БЦ "Олимпик"
29
Download from Www.Somanuals.com. All Manuals Search And Download.
30
Download from Www.Somanuals.com. All Manuals Search And Download.
31
Download from Www.Somanuals.com. All Manuals Search And Download.
342 732 410– 0B– 032009
Subject to change without notice
Download from Www.Somanuals.com. All Manuals Search And Download.
|