ELECTRIC HOTPLATES
MODEL
TMHPE,TMPHF
Installation and
Operation
Instructions
2M-Zꢀ2999 Rev. - Oct. ꢀ, 2009
TMHPE
TMHPF
is a registerd trademark of Toastmaster, A Middleby Company. All rights reserved.
Download from Www.Somanuals.com. All Manuals Search And Download.
GENERAL OPERATING INSTRUCTIONS
CAUTION
This equipment is designed and sold for commercial use only by personnel trained and
experienced in its operation and is not sold for consumer use in and around the home nor for
use directly by the general public in food service locations. For equipment to be used by the
general public, please contact the factory.
The Toastmaster models TMHPE & TMHPF Electric Hot Plates are equipped for the voltage
indicated on the nameplate mounted on the front panel. This unit is designed to operate on
alternating current (A.C.), two wire single phase service only.
DO NOT CONNECT TO DIRECT CURRENT (D.C.).
Total Connected Load:
TMHPF:
at 240 Volts, Wattage is 5,200
at 208 Volts, Wattage is 3,900
TMHPE:
at 240 Volts, Wattage is 4,200
at 208 Volts, Wattage is 3,ꢀ50
INSTALLATION
For your protection, we recommend that a qualified electrician install this appliance. The electrician
should be familiar with electrical installations and your local electrical requirements. The
external wiring should be in conduit or an approved type of flexible cable and of suitable size
to carry the load. The supply circuit should be properly fused and equipped with a means
of disconnecting as required by local electrical code. The body of the hot plate should be
grounded (Do not ground to a gas supply pipe). The connections are made in this unit at the
pigtail leads located in the junction box on the back of the unit. To gain access to the pigtail
leads remove cover on junction box.
LOCATE THE UNIT
Do not install the unit closer than ꢀ inch from a side wall and/or closer than ꢀ inch from a rear wall.
LEVELING UNIT
Level unit by adjusting the (4) feet for accurate and perfect line up with other Toastmaster series units.
CAUTION
DO NOT INSTALL WITHOUT FEET.
CAUTION
USE ONLY FLAT BOTTOM PANS AND POTS! DO NOT USE RAISED BOTTOM UTENSILS
OR BUCKETS! GOOD HEAT TRANSFER DEPENDS UPON GOOD CONTACT BETWEEN
THE ELEMENT AND POT.
NOTE: Using a ꢀ2” diameter or larger pan/pot may cause damage to the element or internal wiring.
Such damages are not covered by warranty. Two (2) heating elements are used. For the TMHPF each
element draws 2,600 Watts on 240 Volts and ꢀ,950 Watts on 208 Volts. For the TMHPE element
draws 2,ꢀ00 Watts on 240 Volts and ꢀ,575 Watts on 208 Volts. Each element is controlled by an
infinite position switch. The right control knob controls the rear cooking element and the left control
knob controls the front cooking element. On “HI” the element delivers uninterrupted full heat. Between
“LO” and “5” any desired amount of heat can be obtained between 6% and 60% of full heat.
Signal lights are provided above the control knobs to give a visual check if either one or both heating
units are turned on.
ꢀ
Download from Www.Somanuals.com. All Manuals Search And Download.
CLEANING
The exterior surfaces can be kept clean and attractive by regularly wiping with a clean soft cloth. Any
discoloration can be removed with a non-abrasive cleaner.
For model TMPHE, the heating elements may be raised for access to the drip pans, which may be
removed for cleaning and the bottom pan may be removed by sliding pan forward.
REPLACEMENT OF INFINITE CONTROL
BE SURE POWER IS DISCONNECTED BEFORE ATTEMPTING TO SERVICE UNIT.
ꢀ. Pull control knobs on front panel forward to remove.
2. Remove 8 screws from front panel and tilt front panel forwards.
3. Remove the nut that mounts the inoperative control and pull the control to the side.
4. Remove one wire at a time from the inoperative control and connect at the same terminal
on the new control. Carefully check to see that proper wires have been connected to the
terminals of the control. See attached wiring diagram.
5. Assemble new control to the front panel.
MAINTENANCE AND REPAIRS
Contact the factory or one of its representatives or a local service company for service or maintenance
if required.
2
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty Statement
This warranty is effective on all Toastmaster equipment sold on or after July 1, 2006, and supersedes all
previous warranties.
Toastmaster warrants equipment that it manufactures to be free from defects in material and
workmanship. Toastmaster’s obligation is limited to repairing or replacing, at Toastmaster’s option, without
cost to the customer, any part found to be defective, as well as any labor or material expense required to
replace the part.
Length of Warranty
This warranty is effective for a period of 18 months from the date of shipment from Toastmaster,
or 12 months from the date of purchase by the end user, whichever is earlier.
Exceptions
•
•
This warranty is valid only for the original end user owner/operator of the equipment.
This warranty does not apply to normal maintenance functions, including (but not limited to)
improper operation, installation or the use of an improper utility supply.
•
•
•
This warranty is valid only if the equipment is used in a commercial setting. The equipment
is designed and constructed for commercial use by trained professionals only. Any use of the
equipment in private or domestic applications immediately voids this warranty.
This warranty does not apply to any parts, labor and material expenses for service that is not
pre-approved and performed by a Toastmaster authorized service agent. Any such service
immediately voids this warranty.
This warranty does not apply to any parts, labor and material expenses associated with the
installation of parts that are not factory-approved for use in the equipment. Any use of such
parts immediately voids this warranty.
•
•
This warranty is not valid if terms of payment have not been met.
For warranty service on Pop-up toasters and light countertop equipment, an exchange program
would supersede a service call. Please find Warranty Exchange Program’ authorization to
follow. (http://www.toastmastercorp.com/filespdfcat/warranty_exchange_2008.pdf)
Toastmaster reserves the right to change the design and specifications of this equipment or any related
documentation at any time. The end user is not entitled to upgrades resulting from these changes.
This warranty is exclusive and supersedes all other warranties for the equipment, both expressed and
implied. There are no implied warranties of merchantability or of fitness for a particular purpose.
The foregoing is Toastmaster’s sole and exclusive obligation and the end user sole and exclusive remedy
for any action including breach of contract or negligence. In no event shall Toastmaster be liable for a sum
in excess of the purchase price of the equipment, or for any prospective or lost profits of the end user.
is a registerd trademark of Toastmaster, A Middleby Company. All rights reserved.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
1
2
5
4
6
8
7
9
10
12
13
14
3
11
15
16
18
20
21
19
17
22
23
24
25
26
MODEL: TMHPE, TMHPF
Electric Hotplates
SK2433
REV -
9/1/09
Download from Www.Somanuals.com. All Manuals Search And Download.
PARTS LIST
October ꢀ, 2009, Rev. -
TMHPE, TMHPF, Electric Hotplates
MODEL
Fig No.
Part No
2N-Y3301
Description
Qty Application
1
2
3
4
5
6
7
ELEMENT
2
2
4
2
2
2
2
TMHPF
TMHPF
TMHPE
TMHPE
TMHPE
TMHPE
TMHPE
TMHPF
TMHPE
ALL
I3-Z6169
I3-Y7891
I3-Y7822
2N-Y7779
2D-6470
ELEMENT CLAMP
CHAIN STRAIN RELF
COVER, TERMINAL BLOCK
ELEMENT,502 RNGE SURFACE
PAN-REFLECTOR CHROMALOX
RING-ELE ADAPTR R9R
TOP, TMHPF
2P-6468
I8-Z12997
I8-Z12998
G3-Z5945
I8-Z12996
I2-Z6064
G3-Y7788
2C-Y2344
2E-Y7327
I2-Z6170
I8-Z12995
2A-Z0314
I2-Z6178
I3-Z6174
2K-Z6183
I2-Z6177
I2-Z6172
2J-6403
8
1
TOP, TMHPE
9
SIDE PANEL LT/RT
SIDE LINER, LEFT
WIRING COVER
2
1
1
1
1
1
1
1
4
10
11
12
13
14
15
16
17
ALL
TMHPE
ALL
COVER, HANDY BOX
TERMINAL-GRND T&B
HANDY BOX 4X2.125X2.125
REAR PANEL
ALL
ALL
ALL
SIDE LINER, RIGHT
FOOT, 4 IN DIE CAST
DRAWER SLIDE
ALL
ALL
TMHPE
TMHPF
ALL
18
1
BOTTOM PANEL
19
20
21
22
23
24
25
26
BUSHING 1.125
4
1
1
2
1
1
2
2
DRAWER
TMHPE
ALL
CENTER WALL
CONTROL-INFINITE 240V
FRONT PANEL
ALL
I2-Z6179
2M-Z12939
2J-Y6690
2R-Z13016
ALL
GRAPHIC PANEL, 12” HTPLT
PILOT LIGHT 240V
KNOB, T-STAT ELEC.
ALL
ALL
ALL
IMPORTANT: WHEN ORDERING, SPECIFY VOLTAGE OR TYPE GAS DESIRED
INCLUDE MODEL AND SERIAL NUMBER
PAGE
OF
ꢀ
ꢀ
Some items are included for illustrative purposes only and in certain instances may not be available.
is a registerd trademark of Toastmaster, A Middleby Company. All rights reserved.
Download from Www.Somanuals.com. All Manuals Search And Download.
Download from Www.Somanuals.com. All Manuals Search And Download.
|