By UniFlame
WARNING
Model BC1912G
Deluxe Portable LP
Gas grill
Improper installation,
adjustment, alteration,
service or maintenance
can cause injury or
property damage.
Read the installation,
operation and
maintenance instructions
thoroughly before
installing or servicing
this equipment.
Failure to follow these
instructions could result
in fire or explosion,
which could cause
property damage,
personal injury, or death.
DANGER!
DO NOT use gas grill for
indoor cooking or
heating. TOXIC fumes
can accumulate and
cause asphyxiation. NOT
to be used in or on boats
or recreational vehicles.
WARNING
SAVE THESE
INSTRUCTIONS FOR
Chemicals known to the
state of California to
cause cancer, birth
defects, or other
reproductive harm are
created by the
FUTURE REFERENCE. IF
YOU ARE ASSEMBLING
THIS UNIT FOR SOMEONE
ELSE, GIVE THIS MANUAL
TO HIM OR HER TO SAVE
FOR FUTURE REFERENCE.
combustion of propane.
NOTE: The use and installation of this product must conform to local codes. In absence of local
codes, use the National Fuel and Gas Code, ANSI Z223.1, Storage and Handling of Liquefied
Petroleum Gasses, NFPA / ANSI 58 of CAN/CGA-B149.1, Natural Gas Installation Code of
CAN/CGA-B149.2, Propane Installation Code.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
IMPORTANT NOTICE: READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE!
Safety First!
Read and understand all warnings and precautions prior to
WARNING
operating your grill.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the
appliance.
2. Extinguish any open
flame.
3. Open Lid.
4. If odor continues,
DANGER
To prevent fire or explosion hazard when testing for a leak:
1. Always perform “leak test” before lighting the grill, each time the cylinder
is connected for use.
2. No smoking. Do not use or permit sources of ignition in the area while
conducting a leak test.
3. Conduct the leak test outdoors in a well- ventilated area.
4. Do not use matches, lighters, or a flame to check for leaks.
immediately call
your gas supplier or
5. Do not use grill until any and all leaks are corrected. If you are unable
fire department.
to stop a leak, disconnect the propane supply. Call a gas appliance
serviceman or your local propane gas supplier.
WARNING
1. This grill is for outside use only, and shall not be used in a building,
garage, or any other enclosed area.
2. This grill is for use with propane gas only (propane gas cylinder not
included).
WARNING
FOR YOUR SAFETY
1. DO NOT store or use
gasoline or other
flammable vapors and
iquids in the vicinity of
this or any other
3. Never attempt to attach this grill to the self-contained propane system of
a camper trailer, motor home, or house.
appliance.
4. Never use charcoal or lighter fluid.
5. The use of alcohol, or prescription or non-prescription drugs may impair
the consumer's ability to properly assemble or safely operate the
appliance.
6. Do not use gasoline, kerosene, or alcohol for lighting! The LP-gas
supply cylinder must be constructed and marked in accordance with the
specifications for LP-gas cylinders of the U.S. Department of
Transportation (DOT) CFR 49 or the National Standard of Canada,
CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation
of Dangerous Goods.
2. When cooking with
oil/grease, do not allow
the oil/grease to exceed
350° F (177°C). Do not
store or use extra
cooking oil in the
vicinity of this or any
other appliance.
7. Always open grill lid carefully and slowly as heat and steam trapped
within grill can severely burn you.
8. Always place your grill on a hard, level surface far away from
combustibles. An asphalt or blacktop surface may not be acceptable for
this purpose.
9. Do not attempt to move the grill while it is lit.
10 Do not leave a lit grill unattended, especially keep children and pets
away from grill at all times.
3. An LP Cylinder not
connected for use shall
NOT be stored in the
vicinity of this or any
other appliance.
11.This is not a tabletop grill. Therefore, do not place this grill on any type
of tabletop surface.
12.Do not use grill in high winds.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
13 Do not use the grill unless it is COMPLETELY assembled and all parts
are securely fastened and tightened.
14 Keep all combustible items and surfaces at least 12 inches (30 cm)
away from the grill at all times. DO NOT use this gas grill or any gas
product under any overhead or near any unprotected combustible
constructions.
Warning
1. Do not store spare
LP cylinder within 10
feet (3m) of this
appliance
2. Do not store or use
gasoline or other
flammable liquids or
vapors within 25 feet
(8m) of this appliance
CAUTION
1. To prevent liquid propane from entering the regulator valve and causing
a possible safety hazard, make sure that during installation and use, the
propane cylinder is lower than the regulator valve / regulator.
2. Do not touch metal parts of grill until it has completely cooled (about 45
min.) to avoid burns, unless you are wearing protective gear (potholders,
gloves, BBQ mittens, etc.).
3. Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
liquids.
3. When cooking with
oil/grease, do not allow
the oil/grease to exceed
350°
F (177°C).
4. Do not alter grill in any manner
CAUTION: Liquid propane (LP) gas is flammable and hazardous if
handled improperly. Become aware of the characteristics before using
any LP product.
4. Do not leave
oil/grease unattended
·
·
LP Characteristics: Flammable, explosive under pressure, heavier than
air, and settles and pools in low areas.
In its natural state propane has no odor. for your safety, an odorant is
added that smells like rotten cabbage.
·
·
·
·
Contact with LP can cause freeze burns to skin.
This grill is shipped from the factory for LP gas use Only.
Never use an LP cylinder with a damaged body.
Dented or rusted LP cylinders may be hazardous and should be
checked by your LP gas supplier
CAUTION: It is essential to keep the grill’s valve compartment, burners,
and circulating air passages clean. Inspect grill before each use.
GENERAL INFORMATION:
1. PROPANE GAS CYLINDER NEEDED TO OPERATE:
2. This Gas Grill is NOT for commercial use!
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Illustrated parts list
1.Lid & Base-----------------------------1set 2.Cooking Grid ----------------------------1pc
3. Heat Plate ----------------------------1pc
4.Burner-------------------------------------1pc
5.Gas Regulator Valve-----------------1pc 6.Handle -----------------------------------3sets
7.Warming Grid (Pre-assembly)-----1pc
Hardware: (Some hardware already assembled to parts above)
A. Long Bolts For Handles ---------- 6pcs B. Short Bolt For Burner------------------1pc
D. Flat washers------------------------------7pcs
C. Lock Washers For Handles ------7pcs
E. Phillips screwdriver --------------- 1pc
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Assembly Instructions
For Best Results
Remove all contents from packaging, and make sure all parts are present before attempting
to assemble! Tighten all bolt connections by hand first, then when the grill is fully
assembled, go back and tighten.
Step 1
Unfold legs from bottom
of unit
6
D
C
A
7
Step 2
1
Attach handles (6) as
A
C
shown using bolts (A) and
lock washers (C) in Phillips
screwdriver (E). Though
warming rack is pre-
D
6
assembled, it may be out of
position for some reason.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Step 3
Secure burner (4) to grill base
using bolt (B) and lock washer
(D). Finger tighten gas
4
regulator valve (5), to threaded
burner inlet, as shown.
IMPORTANT: The gas
regulator valve is properly
positioned when the hex
5
portion of regulator valve is flat
against burner inlet.
Note: when attached, the
regulator valve will rotate.
D
B
Step 4
Insert heating plate (3) and
cooking grid (2) as shown.
Note: Assure that the
curved side of the cooking
grid faces the front of the
grill.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
OPERATING YOUR GRILL
USE ONLY THE REGULATOR PROVIDED!
If a replacement is necessary, please call our customer service center.
The use of unauthorized parts can create an unsafe conditions and
environment
Connecting gas cylinder:
This grill is designed to operate with a (DOT 39 Cylinder) one pound 7-3/8” High disposable / 16.4
oz. propane gas cylinder. DO NOT ATTEMPT TO REFILL ANY PROPANE GAS CYLINDERS! The
LP-gas supply cylinder to be used must be constructed and marked in accordance with the
specifications for LP-gas cylinders of the U.S. Department of Transportation (DOT) CFR49 or the
National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres, and Tubes for the
Transportation of Dangerous Goods. Only cylinders marked “propane” may be used. The gas
cylinder should not be dropped or handled roughly! If the appliance is not in use, the gas cylinder
must be disconnected. Storage of an appliance indoors is permissible only if the cylinder is
disconnected and removed from the appliance. Cylinders must be stored outdoors out of the reach
of children and must not be stored in a building, garage, or any other enclosed area. Your cylinder
must never be stored where temperatures can reach over 125°F! Before connection, be sure that
there is no debris caught in the head of the gas cylinder, head of the regulator valve, or in the head
of the burner and burner ports. Lubricate the threads of the regulator valve with petroleum jelly,
insert the gas cylinder into the regulator valve and hand-tighten firmly. Disconnect the propane
cylinder from the regulator valve when the grill is not in use. DO NOT obstruct the flow of
combustion air and ventilation air to the grill.
Duration:
One pound (1 cylinder) of propane gas has slightly more than 21,000 BTU’s of heat energy. Your
gas grill burns gas at a rate of 10,000 BTU/hr. This gas grill will cook for approximately 2 hours with
the regulator valve set on “high.”
Check for leaks. Make sure the regulator valve is securely
fastened to the burner and the cylinder.
TO CHECK FOR LEAKS:
Make 2-3 oz. of leak solution by mixing one part liquid dishwashing soap with three parts water.
-Make sure control knob is off.
-Spoon several drops of solution at the cylinder to regulator valve connection.
-Inspect the solution at the connection, looking for bubbles. If NO bubbles appear, the
connection is secure. If bubbles appear, you have a leak.
-Turn control knob to the Lock Off position.
-Disconnect cylinder and reconnect, making sure the connection is secure.
-Retest with solution. If you continue to see bubbles, replace the cylinder.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Lighting Your Grill
IMPORTANT: Open lid prior to lighting grill. Attempting to light
the burner with the lid closed may cause an explosion! Make
sure there are no obstructions of airflow to the gas unit.
Spiders and insects can nest within and clog the burner /
venturi tube at the orifice. A clogged burner tube can lead to a
fire beneath the appliance. Clean burner holes with a heavy-
duty pipe cleaner. Make sure control knob is locked off. Place
a lighted match up through the hole in the bottom of the unit.
Turn the regulator valve to its “high” setting,. After lighting,
please observe the burner flame, make sure all burner ports
are lighted - a blue / yellow flame of 1-2 inches from the burner
rod should appear (refer to drawing). If burner does not light
after first try, turn the gas regulator to its “off” position and wait
5 minutes for gas to clear before trying again. If burner flame
goes out during operation, immediately turn the gas “off” and
open lid to let the gas clear for about 5 minutes. Attempt to re-
light. Before cooking on this grill for the first time, operate the
grill for about 15 minutes with the lid closed and the gas turned
on “high.” This will “heat clean” the internal parts and dissipate
odor from the painted finish. Clean your grill after each use, DO
NOT use abrasive or flammable cleaners, as it will damage the
parts of this product and may start a fire. Clean with warm
soapy water.
fire
Assure that the regulator control knob is in
the “lock off” position when attaching the
propane cylinder to the regulator.
When lighting, turn control knob to the off
position, and push in to turn on. Please
refer to “lighting instructions,” above.
When turning gas off, push the regulator
control knob and turn to “OFF” position
Observe Flame Height When lit:
Flame should be a Blue / Yellow
color Between1”– 2” High
2”
1”
0”
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Cleaning and Care
Caution: All cleaning and maintenance should be done when grill is cool and with the fuel supply turned off
at the LP cylinder. DO NOT clean any grill part in a self-cleaning oven. The extreme heat will damage the
finish.
Cleaning – Burning-off the grill after every use (approx. 15 minutes) will keep excessive food residue from
building up.
Recommended cleaning materials -
Mild dishwashing liquid detergent
Nylon cleaning pad
Paper clip
Hot water
Wire brush
Putty knife/scraper
Compressed air
DO NOT use cleaners that contain acid, mineral spirits or xylene.
Outside surfaces - Use mild dishwashing detergent and hot water solution. Non abrasive scouring powder can
be used on stubborn stains, then rinse with water.
If the inside surface of the grill lid has the appearance of peeling paint, baked on grease buildup has turned
to carbon and is flaking off. Clean thoroughly with strong solution of detergent and hot water. Rinse with
water and allow to completely dry. NEVER USE OVEN CLEANER.
Interior of grill bottom – Remove residue using brush, scraper and/or cleaning pad, then wash with
dishwashing detergent and hot water solution. Rinse with water and let thoroughly dry.
Plastic surfaces – Wash with a soft cloth and dishwashing detergent and hot water solution. Rinse with
water. Do not use abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts.
Cooking Grid – Use mild dishwashing detergent and hot water solution. Non abrasive scouring powder can
be used on stubborn stains, then rinse with water.
Heat Plate – Clean residue with wire brush and wash with soapy water, then rinse with water.
CLEANING THE BURNER ASSEMBLY -
1. Turn gas off at the control knob and disconnect cylinder.
2. Remove cooking grate and heat plate.
3. Remove burner by unscrewing the regulator valve from burner inlet and removing the fastener securing
the burner to the grill bottom.
4. Lift burner up and away from gas valve area.
5. Clean inlet (venturi) of burner with small bottle brush or compressed air.
6. Remove all food residue and dirt on outside of burner surface.
7. Clean any clogged ports with heavy-duty pipe cleaner or a stiff wire (such as an opened paper clip)
8. Inspect burner for any damage (cracks or holes). If damage is found, replace with new burner.
Reinstall burner; check to insure that gas valve orifices are correctly positioned and secured inside burner
inlet (venturi).
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Award-Winning Barbecue Recipes
Never-fail barbecue sauce
Ingredients:
¼ cup
Finely Chopped Onion
2 tablespoons
¼ cup
1 tablespoon
¼ teaspoon
1
Butter Or Margarine
Brown Sugar, Firmly Packed
Worcestershire Sauce
Hot Pepper Sauce
Clove Garlic, Finely Chopped
Catsup
1 cup
¼ cup
Lemon Juice
1 teaspoon
Prepared Mustard
Prepare:
Cook onion and garlic in margarine until tender. Add remaining ingredients and bring to a boil. Simmer
uncovered 15 to 20 minutes. Refrigerate leftovers after using.
Mamma’s Marinated Chicken
Ingredients:
¼ cup
Dijon mustard
2 tablespoons
1 ½ teaspoons
½ teaspoon
¼ teaspoon
4
fresh lemon juice
Worcestershire sauce
dried tarragon
freshly ground black pepper
boneless skinless chicken breast halves
Prepare:
Combine ingredients, mixing well. Marinade chicken for several hours. Grill uncovered, over medium heat,
for 10 to 15 minutes or to taste.
Barbecued Honey Steak
Ingredients:
5 pounds
2 tablespoons
1 teaspoon
2
Beef sirloin steak
Red pepper -- crushed
Black pepper
Garlic cloves -- crushed
1 large
Onion
1 cup
Honey
Prepare:
Combine all ingredients and marinate steak for 7-8 hours. Remove meat from marinade and grill over very
hi gh heat. Heat leftover marinade and pour over grilled steak to serve.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Hardcore Grilled Trout
Ingredients:
1/4 cup lemon or lime juice
2 tablespoons melted butter
2 tablespoons vegetable oil
2 tablespoons chopped parsley
1 tablespoon hot sauce
1/2 teaspoon ground ginger
1/2 teaspoon salt
4 brook trout -- about 1 pound each
Prepare:
Combine lemon juice, margarine, oil, parsley, sesame seeds, hot sauce, ginger and salt. Mix well. Pierce
skin of fish in several places. Roll fish in juice mixture to coat inside and out. Cover. Refrigerate 30 minutes
to 1 hour, turning occasionally. Remove fish from marinade. Place fish on grill; brush fish with marinade
while grilling. Cook over high heat for 5 minutes. Turn; brush with marinade, cook 5 minutes longer. Fish is
done when it flakes easily with fork – Cook to taste.
Grilled Veggies
Ingredients:
¾ cup Olive oil
¼ cup Red wine vinegar
1 teaspoon Fresh rosemary
1 teaspoon Fresh thyme leaves
1 teaspoon Fresh basil; chopped
1 teaspoon Fresh oregano; chopped
1 tablespoon minced garlic
½ teaspoon salt
½ teaspoon Ground black pepper
2 pounds assorted vegetables, chopped or whole, according to taste.
Prepare
Combine all ingredients in a small bowl. Marinade vegetables with sauce, and cover and refrigerate for 2
hrs. Grill vegetables over medium heat until tender, brushing them with marinade while they cook. Cooking
times will vary according to the vegetables chosen.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
Troubleshooting information
Problem
Possible Cause
Prevention/Cure
___________________________________________________________________________
Burner will not light with
match.
No gas flow
Check if LP cylinder is empty
Clear burner tube
Obstruction of gas flow.
Spider webs or insect nest in venturi.
Burner ports clogged or blocked.
Clean venturi.
Clean burner ports.
Irregular flame pattern, flame Burner ports are clogged or blocked
Clean burner ports.
does not run the full length
of burner.
__________________________________________________________________________________________
Flame is yellow or orange.
New burner may have residual
Manufacturing oils.
Burn grill for 15 minutes with the lid closed.
Spider webs or insect nest in venturi.
Clean venturi.
Clean burner.
Food residue, grease or seasoning
Salt on burner.
Flame blow out
flame
High or gusting winds
Turn front of grill to face wind or increase
Replace LP cylinder.
height.
Low on LP gas.
Flare-up
Grease buildup.
Clean grill.
Excessive fat in meat.
Excessive cooking temperature.
Trim fat from meat before grilling.
Adjust (lower) temperature accordingly.
Persistent grease fire.
Grease trapped by food buildup
around burner system.
Turn knobs to LOCK OFF position.
Leave lid inclosed position and let fire burn
out. After grill cools, remove and clean all
parts.
__________________________________________________________________________________________
Flashback (fire in burner
tube
Burner and /or burner tube is
blocked.
Clean burner and/or burner tube.
Inside of lid is peeling – like
paint peeling.
The lid is baked enamel
Baked on grease buildup has turned to
carbon and is flaking off. Clean thoroughly.
Download from Www.Somanuals.com. All Manuals Search And Download.
Owner’s Manual,
Model BC1912G Portable Gas Grill
1 YEAR LIMITED WARRANTY
UniFlame Corporation warrants to the original retail purchaser of this grill that if it is assembled and operated in
accordance with the printed instructions accompanying it then for a period of one (l) year from the date of purchase. All
parts shall be free from defects in material and workmanship. UniFlame may require reasonable proof of your date of
purchase. Therefore, you should retain your sales slip or invoice.
This Limited Warranty shall be limited to the repair or replacement of parts, which prove defective under normal use
and service and which on examination, shall indicate, to UniFlame's satisfaction, they are defective. Before returning
any parts, contact UniFlame's Customer Service Department. If UniFlame confirms the defect and approves the claim,
Uniflame will elect to replace such parts without charge. If you are required to return defective parts, transportation
charges must be prepaid. UniFlame will return parts to the purchaser, freight or postage prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, misuse, alteration,
misapplication, improper installation or improper maintenance or service, or failure to perform normal and routine
maintenance, as set out in this owners manual. There are no other express warrants except as set forth herein and any
applicable implied warranties of merchantability and fitness are limited in duration to the period of coverage of this
express written Limited Warranty. Some states do not allow limitation on how long an implied warranty lasts, so this
limitation may not apply to you.
UniFlame is not liable for any special, indirect or consequential damages. Some states do not allow the exclusion or
limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you.
UniFlame does not authorize any person or company to assume for it any other obligation or liability in connection with
the sale, installation, use, removal, return, or replacement of its equipment, and no such representations are binding on
UniFlame.
UniFlame Corporation
1817 N. Kenosha Road
Zion, Illinois 60099,USA
(800) 762-1142
24 Hour Fax: (847) 731-6032
Download from Www.Somanuals.com. All Manuals Search And Download.
|