MDX-65
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
E Model
Dolby noise reduction extension manufactured under license
from Dolby Laboratories Licensing Corporation.
“DOLBY” and the double-D symbol a are trademarks of Dolby
Laboratories Licensing Corporation.
Model Name Using Similar Mechanism MDX-62
Mini Disc Mechanism Type
Optical Pick-up Name
MG-798K-133
KMS-241A/J2N
SPECIFICATIONS
FEATURES
System
Laser Diode Properties
Material: GaAlAs
Mini disc digital audio system
• Sony BUS system compatible with mobile MD
changers.
• Direct-in system for inserting and removing
MDs easily.
• No waiting time to change discs in continuous
play.
• The MD changer compartment has a built in light
for easy use even in the dark.
Wavelength: 780 nm
Emission Duration: Continuous
Laser output Power: Less than
44.6 µW*
* This output is the value measured at a distance of
200 mm from the objective lens surface on the
Optical Pick-up Block.
• 1 bit Digital/Analog converter for high quality
sound reproduction.
Frequency response
10 – 20,000 Hz
Wow and flutter Below measurable limit
Signal-to-noise ratio
95 dB
Outputs
Bus control output (8 PIN)
Analog audio output (RCA PIN)
Current drain 300 mA (MD playback)
600 mA (during loading or ejecting a
disc)
Dimensions
Approx. 176 × 83.5 × 142 mm
3
18
(7 × 3 /8 × 5
/32 in.) (w/h/d) not incl.
projecting parts and controls
Approx. 1.1 kg (2 lb. 7 oz.)
Mass
Power requirement
12 V DC car battery (negative
ground)
Supplied accessories
Mounting hardware (1 set)
Bus cable 5.5 m (1)
RCA pin cord 5.5 m (1)
• U.S. and foreign patents licensed from Dolby
Laboratories Licensing Corporation.
• Design and specifications subject to change without
notice.
MINIDISC CHANGER
MICROFILM
Download from Www.Somanuals.com. All Manuals Search And Download.
SECTION 1
SERVICE NOTE
1-1.TO PLACE THE SET INTO PLAYBACK MODE
The this set has no key control function and cannot be placed into
the Playback mode alone.
For key control, the this set is controlled through serial
communication with a master unit (car audio player, TV tuner or
source selector compatible with the Sony BUS system.)
To service the this set, the set should be connected as given below:
Master unit
(CDX-C880,
C880R, etc.)
MDX-65
BUS CONTROL OUT BUS CONTROL IN
1-2. HOW TO CHECK THE SERVO BOARD
WAVEFORMS
1. Remove the panel (rear) assy, case (upper) and panel (front) assy.
Then, remove the main board from the mechanism deck. (See
page 8 of “SECTION 3. DISASSEMBLY”.)
2. Remove the chassis (OP) block from the mechanism deck. (See
page 10 of “SECTION 3. DISASSEMBLY”.)
3. Short each bridge points BP1 and BP2 on the main board by
solder bridge.
– main board (conductor side) –
BP1
BP2
4. Connect the power board with the main board by the main
flexible board. Connect the main board with the servo board by
the servo flexible board.
5. Connect to a master unit. With the master unit OFF, press the
preset buttons 4 n 5 n 1 (2 seconds or more each) in this
turn to enter the TEST mode.
6. Open the doors and insert a disc in the chassis (OP) assy. Use
the SOURCE button on the master unit to select to MD to
playback.
7. Check the waveforms at each point on the servo board.
Note: After this check is completed, remove solder between
shorted bridge points BP1 and BP2 and open these points.
– 3 –
Download from Www.Somanuals.com. All Manuals Search And Download.
SECTION 2
GENERAL
This section extracted from US,
Canadian, E model’s instruction manual.
Download from Www.Soma–nua4ls.–com. All Manuals Search And Download.
– 5 –
Download from Www.Somanuals.com. All Manuals Search And Download.
SECTION 3
DISASSEMBLY
Note : Follow the disassembly procedure in the numerical order given.
3-1. PANEL (REAR) ASSY
4 BVTT 2.6x6
6 panel (rear) assy
3 BVTT 2.6x6
2 PTT 2.6x8
5 CN901
1 cover
3-2. CASE (UPPER)
3 case (upper)
1 BVTT 2.6x6
2 BVTT 2.6x6
Download from Www.Soma–nua6ls.–com. All Manuals Search And Download.
3-3. PANEL (FRONT) ASSY
3 panel (front) assy
1 claw
2 claw
4 CN620
3-4. MD BLOCK
4 tension spring (FL)
6 MD block
1 damper (798)
5 tension spring (FL)
2 damper (798)
3 tension spring (FL)
– 7 –
Download from Www.Somanuals.com. All Manuals Search And Download.
3-5. MAIN BOARD
3 escutcheon
6 chassis (front)
0 CN600
7 collar (EHS)
!¡ CN601
!¢ CN701
!™ CN500
5 lead stopper
4 screws
!∞ CN700
(M1.7)
2 screws
(M1.7)
1 cushion
9 CN602
!¶ special flat screws
(1.7x3)
!• MAIN board
!£ CN603
!§ cushion (MAIN)
8 sheet (MAIN PC board)
3-6. CHASSIS (OP) BLOCK
9 worm wheel (ELV2)
7 bearing (ELV)
8 bearing (ELV)
6 chassis (OP) block
5 bearing (ELV)
4 bearing (ELV)
3 chassis (bottom) assy
2 precision screws
1 precision screws
(P 1.7x1.8)
(P 1.7x1.8)
Download from Www.Soma–nua8ls.–com. All Manuals Search And Download.
3-7. SERVO BOARD
3 screws
(M1.7x2.2)
6 CN100
5 CN300
7 SERVO board
1 CN200
2 Unsolder the
motor lead wires.
4 CN400
3-8. OPTICAL PICK-UP
1 screws
(K1.7x3.5)
2 optical pick-up
– 9 –
Download from Www.Somanuals.com. All Manuals Search And Download.
3-9. NOTE ON ASSEMBLY FOR THE CHASSIS (OP) BLOCK
1 worm wheel (ELV2)
3 bearing (ELV)
4 bearing (ELV)
5 chassis (OP) block
2 Turn the three feed
A
screw (ELV) assy fully in
the direction of arrows A.
A
A
8 chassis (bottom) assy
6 bearing (ELV)
7 bearing (ELV)
0 precision screws
(P1.7x1.8)
9 precision screw
B
(P1.7x1.8)
!¢ gear (ELVC)
!™ gear (ELVA2)
B
B
!∞ polyethylene washer
!£ polyethylene washer
!¡Turn the three gear (ELVB) fully
in the direction of arrows B.
Download from Www.Som–anu1a0ls.c–om. All Manuals Search And Download.
SECTION 4
DIAGRAMS
4-1. IC PIN DESCRIPTIONS
• IC100 CXA2523AR (RF AMP)
Pin No.
1
Pin Name
I
I/O
I
Pin Description
I-V converted RF signal input (I) from detector of optical pick-up.
I-V converted RF signal input (J) from detector of optical pick-up.
Center voltage (+1.65 V) generation output
2
J
I
3
VC
O
I
4 – 9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
A – F
Signal input (A to F) from detector of optical pick-up.
Quantity monitor input of light from laser diode of optical pick-up.
Laser amplifier output to automatic power control circuit.
Reference voltage input for laser power setting.
PD
I
APC
O
I
APCREF
GND
—
I
GND
TEMPI
TEMPR
SWDT
SCLK
XLAT
XSTBY
FOCNT
VREF
EQADJ
3TADJ
VCC
Temperature sensor connecting pin (Not used in this set.)
Reference voltage output for temperature sensor. (Not used in this set.)
Write data signal input from System controller (IC600).
Serial clock signal input from System controller (IC600).
Serial latch signal input from System controller (IC600).
Standby signal input (“L” : Standby) (Fixed at “H” in this set.)
Center frequency control voltage input of internal circuit filter (BPF22, BPF3T and EQ).
Reference voltage output (Not used in this set.)
O
I
I
I
I
I
O
I
Center frequency setting input of internal circuit filter (EQ).
Center frequency setting input of internal circuit filter (BPF3T).
Power supply pin (+3.3 V)
I
—
I
WBLADJ
TE
Center frequency setting input of internal circuit filter (BPF22).
Tracking error signal output to CXD2652AR (IC200).
Connecting pin for low pass filter condenser of sled error signal.
Sled error signal output to CXD2652AR (IC200).
O
I
CSLED
SE
O
O
I
ADFM
ADIN
ADAGC
ADFG
AUX
FM signal output of ADIP.
FM signal input of ADIP by AC combination.
I
External condenser connecting pin for AGC of ADIP.
ADIP double FM signal output (22.05 kHz ± 1 kHz) to CXD2652AR (IC200).
Support signal (I3 signal/temperature signal) output (Not used in this set.)
Focus error signal output to CXD2652AR (IC200).
Quantity signal output of light to CXD2652AR (IC200).
Bottom hold signal output of quantity signal (RF/ABCD) of light to CXD2652AR (IC200).
Peak hold signal output of quantity signal (RF/ABCD) of light to CXD2652AR (IC200).
Playback EFM RF signal output to CXD2652AR (IC200).
External condenser connecting pin of AGC circuit for RF.
RF signal input by AC combination.
O
O
O
O
O
O
O
I
FE
ABCD
BOTM
PEAK
RF
RFAGC
AGCI
COMPO
COMPP
ADDC
OPO
I
O
I
User comparator output pin (Not used in this set.)
User comparator input pin (Fixed at “L” in this set.)
External condenser connecting pin for low frequency interception of ADIP amplifier.
External condenser connect pin for lower cut of ADIP amplifier.
User operational amplifier inversion input pin (Fixed at “L” in this set.)
RF signal output
I
O
I
OPN
RFO
O
I
MORFI
MORFO
RF signal input of MO by AC combination.
O
RF signal output of MO.
– 11 –
Download from Www.Somanuals.com. All Manuals Search And Download.
• IC600 µPD784216GC-027-8EU (SYSTEM CONTROLLER)
Pin No.
Pin Name
I/O
O
O
O
O
O
I
Pin Description
1
M1
Elevator motor (M904) drive signal output
2
M1
Elevator motor (M904) drive signal output
Loading motor (M903) drive signal output
Loading motor (M903) drive signal output
Mechanism deck system power control output (“H” : Power ON)
Loading end sensor detection switch (S902) input
Store end sensor detection switch (S903) input
Home position detection switch (S901) input (“L” : Home position)
Power supply pin (+5 V)
3
M2
4
M2
5
MDMON
LES
6
7
SES
I
8
HOME
VDD
I
9
—
—
—
—
—
—
—
I
10
X2
Main system clock connecting pin (14 MHz)
Main system clock connecting pin (14 MHz)
GND
11
X1
12
VSS
13
XT2
Sub system clock connecting pin (32.768 kHz)
Sub system clock connecting pin (32.768 kHz)
System reset input
14
XT1
15
RESET
BU IN
BUS ON
SQ SY
STR SW
—
16
Backup OFF detection input (“L” : Backup OFF)
BUS OFF detection of SONY BUS. (“H” : BUS OFF)
Sub code Q sync input from CXD2652AR (IC200).
STOP switch (S600) input
17
I
18
I
19
I
20
O
I
Not used.
21
CC XINT
—
Interruption status input from CXD2652AR (IC200).
Not used.
22
O
—
—
I
23
AVDD
AVREF0
INIT
Power supply for A/D converter. (+5 V)
Reference voltage for A/D converter.
Initial input pin at reset.
24
25
26
TEMP
EHS
I
Thermistor connecting pin for temperature detection.
Elevator height position detection input
Connect to GND.
27
I
28, 29
30 – 32
33
—
I
—
O
—
O
O
—
O
—
I
Connect to GND.
AVSS
ERR PWM
—
Analog GND
34
Error data output (Not used in this set.)
Not used.
35
36
AVREF1
—
Reference voltage for D/A converter.
Not used.
37, 38
39
—
Not used.
40
MD SI
MD SO
MD CKO
—
Read data signal input from CXD2652AR (IC200).
Write data signal output to CXA2523AR (IC100) and CXD2652AR (IC200).
Serial clock signal output to CXA2523AR (IC100) and CXD2652AR (IC200).
Not used.
41
O
O
O
—
I
42
43
44
—
Not used.
45
UNISI
UNISO
UNI CKI
LINKOFF
—
Serial data input for SONY BUS.
Serial data output for SONY BUS.
Serial clock input for SONY BUS.
Link control signal output for SONY BUS. (“H” : Link OFF)
Not used.
46
O
I
47
48
O
O
I
49
50
—
Not used.
51, 52
53 – 55
56 – 59
60
D-BASS1, 2
—
O
O
O
O
O
O
Digital D-BASS select output 1, 2 (Not used in this set.)
Not used.
MNT0 – 3
AGING
AGCHK
TFTON
Monitor 0 – 3 signal input from CXD2652AR (IC200).
Not used.
61
Not used.
62
Not used.
Download from Www.Som–anu1a2ls.c–om. All Manuals Search And Download.
Pin No.
63
Pin Name
—
I/O
O
O
O
I/O
I
Pin Description
Not used.
64
EE CS
Chip select output to EEPROM. (Not used in this set.)
Serial clock output to EEPROM. (Not used in this set.)
Data input from/output to EEPROM. (Not used in this set.)
Internal status input from CXD2652AR (IC200).
65
EE CKO
EE SIO
SENS
66
67
68
LIMIT SW
DOORSW
MD LAT
MD RST
VSS
I
Optical pick-up innermost track limit position detection switch (S400) input
Front door open detection switch (S620) input (“L” : Open complete)
Serial latch signal output to CXA2523AR (IC100) and CXD2652AR (IC200).
Reset signal output to CXD2652AR (IC200).
69
I
70
O
O
—
O
O
I
71
72
GND
73
MD ON
EMPH O
A ATT
Servo system power control output (“H” : Power ON)
De-emphasis circuit control output (“H” : De-emphasis ON)
Analog mute control input (“H” : Mute ON)
74
75
76
ILLON
O
I
Illumination lamp (PL620) light-up control output (“H” : Lamp light-up)
Single mode setting pin (“L” : Single mode)
77
TSTSMD
TSTCKO
TSTSO
TSTMOD
VDD
78
O
O
I
Serial clock output to LED for TEST mode display. (Not used in this set.)
Serial data output to LED for TEST mode display. (Not used in this set.)
TEST mode setting pin (“L” : TEST mode)
79
80
81
—
O
I
Power supply pin (+5 V)
82 – 85
86 – 93
94
TSTOUT0 – 3
TSTIN0 – 7
TEST/VPP
DCS1
TEST key output pin of 4 × 8 matrix. (Not used in this set.)
TEST key input pin of 4 × 8 matrix. (Not used in this set.)
Fixed at “L” in this set.
—
I
95
Disc with/without detection 1 switch (S611) input (“H” : with disc)
Disc with/without detection 2 switch (S612) input (“H” : with disc)
Disc with/without detection 3 switch (S613) input (“H” : with disc)
Disc with/without detection 4 switch (S614) input (“H” : with disc)
Disc with/without detection 5 switch (S615) input (“H” : with disc)
Disc with/without detection 6 switch (S616) input (“H” : with disc)
96
DCS2
I
97
DCS3
I
98
DCS4
I
99
DCS5
I
100
DCS6
I
– 13 –
Download from Www.Somanuals.com. All Manuals Search And Download.
4-2. CIRCUIT BOARDS LOCATION
SENSOR board
POWER board
MAIN board
LAMP board
SERVO board
Download from Www.Som–anu1a4ls.c–om. All Manuals Search And Download.
MDX-65
4-3. BLOCK DIAGRAM
IC902
DIGITAL OUT
OPTICAL PICK-UP BLOCK
(KMS-241A/J2N)
IC902
4
IC100
IC600
IC900
IC601
DETECTOR
RF AMP
SYSTEM CONTROL
BUS INTERFACE
CN900
RESET
(BUS CONTROL OUT)
SYS RST
RESET
SW
XRST
XLAT
SWDT
SCLK
71
70
41
42
9
6
5
MD RST
RESET
MD LAT
F
15
47
46
45
17
8
7
4
6
16
17
18
46
SWDT
SCLK
XLAT
C
B
SWDT
1
4
2
5
3
6
F
MD SO
SCLK
XLAT
RFO
11
9
UNI CKI
BATT
7
8
MD CKO
B
A
C
D
I
2
J
J
IC200
UNISO
DIGITAL SIGNAL PROCESSOR,
DIGITAL SERVO SIGNAL PROCESSOR
BUS CLK
BUS DATA
BUS ON
4
7
8
1
A
D
E
I
40
38
26
28
32
AGCI
RF
IC500
10
13
UNISI
E
D/A CONVERTER
55
74
73
78
7
6
XLAT
SCLK
SWDT
XRST
XINT
RFI
TE
XLAT
SCLK
SWDT
XRST
XINT
IC602
LEVEL SHIFT
TE
2
SW
BUS ON
CC XINT
5
SE
SE
15
RSTB
XINT
SRDT
SQSY
DOUT
3
1
5
9
4
2
6
8
21
40
18
10
14
8
ADFG
ADFG
MD SI
BU IN
BATTERY DET
Q940, 941
34
36
37
65
63
62
SRDT
SQSY
DOUT
FE
BOTM
PEAK
FE
SRDT
SQSY
DOUT
16
75
AUTOMATIC
POWER CONTROL
Q100
11
22
BOTM
PEAK
11
10
APC
PD
CN902-2
SQ SY
LD
PD
R-CH
R
A ATT
24
26
25
5
6
4
DADT
XBCK
LRCK
DATA
BCK
MUTING
Q920
MUTING
CONTROL
SWITCH
Q932
MUTING
SWITCH
Q500
35
64
ABCD
ABCD
AUX2
LRCK
MUTE 18
DMI 17
AUDIO
OUT
74 EMPH O
VOUTR
VOUTL 12
9
R-CH
MUTING
Q910
IC930
LINE AMP
PEAK HOLD
Q200
75
83
CN902-1
MNT0
MNT1
MNT2
MNT3
SENS
56 MNT0
57 MNT1
58 MNT2
59 MNT3
67 SENS
5
+
–
27
1
FS256
XTI
IC202
LASER
APC SWITCH
7
6
L
1
12
4
APC REF
APC REF
S901
(HOME POSITION DET)
2
8
5
HOME
EHS
MDMON
RV901
ELEVATOR HEIGHT
SENSOR
+9V REG.
Q930, 931
+9V
27
IC603
LEVEL SHIFT
8
6
5
88
FFDR
Q602
B+ SWITCH
P/U5V
S400
(LIMIT)
+6V REG.
Q950
FOCUS
1
2
3
4
9
13
11
9
12
10
8
MNT0
MNT1
MNT2
MNT3
SENS
MNT0
B/U5V
11
29
89
86
FRDR
TFDR
Q970
68
LIMIT SW
MNT1
MNT2
MNT3
SENS
B+ SWITCH
+5V REG.
Q972
S611-616
DRV5V
31
32
DISC WITH/
WITHOUT DET
TRACKING
IC970
95 DCS1
ı
26
22
85
93
REGULATOR CONTROL
TRDR
SPRD
5
6
DCS6
DOORSW
LES
100
69
6
INPUT
OUT
VCC
4
1
2
S620
FRONT DOOR
OPEN DET
3
4
20
M901
M
M
(SPINDLE)
24
13
19
18
94
91
SPFD
S902
LOADING END
SENSOR DET
SRDR
M902
(SLED)
+3V REG.
Q800, 801
IC201
RAM
+3.3V
15
17
92
SFDR
S903
STORE END
SENSOR DET
PL620
(ILLUMINATION)
LAMP DRIVE
Q600, 601
AO0 32
9
A0
IC300
ı
ı
12
·
SLED/SPINDLE MOTOR DRIVE,
FOCUS/TRACKING COIL DRIVE
29
·
7
SES
34
ı
14
ı
IC700
ELEVATOR MOTOR DRIVE
76
19
10
ILL ON
STR SW
X2
AO8 38
18 A8
Signal Path
: PB
D0 47
1
·
D0
9
2
4
1
2
M1
M1
17
16
OSCO
OSCI
·
M904
X200
46
2
·
S600
STOP
M
M
·
48
(ELEVATOR)
22.5792MHz
24
·
7
·
D4 49
25 D3
X600
14MHz
IC701
LOADING MOTOR DRIVE
41
42
43
44
45
22
23
5
4
3
XOE
XCAS
A09
XRAS
XWE
DE
CAS
A9
RAS
WE
04
11
13
X1
9
2
4
3
4
M2
M2
XT2
M903
(LOADING)
X601
32.768kHz
7
14
XT1
– 15 –
– 16 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
4-4. PRINTED WIRING BOARDS — SERVO SECTION —
THIS NOTE IS COMMON FOR PRINDED WIRING BOARDS
AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is
printed in each block.)
for schematic diagrams
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics and
tantalums.
1
4
• All resistors are in Ω and / W or less unless otherwise
specified.
•
%
: indicates tolerance.
• C : panel designation.
Note:
Note:
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
The components identi-
fied by mark ! or dotted
line with mark ! are criti-
cal for safety.
Replace only with part
number specified.
•
U : B+ Line.
• Power voltage is dc 14.4V and fed with regulated dc power
supply from Master unit.
• Voltage and waveforms are dc with respect to ground
under no-signal conditions.
no mark : PB
: Impossible to measure
∗
• Voltages are taken with aVOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal produc-
tion tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal produc-
tion tolerances.
• Circled numbers refer to waveforms.
• Signal path.
E
: PB
for printed wiring boards
• X : parts extracted from the component side.
• Y : parts extracted from the conductor side.
r
•
: Through hole.
• b : Pattern from the side which enables seeing.
(The other layer’s patterns are not indicated.)
Caution:
Pattern face side: Parts on the pattern face side seen from the
(Side B)
Parts face side: Parts on the parts face side seen from the
(Side A) parts face are indicated.
pattern face are indicated.
– 17 –
– 18 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
• Semiconductor
Location
Ref. No. Location
D300
C-4
IC100
IC200
IC201
IC202
IC300
E-2
B-4
A-3
E-5
D-4
Q100
Q200
F-4
C-4
(Page 27)
– 19 –
– 20 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
4-5. SCHEMATIC DIAGRAM — SERVO SECTION — • Refer to page 33 for Waveforms and page 35 for IC Block Diagrams.
– 21 –
– 22 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
4-6. SCHEMATIC DIAGRAM — MAIN SECTION — • Refer to page 34 for Waveforms and page 37 for IC Block Diagrams.
– 23 –
– 24 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
4-7. PRINTED WIRING BOARDS — MAIN SECTION —
• Semiconductor
Location
Ref. No. Location
D500
D501
D600
D601
D602
D800
D801
C-3
C-3
C-2
B-2
E-2
A-3
A-4
IC500
IC600
IC601
IC602
IC603
IC700
IC701
B-3
D-2
C-2
D-4
D-4
C-1
B-2
Q500
Q600
Q601
Q602
Q800
Q801
C-3
E-3
E-3
B-2
B-3
A-3
(
) : SIDE B
– 25 –
– 26 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
(Page 30)
(Page 20)
– 27 –
– 28 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
4-8. PRINTED WIRING BOARD — POWER BOARD —
• Semiconductor
Location
Ref. No. Location
D900
D901
D902
D903
D904
D905
D930
D940
D941
D950
D951
D952
D970
B-2
B-2
A-2
A-2
A-2
A-2
D-4
E-6
E-7
E-5
E-4
E-3
D-9
(Page 27)
IC900
(IC902)
IC930
IC970
B-3
E-1
C-4
E-7
Q910
Q920
Q930
Q931
Q932
Q940
Q941
Q950
Q970
Q972
C-2
C-2
D-5
D-3
B-3
E-6
E-6
E-3
E-4
D-8
(
) : SIDE B
– 29 –
– 30 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
4-9. SCHEMATIC DIAGRAM — POWER SECTION — • Refer to page 37 for IC Block Diagrams.
(Page 24)
– 31 –
– 32 –
Download from Www.Somanuals.com. All Manuals Search And Download.
• Waveforms
– Main Section –
– Servo Section –
1 IC100 4 (A) PLAY MODE
5 IC100 #• (RF) PLAY MODE
9 IC200 @§ (XBCK)
1 IC600 !º (X2)
5 IC500 1 (XT1)
200 mV/DIV, 10 µsec/DIV
500 mV/DIV, 1 µsec/DIV
3.2 Vp-p
2.7 Vp-p
3.2 Vp-p
Approx.
1.1 Vp-p
Approx.
150 mVp-p
354 ns
89 ns
71 ns
2 IC100 8 (E) PLAY MODE
100 mV/DIV, 10 µsec/DIV
6 IC100 #¢, IC200 ^∞(FE) PLAY MODE
200 mV/DIV, 0.5 msec/DIV
!º IC200 !§ (OSCI)
2 IC600 !¢ (XT1)
2.6 Vp-p
2.8 Vp-p
Approx.
150 mVp-p
400 mVp-p
44.3 ns
30.4 µs
3 IC500 4 (LRCK)
3 IC100 9 (F) PLAY MODE
7 IC100 @§, IC200 &¢ (TE) PLAY MODE
100 mV/DIV, 10 µsec/DIV
500 mV/DIV, 0.5 msec/DIV
2.8 Vp-p
Approx.
150 mVp-p
2.0 Vp-p
22.7 µs
4 IC500 6 (BCK)
4 IC100 1, 2 (I, J) PLAY MODE
100 mV/DIV, 10 µsec/DIV
8 IC200 @∞(LRCK)
3.2 Vp-p
2.8 Vp-p
150 mVp-p
354 ns
22.7 µs
– 33 –
– 34 –
Download from Www.Somanuals.com. All Manuals Search And Download.
• IC Block Diagrams
– Servo Section –
IC100 CXA2523AR
48
47
46
45
44
43 42
41
40
39
38 37
USROP
–
+
RF AGC
EQ
EQ
+
–
USRC
RFA1
DET
BPF3T
3T
RFA2
RFA3
AUX
SW
PEAK3T
I
1
2
–
HLPT
–1
1
2
–
–
P-P
–2
–
J
3T
WBL
OFST
PTGR
TEMP
PEAK
–
–
–
1
2
–2
–1
CVB
36
BOTTOM
WBL
BOTM
+
–
PBH
VC
A
3
4
GRV
GRVA
PBSW
35
34
33
ABCD
FE
–
–
–
–
+
–
AUX
AA
IVR
IVR
IVR
BPFC
ABCDA
32 ADFG
31 ADAGC
30 ADIN
+
–
B
C
5
6
BB
CC
+
+
–
–
FEA
ATA
+
–
DET
BPF22
WBL
–
–
+
+
ADIP
AGC
29 ADFM
28 SE
+
–
D
E
7
8
DD
EE
IVR
IVR
WBL
–1
TG
TG
PTGR
–
+
–
+
–2
+
–
SEA
TEA
+
–
EE'
27 CSLED
26 TE
–1
–2
EFB
TESW
EBAL
ESW
+
–
F
9
+
–
FF
IVR
WBL
FF'
25 WBLADJ
3T
VI CONV
IV
FBAL
EQ
GSW
PD 10
AUXSW
BGR
COMMAND
+
–
+
–
VREF
SCRI - PARA
DECODE
APC 11
APCREF 12
13
14
15
16 17 18
19
20
21
22 23
24
– 35 –
Download from Www.Somanuals.com. All Manuals Search And Download.
IC200 CXD2652AR
100 99 98 97 96 95 94 93
92 91 90 89 88 87 86 85 84 83 82 81 80 79 78 77 76
75
74
73
72
AUX2
TE
PWM
GENERATOR
SPINDLE
SERVO
MNT0
MNT1
MNT2
MNT3
1
SE
2
3
4
MONITOR
CONTROL
EACH
BLOCK
AVSS
71
70
69
68
ADRB
ADRT
AVDD
ADIO
ADIP
DECODER
SWDT
SCLK
XLAT
SRDT
SENS
5
6
7
8
9
EACH
BLOCK
CPU I/F
67
66
65
64
63
62
VC
SERVO
DSP
A/D
CONVERTER
AUX1
FE
ANALOG
MUX
ABCD
BOTM
PEAK
XRST 10
SQSY 11
DQSY 12
SUBCODE
PROCESSOR
61
60
59
58
CLTV
FILO
FILI
RECP 13
PCO
SHOCK RESISTANT
MEMORY CONTROLLER
XINT 14
TX 15
57
56
PDO
AVSS
OSCI 16
OSCO 17
XTSL 18
NC 19
CLOCK
GENERATOR
EACH
BLOCK
55
54
53
52
51
RFI
COMP
DIGITAL
AUDIO
I/F
SAMPLING
RATE
CONVERTER
BIAS
AVDD
ASYI
ASYO
DVSS 20
DIN 21
DOUT 22
ADDT 23
DADT 24
LRCK 25
ATRAC
ENCODER/DECODER
ADDRESS/DATA BUS A00 - A11, D0 - D3
26 27 28
29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49
50
IC300 MPC17A38ZVMEL
36 35 34 33
32 31 30 29
28 27
26 25 24
23
22 21
20 19
DC/DC
CONVERTER
DRIVER
DRIVER
DRIVER
DRIVER
VC
PRE-DRIVER
PRE-DRIVER
PRE-DRIVER
CONTROL
PRE-DRIVER
CLOCK
VC
VC
VC
VC
VC
VC
CLK
DETECTOR
CONTROL
CONTROL
CONTROL
VC
VC
VC
2
3
4
5
6
7
8
9
10
11
12 13 14
15 16 17 18
1
Download from Www.Som–anu3a6ls.c–om. All Manuals Search And Download.
– Main Section –
IC500 PCM1718E-T1
IC700, 701 LB1638MTP-T1
10
9
1
N.C.
GND
IN1
20 XTO
1
2
XTI
CLK
CONTROL
DGND
19 CLKO
VDD
3
INPUT
18
MUTE
INTERFACE
2
OUT1
17 DM1
16 DM0
15 RSTB
LRCIN
4
MODE
CONTROL
DIN
BCKIN
ZERO
5
6
7
DIGITAL
FILTER
8
7
VS
14
FORMAT
VCC
IN2
3
4
OUT2
NOISE SHAPER
5 LEVEL
DAC
5 LEVEL
DAC
GND
5
6
N.C.
LOWPASS
FILTER
LOWPASS
FILTER
CMOS
AMP
CMOS
AMP
D/C L
13
D/C R
8
VOUTR
AGND
9
12 VOUTL
11
10
VCC
– Power Section –
IC900 BA8272F-E2
IC970 TL5001CPS-E20
14
13
12
11
10
9
8
4
3
2
1
U.V.L.O
RESET
DEAD-TIME
COMPARATOR
SWITCH
REFERENCE
VOLTAGE
+
–
+
–
OSC
2
3
4
5
6
7
1
SWITCH
ERROR
AMP
+
–
'ON'
AT
'H'
S.C.P.
COMPARATOR 1
–
+
PWM
COMPARATOR
–
+
S.C.P.
LATCH
S.C.P.
COMPARATOR 2
6
7
8
5
– 37 –
Download from Www.Somanuals.com. All Manuals Search And Download.
SECTION 5
EXPLODED VIEWS
NOTE:
• The mechanical parts with no reference
number in the exploded views are not supplied.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Color Indication of Appearance Parts
Example :
The components identified by
mark !or dotted line with mark.
!are critical for safety.
Replace only with part number
specified.
KNOB, BALANCE (WHITE) ... (RED)
Parts Color Cabinet’s Color
• Accessories and packing materials and
hardware (# mark) list are given in
the last of this parts list.
Les composants identifiés par une
marque !sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
5-1. CASE SECTION
9
10
A
1
7
18
6
10
3
8
5
#1
2
2
4
19
8
#1
20
11
15
#1
12
13
21
16
#1
A
16
14
15
16
17
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
1
2
3
4
5
X-3376-846-1 DOOR(P)ASSY
3-930-744-01 SPACER(DOOR)
3-831-441-11 CUSHION, RA TTLEABSORBER
X-3376-863-1 DOOR(S)ASSY
12
13
* 14
* 14
15
X-3376-847-1 PANEL(REAR)ASSY
3-931-697-01 CUSHION(STOPPER)
A-3294-566-A POWERBOARD,COMPLETE(US,Canadian,E)
A-3294-668-A PO WERBO ARD ,COMPLETE(AEP ,UK)
3-930-176-01 DAMPER(798)
X-3376-845-1 PANEL(FR ONT)ASSY
* 6
7
8
* 9
10
1-672-198-11 LAMPBOARD
3-909-607-01 SCREW
3-348-750-01 CUSHION(DAMPER)
3-031-481-11 CASE(UPPER)
3-912-956-11 SCREW(2.6X6)(CU),+BVTT
16
* 17
18
19
* 20
3-930-177-01 SPRING(FL),TENSION
3-031-482-11 CASE(LOWER)
3-025-283-01 SHEET(DOORS1)
3-025-284-01 SHEET(DOORS2)
3-031-503-01 BRACKET
* 11
3-031-489-01 PLA TE, GR OUND
* 21
3-031-483-11 COVER
Download from Www.Som–anu3a8ls.c–om. All Manuals Search And Download.
5-2. MAIN BOARD SECTION
58
59
56
57
54
56
55
56
57
MG-798K-133
63
60
53
56
61
52
51
62
64
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
* 51
* 52
* 52
53
3-931-149-02 SHEET(MAINPCBOARD)
58
* 59
60
61
62
3-931-699-01 CUSHION(ROLLH)
3-931-025-11 SHEET(MECHANISMDECK)
3-931-698-01 CUSHION(ROLLL)
1-668-438-11 MAINFLEXIBLEBOARD
3-880-990-00 SCREW(1.7X3), FLA T,(+)SPECIAL
A-3294-565-A MAINBOARD,COMPLETE(US,Canadian,E)
A-3294-667-A MAINBO ARD ,COMPLETE(AEP ,UK)
1-776-474-11 CABLE, FLA T7P
54
3-909-412-01 SCREW(+P)(1.7X2)(TYPE3)
55
56
* 57
A-3317-382-A SENSORBOARD,COMPLETE
3-348-750-01 CUSHION(DAMPER)
3-715-973-01 CUSHION
* 63
* 64
4-952-141-01 CUSHION(SPEAKER)
3-021-073-01 CUSHION(MAIN)
– 39 –
Download from Www.Somanuals.com. All Manuals Search And Download.
5-3. MD SECTION (1)
(MG-798K-133)
102
103
104
101
106
109
109
105
112
101
101
113
118
#4
108
107
S903
S902
#4
109
109
#2
114
111
110
#2
117
#2
M903
#2
116
112
#3
115
#2
M904
112
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
101
102
103
* 104
105
3-317-552-71 SCREW(M1.7)
3-930-314-01 ESCUTCHEON
3-930-319-01 BUTTON(STOP)
3-930-320-01 CHASSIS(FRONT)
3-931-366-01 STOPPER,LEAD
112
113
* 114
115
3-377-719-11 WASHER, POL YETHYLENE
3-930-317-01 GEAR(LD)
X-3374-670-1 CHASSIS(BOTTOM)ASSY
3-930-313-01 GEAR(EL VC)
116
3-020-386-01 GEAR(EL VA2)
106
* 107
108
109
110
1-668-264-11 SERVOFLEXIBLEBOARD
X-3374-669-1 CHASSIS(MOTOR)ASSY
3-930-310-01 COLLAR(EHS)
3-930-312-02 BEARING(EL V)
X-3374-673-1 BRACKET(LD2)ASSY
117
* 118
M903
M904
S902
3-020-363-01 WHEEL(EL V2), WORM
3-741-875-01 SHEET ,RUBBER
X-3371-508-2 MOTORASSY ,LD(LO ADING)
X-3374-812-1 MOTORASSY ,EL V(ELEV ATOR)
1-570-771-11 SWITCH(LOADINGENDSENSORDET)
111
3-930-365-01 WHEEL(LD),WORM
S903
1-570-771-21 SWITCH(STOREENDSENSORDET)
Download from Www.Som–anu4a0ls.c–om. All Manuals Search And Download.
5-4. MD SECTION (2)
(MG-798K-133)
#2
151
152
160
165
164
153
154
155
156
157
166
163
167
158
168
162
159
160
161
169
170
162
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
* 151
* 152
153
154
155
X-3371-209-3 CHASSIS(TOP)ASSY
3-020-388-01 GUIDE(HOLDER2)
3-930-318-01 BUTTON(EJECT)( 61)
3-930-318-11 BUTTON(EJECT)( 62)
3-930-318-21 BUTTON(EJECT)( 63)
161
162
163
164
165
3-930-350-01 SPRING(EJ),TORSION
X-3371-216-1 HOLDER(CADDIE)ASSY
3-930-352-01 SPRING(DLOCK),TENSION
X-3375-509-1 SLIDER(3)ASSY ,LO ADING
3-930-366-01 RACK(LOADING)
156
157
158
159
160
3-930-318-31 BUTTON(EJECT)( 64)
3-930-318-41 BUTTON(EJECT)( 65)
3-930-318-51 BUTTON(EJECT)( 66)
3-930-354-01 LEVER,DISCEJECT
166
167
168
169
170
3-930-360-01 SPRING(LIMITER),TORSION
X-3374-671-1 CHASSIS(REAR2)ASSY
3-930-349-01 SPRING(LOCK),TORSION
X-3371-219-5 PLA TE(HOLDER)ASSY ,LOCK
3-021-511-01 WASHER
3-377-719-11 WASHER, POL YETHYLENE
– 41 –
Download from Www.Somanuals.com. All Manuals Search And Download.
5-5. MD SECTION (3)
(MG-798K-133)
#6
#6
209
210
226
#6
207
206
207
206
205
208
205
211
212
203
RV901
213
#6
225
#2
M902
S901
M901
204
203
214
#4
215
224
220
217
218
#6
219
216
#7
#5
201
202
222
221
#5
201
223
The components identified by Les composants identifiés par une
mark !or dotted line with mark. marque !sont critiques pour la
!are critical for safety.
sécurité.
Replace only with part number Ne les remplacer que par une piéce
specified.
portant le numéro spécifié.
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
201
202
203
204
205
3-930-338-01 HOLDER(OPGUIDEB)
3-930-332-01 GUIDE(OPB)
X-3371-212-1 SCREW(EL V)ASSY ,FEED
1-658-880-11 EHSFLEXIBLEBOARD
3-020-351-01 SLEEVE(EL V2)
217
218
219
220
! 221
X-3371-213-1 HOLDER(SLA)ASSY
X-3371-214-1 SCREW(SL)ASSY ,FEED
3-930-331-01 GUIDE(OP A)
3-020-346-01 SPRING(SLOUT2),FEED
8-583-037-02 PICK-UP ,OPTICALKMS-241A/J2N
206
207
* 208
209
3-930-334-01 SPRING(EL V), COMPRESSION
3-930-345-01 PLA TE(B), EL VLIMITER
X-3371-215-1 CHASSIS(OP)ASSY
3-930-344-01 PLA TE(A), EL VLIMITER
3-930-711-01 SPRING(EL V2), COMPRESSION
* 222
223
224
* 225
226
A-3294-337-A SERVOBOARD,COMPLETE
3-932-755-01 SCREW(M1.7X2.2)
3-703-816-32 SCREW(M1.4X1.6),SPECIALHEAD
3-018-070-01 SHEET(TT)
210
3-930-333-01 SLEEVE(EL V)
211
212
213
214
215
3-930-339-01 WHEEL(SL),WORM
3-338-645-31 WASHER(0.8-2.5)
3-930-343-01 SCREW(K1.7X3.5)
3-930-342-01 RET AINER(SP)
3-930-336-01 HOLDER(SLB)
M901
M902
RV901
A-3291-507-A MOTORBLOCKASSY ,SP(SPINDLE)
A-3291-508-A MOTORBLOCKASSY ,SL(SLED)
1-223-817-11 RES, VAR, SLIDE 10K(ELEV ATORHEIGHT
SENSOR)
S901
1-570-771-21 SWITCH(HOMEPOSITIONDET)
216
3-930-335-01 DETENT ,SL
Download from Www.Som–anu4a2ls.c–om. All Manuals Search And Download.
SECTION 6
ELECTRICAL PARTS LIST
LAMP MAIN
NOTE:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the
components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service.
Some delay should be anticipated
when ordering these items.
• SEMICONDUCTORS
In each case, u : µ, for example:
uA.. : µA.. uPA.. : µPA..
uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..
• CAPACITORS
The components identified by
mark !or dotted line with mark.
!are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque !sont critiques pour
la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
• RESISTORS
All resistors are in ohms.
METAL:Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F:nonflammable
• Abbreviation
G : German model
uF : µF
• COILS
uH : µH
When indicating parts by reference
number, please include the board.
Ref. No.
Part No.
Description
Remark
16V
Ref. No.
Part No.
Description
Remark
*
1-672-198-11 LAMPBOARD
C604
C605
C606
C607
C608
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
************
<CAP ACIT OR>
1-107-826-11 CERAMICCHIP
<CONNECTOR>
C620
* CN620
PL620
R620
0.1uF
10%
C609
C610
C611
C650
C651
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
1-580-056-21 PIN,CONNECTOR(SMD)3P
<PILOTLAMP>
C652
C653
C654
C699
C700
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
1-517-630-41 LAMP ,PILO T(ILLUMINA TION)
<RESISTOR>
1-216-298-00 MET ALCHIP
<SWITCH>
2.2
5%
1/10W
DET)
C701
C800
C801
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-104-852-11 TANT AL. CHIP
0.1uF
0.1uF
22uF
10%
10%
20%
16V
16V
10V
S620
1-692-532-21 SWITCH,PUSH(1KEY)(FRONTDOOROPEN
<CONNECTOR>
*************************************************************
CN500
* CN600
CN601
* CN602
* CN603
1-573-370-21 CONNECTOR,FFC/FPC30P
1-573-939-11 CONNECTOR,FFC/FPC(ZIF)30P
1-573-916-11 CONNECTOR,FFC/FPC(ZIF)7P
1-580-055-21 PIN,CONNECTOR(SMD)2P
1-580-055-21 PIN,CONNECTOR(SMD)2P
*
*
A-3294-565-A MAINBOARD,COMPLETE(US,Canadian,E)
A-3294-667-A MAINBO ARD ,COMPLETE(AEP ,UK)
*********************
3-034-614-01 PAPER, SHIELD
<CAP ACIT OR>
* CN604
CN700
* CN701
1-580-056-21 PIN,CONNECTOR(SMD)3P
1-580-055-21 PIN,CONNECTOR(SMD)2P
1-580-055-21 PIN,CONNECTOR(SMD)2P
C500
C501
C502
C503
C504
1-107-826-11 CERAMICCHIP
1-104-851-11 TANT AL. CHIP
1-107-826-11 CERAMICCHIP
1-115-416-11 CERAMICCHIP
1-115-416-11 CERAMICCHIP
0.1uF
10uF
0.1uF
1000PF
1000PF
10%
20%
10%
5%
16V
10V
16V
25V
25V
<DIODE>
D500
D501
D600
D601
D602
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
8-719-977-03 DIODE DTZ5.6B
8-719-977-03 DIODE DTZ5.6B
8-719-977-03 DIODE DTZ5.6B
5%
C505
C507
C509
C510
C520
1-104-851-11 TANT AL. CHIP
1-110-450-11 ELECTCHIP
1-104-851-11 TANT AL. CHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
10uF
100uF
10uF
0.1uF
0.1uF
20%
20%
20%
10%
10%
10V
6.3V
10V
16V
16V
D800
D801
8-719-421-18 DIODE MA8033-L-TX
8-719-988-61 DIODE 1SS355TE-17
C530
C540
C541
C600
C601
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-104-852-11 TANT AL. CHIP
1-107-826-11 CERAMICCHIP
0.1uF
0.1uF
0.1uF
22uF
10%
10%
10%
20%
10%
16V
16V
16V
10V
16V
<IC>
IC500
IC600
IC601
IC602
IC603
8-759-571-84 IC PCM1718E/2K
8-759-537-17 IC uPD784216GC-038-8EU
8-759-503-60 IC S-80740AN-D4-S
8-759-238-47 IC TC74HCT7007AF(EL)
8-759-238-47 IC TC74HCT7007AF(EL)
0.1uF
C602
C603
1-162-917-11 CERAMICCHIP
1-162-917-11 CERAMICCHIP
15PF
15PF
5%
5%
50V
50V
– 43 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MAIN POWER
Ref. No.
Part No.
Description
Remark
1/16W
Ref. No.
Part No.
Description
Remark
IC700
IC701
8-759-823-87 IC LB1638M
8-759-823-87 IC LB1638M
<NETWORKRESISTOR>
RB601
RB602
RB603
RB605
RB606
1-233-412-11 RES,CHIPNETWORK 1.0K
1-233-810-21 RES,CHIPNETWORK 100K
1-233-412-11 RES,CHIPNETWORK 1.0K
1-233-412-11 RES,CHIPNETWORK 1.0K
1-233-810-21 RES,CHIPNETWORK 100K
(3216)
(3216)
(3216)
(3216)
(3216)
<RESISTOR>
1-216-821-11 MET ALCHIP
<COIL>
JC501
L600
1K
5%
RB607
RB608
RB609
1-233-412-11 RES,CHIPNETWORK 1.0K
1-239-446-11 RES,CHIPNETWORK 330K
1-233-412-11 RES,CHIPNETWORK 1.0K
(3216)
(3216)
(3216)
1-412-058-11 INDUCTORCHIP
<TRANSISTOR>
10uH
<SWITCH>
1-571-914-21 SWITCH,KEYBOARD(STOP)
<THERMISTOR>
Q500
Q600
Q601
Q602
Q800
8-729-424-12 TRANSISTOR UN2112
8-729-904-60 TRANSISTOR DTB113ZK
8-729-421-22 TRANSISTOR UN2211
8-729-020-67 TRANSISTOR XN1A312-TX
8-729-106-60 TRANSISTOR 2SB1115A
S600
TH600
1-810-421-11 THERMISTOR NTH5G36B103K01TE
<VIBRA TOR>
Q801
8-729-230-49 TRANSISTOR 2SC2712-YG
<RESISTOR>
X600
X601
1-760-607-11 VIBRA TOR, CERAMIC(14MHz)
1-579-886-21 VIBRA TOR, CR YST AL(32.768kHz)
R500
R501
R502
R503
R505
1-216-841-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-801-11 MET ALCHIP
1-216-801-11 MET ALCHIP
47K
1K
1K
22
22
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
*************************************************************
*
*
A-3294-566-A POWERBOARD,COMPLETE(US,Canadian,E)
A-3294-668-A PO WERBO ARD ,COMPLETE(AEP ,UK)
***********************
R509
R540
R541
R542
R600
1-216-829-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-821-11 MET ALCHIP
4.7K
2.2K
2.2K
2.2K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
*
3-031-503-01 BRACKET
<CAP ACIT OR>
C900
C901
C902
C903
C904
1-126-204-11 ELECTCHIP
1-163-275-11 CERAMICCHIP
1-164-004-11 CERAMICCHIP
1-163-017-00 CERAMICCHIP
1-164-004-11 CERAMICCHIP
47uF
0.001uF
0.1uF
0.0047uF 5%
0.1uF
20%
5%
10%
16V
50V
25V
50V
25V
R601
R602
R603
R604
R605
1-216-833-11 MET ALCHIP
1-216-841-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-821-11 MET ALCHIP
10K
47K
1K
1K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
10%
C905
C910
C911
C912
C913
1-164-004-11 CERAMICCHIP
1-126-603-11 ELECTCHIP
1-162-569-11 CERAMICCHIP
1-126-193-11 ELECT
0.1uF
4.7uF
100PF
1uF
10%
20%
2%
20%
20%
25V
35V
50V
50V
35V
R606
R608
R609
R610
R611
1-216-837-11 MET ALCHIP
1-218-708-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-829-11 MET ALCHIP
22K
4.7K
1K
2.2K
4.7K
5%
1/16W
0.50% 1/16W
5%
5%
5%
1/16W
1/16W
1/16W
1-126-603-11 ELECTCHIP
4.7uF
C920
C921
C922
C923
C930
1-126-603-11 ELECTCHIP
1-162-569-11 CERAMICCHIP
1-126-193-11 ELECT
1-126-603-11 ELECTCHIP
1-164-004-11 CERAMICCHIP
4.7uF
100PF
1uF
4.7uF
0.1uF
20%
2%
20%
20%
10%
35V
50V
50V
35V
25V
R612
R613
R614
R615
R616
1-216-825-11 MET ALCHIP
1-216-829-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-821-11 MET ALCHIP
2.2K
4.7K
2.2K
2.2K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C933
C934
C936
C938
C940
1-126-204-11 ELECTCHIP
1-164-004-11 CERAMICCHIP
1-164-004-11 CERAMICCHIP
1-128-590-11 ELECTCHIP
1-164-346-11 CERAMICCHIP
47uF
0.1uF
0.1uF
100uF
1uF
20%
10%
10%
20%
16V
25V
25V
6.3V
16V
R617
R618
R621
R622
R623
1-216-825-11 MET ALCHIP
1-216-845-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-851-11 MET ALCHIP
1-216-821-11 MET ALCHIP
2.2K
100K
1K
330K
1K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C950
C951
C952
C970
C971
1-164-004-11 CERAMICCHIP
1-125-710-11 DOUBLELA YERS 0.1F
1-124-779-00 ELECTCHIP
1-163-133-00 CERAMICCHIP
1-163-986-00 CERAMICCHIP
0.1uF
10%
25V
5.5V
16V
50V
25V
R624
R800
R801
R802
1-216-851-11 MET ALCHIP
1-216-815-11 MET ALCHIP
1-216-829-11 MET ALCHIP
1-216-815-11 MET ALCHIP
330K
330
4.7K
330
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
10uF
470PF
0.027uF
20%
5%
10%
Download from Www.Som–anu4a4ls.c–om. All Manuals Search And Download.
POWER
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
C973
C974
C975
C976
C977
1-164-004-11 CERAMICCHIP
1-164-004-11 CERAMICCHIP
1-126-204-11 ELECTCHIP
1-128-590-11 ELECTCHIP
1-128-590-11 ELECTCHIP
0.1uF
0.1uF
47uF
100uF
100uF
10%
10%
20%
20%
20%
25V
25V
16V
6.3V
6.3V
<TRANSISTOR>
Q910
Q920
Q930
Q931
Q932
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-920-21 TRANSISTOR DTC314TKH04
8-729-424-59 TRANSISTOR UN2212
8-729-920-85 TRANSISTOR 2SD1664-QR
8-729-424-12 TRANSISTOR UN2112
C978
C980
C981
C983
C984
1-128-590-11 ELECTCHIP
1-128-590-11 ELECTCHIP
1-127-485-00 ELECT
1-164-004-11 CERAMICCHIP
1-164-004-11 CERAMICCHIP
100uF
100uF
33uF
0.1uF
0.1uF
20%
20%
20%
10%
10%
6.3V
6.3V
6.3V
25V
25V
Q940
Q941
Q950
Q970
Q972
8-729-230-49 TRANSISTOR 2SC2712-YG
8-729-901-06 TRANSIST OR DT A144EK
8-729-920-85 TRANSISTOR 2SD1664-QR
8-729-106-60 TRANSISTOR 2SB1115A
8-729-822-84 TRANSIST OR 2SB1202F AST
<CONNECTOR>
CN900
* CN901
1-580-907-12 PLUG,CONNECTOR(BUSCONTROLOUT)
1-573-939-11 CONNECTOR,FFC/FPC(ZIF)30P
<RESISTOR>
R900
R901
R910
R911
R912
1-216-089-00 RES,CHIP
1-216-071-00 MET ALCHIP
1-216-079-00 MET ALCHIP
1-216-097-00 RES,CHIP
1-216-081-00 MET ALCHIP
47K
8.2K
18K
100K
22K
5%
1/10W
1/10W
1/10W
1/10W
1/10W
<JACK>
1-580-441-11 JACK,PIN2P(AUDIOOUT)
<DIODE>
5%
5%
5%
5%
CN902
R913
R914
R915
R920
R921
1-216-081-00 MET ALCHIP
1-216-033-00 MET ALCHIP
1-216-097-00 RES,CHIP
1-216-079-00 MET ALCHIP
1-216-097-00 RES,CHIP
22K
220
100K
18K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
D900
D901
D902
D903
D904
8-719-421-27 DIODE MA728
8-719-057-80 DIODE MA8160-M-TX
8-719-421-27 DIODE MA728
8-719-057-80 DIODE MA8160-M-TX
8-719-421-27 DIODE MA728
R922
R923
R924
R925
R930
1-216-081-00 MET ALCHIP
1-216-081-00 MET ALCHIP
1-216-033-00 MET ALCHIP
1-216-097-00 RES,CHIP
1-216-049-11 RES,CHIP
22K
22K
220
100K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
D905
D930
D940
D941
D950
8-719-057-80 DIODE MA8160-M-TX
8-719-422-97 DIODE MA8091-M
8-719-977-12 DIODE DTZ6.8B
8-719-988-61 DIODE 1SS355TE-17
8-719-988-61 DIODE 1SS355TE-17
R931
R932
R933
R940
R941
1-216-057-00 MET ALCHIP
1-216-057-00 MET ALCHIP
1-216-009-00 RES,CHIP
1-216-097-00 RES,CHIP
1-216-093-00 RES,CHIP
2.2K
2.2K
22
100K
68K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
D951
D952
D970
8-719-422-62 DIODE MA8062-L-TX
8-719-041-79 DIODE MA721W A-TX
8-719-210-43 DIODE EC10QS-06
<JUMPERRESISTOR>
R942
R943
R950
R951
R970
1-216-109-00 MET ALCHIP
1-216-089-00 RES,CHIP
1-216-049-11 RES,CHIP
1-216-085-00 RES,CHIP
1-216-214-00 RES,CHIP
330K
47K
1K
33K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
FB903
1-216-295-00 SHOR T
<IC>
0
IC900
IC902
IC930
IC970
8-759-444-86 IC BA8272F-E2
8-749-923-53 IC TOTX193(DIGIT ALOUT)
8-759-711-82 IC NJM4580E
R971
R972
R973
R974
R975
1-216-206-00 RES,CHIP
1-216-206-00 RES,CHIP
1-216-061-00 MET ALCHIP
1-216-081-00 MET ALCHIP
1-216-077-00 MET ALCHIP
2.2K
2.2K
3.3K
22K
15K
5%
5%
5%
5%
5%
1/8W
1/8W
1/10W
1/10W
1/10W
8-759-983-96 IC TL5001CPS
<COIL>
L970
L971
L972
1-409-640-21 INDUCTOR
1-403-584-11 INDUCTOR
1-409-640-21 INDUCTOR
10uH
33uH
10uH
R976
R977
R978
R979
R980
1-216-174-00 RES,CHIP
1-216-198-00 RES,CHIP
1-216-198-00 RES,CHIP
1-216-663-11 MET ALCHIP
1-216-649-11 MET ALCHIP
100
1K
1K
3.3K
820
5%
5%
5%
0.5%
0.5%
1/8W
1/8W
1/8W
1/10W
1/10W
<FIL TER>
1-239-466-21 FILTER, EMI
<FUSE>
NF900
PC1
R981
1-216-158-00 RES,CHIP
<SWITCH>
22
5%
1/8W
1-533-351-11 FUSE,CHIP(2A/125V)
SW1
1-572-552-11 SWITCH, SLIDE(ANALOG/DIGIT
AL)
*************************************************************
– 45 –
Download from Www.Somanuals.com. All Manuals Search And Download.
SENSOR
SERVO
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
A-3317-382-A SENSORBOARD,COMPLETE
************************
<CONNECTOR>
WhenreplacinganypartsintheSENSORboard,
thewholemountedboardshouldbereplaced.
************************************************************* * CN300
CN100
CN200
1-573-929-11 CONNECTOR,FFC/FPC(ZIF)20P
1-573-370-21 CONNECTOR,FFC/FPC30P
1-770-619-11 PIN,CONNECTOR2P
CN400
1-573-346-21 CONNECTOR,FFC/FPC6P
*
A-3294-337-A SERVOBOARD,COMPLETE
***********************
<DIODE>
8-719-988-61 DIODE 1SS355TE-17
<FERRITEBEAD>
<CAP ACIT OR>
D300
FB200
C100
C101
C102
C103
C104
1-107-685-11 TANT AL. CHIP
15uF
20%
20%
20%
6.3V
4V
4V
50V
25V
1-135-201-11 TANT ALUMCHIP 10uF
1-135-201-11 TANT ALUMCHIP 10uF
1-414-594-11 INDUCTOR,FERRITEBEAD
<IC>
1-162-964-11 CERAMICCHIP
1-162-969-11 CERAMICCHIP
0.001uF
0.0068uF 10%
10%
C105
C106
C107
C108
C109
1-164-227-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-110-563-11 CERAMICCHIP
1-162-968-11 CERAMICCHIP
1-109-982-11 CERAMICCHIP
0.022uF
0.1uF
0.068uF
0.0047uF 10%
1uF
10%
10%
10%
25V
16V
16V
50V
10V
IC100
IC200
IC201
IC202
IC300
8-752-080-95 IC CXA2523AR
8-752-384-47 IC CXD2652AR
8-759-498-44 IC MSM51V4400-70TS-K
8-759-058-62 IC TC7S08FU(TE85R)
8-759-442-80 IC MPC17A38ZVMEL
10%
C110
C111
C112
C113
C200
1-107-826-11 CERAMICCHIP
1-164-227-11 CERAMICCHIP
1-162-970-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-685-11 TANT AL. CHIP
0.1uF
10%
10%
10%
10%
20%
16V
25V
25V
16V
6.3V
<COIL>
0.022uF
0.01uF
0.1uF
L100
L200
L300
1-412-058-11 INDUCTORCHIP
1-412-058-11 INDUCTORCHIP
1-412-034-11 INDUCTORCHIP
10uH
10uH
330uH
15uF
C202
C203
C204
C206
C207
1-162-919-11 CERAMICCHIP
1-162-919-11 CERAMICCHIP
1-164-217-11 CERAMICCHIP
1-162-970-11 CERAMICCHIP
1-107-823-11 CERAMICCHIP
22PF
22PF
150PF
0.01uF
0.47uF
5%
5%
5%
10%
10%
50V
50V
50V
25V
16V
<TRANSISTOR>
Q100
Q200
8-729-216-22 TRANSISTOR 2SA1162-G
8-729-230-49 TRANSISTOR 2SC2712-YG
<RESISTOR>
C208
C209
C210
C211
C212
1-107-826-11 CERAMICCHIP
1-162-927-11 CERAMICCHIP
1-162-968-11 CERAMICCHIP
1-107-823-11 CERAMICCHIP
1-163-023-00 CERAMICCHIP
0.1uF
100PF
0.0047uF 10%
0.47uF
10%
5%
16V
50V
50V
16V
50V
R100
R101
R102
R103
R104
1-216-853-11 MET ALCHIP
1-218-706-11 MET ALCHIP
1-216-308-00 MET ALCHIP
1-216-811-11 MET ALCHIP
1-216-853-11 MET ALCHIP
470K
3.9K
4.7
150
470K
5%
1/16W
0.50% 1/16W
10%
5%
5%
5%
5%
1/10W
1/16W
1/16W
0.015uF
C213
C214
C215
C216
C217
1-107-826-11 CERAMICCHIP
1-109-982-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
0.1uF
1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
10V
16V
16V
16V
R105
R106
R107
R108
R109
1-218-739-11 RES,CHIP
1-216-994-11 RES,CHIP
1-216-994-11 RES,CHIP
1-216-994-11 RES,CHIP
1-216-842-11 MET ALCHIP
91K
13K
13K
13K
56K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C218
C219
C220
C221
C300
1-162-927-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-162-970-11 CERAMICCHIP
1-162-970-11 CERAMICCHIP
1-104-852-11 TANT AL. CHIP
100PF
0.1uF
0.01uF
0.01uF
22uF
5%
50V
16V
25V
25V
10V
10%
10%
10%
20%
R110
R111
R204
R205
R206
1-216-833-11 MET ALCHIP
1-216-833-11 MET ALCHIP
1-216-809-11 MET ALCHIP
1-216-833-11 MET ALCHIP
1-216-845-11 MET ALCHIP
10K
10K
100
10K
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C301
C302
C303
C304
C305
1-107-826-11 CERAMICCHIP
1-107-682-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
0.1uF
1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
16V
16V
16V
16V
16V
R207
R208
R209
R210
R211
1-216-855-11 MET ALCHIP
1-216-827-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-821-11 MET ALCHIP
1-216-811-11 MET ALCHIP
680K
3.3K
1K
1K
150
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
C306
C400
C401
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
1-107-826-11 CERAMICCHIP
0.1uF
0.1uF
0.1uF
10%
10%
10%
16V
16V
16V
R212
R213
R214
1-216-819-11 MET ALCHIP
1-216-853-11 MET ALCHIP
1-216-809-11 MET ALCHIP
680
470K
100
5%
5%
5%
1/16W
1/16W
1/16W
Download from Www.Som–anu4a6ls.c–om. All Manuals Search And Download.
SERVO
Ref. No.
Part No.
Description
Remark
Ref. No.
Part No.
Description
Remark
R215
R216
R217
1-216-825-11 MET ALCHIP
1-216-825-11 MET ALCHIP
1-216-825-11 MET ALCHIP
2.2K
2.2K
2.2K
5%
5%
5%
1/16W
1/16W
1/16W
**************
HARD WARELIST
**************
<NETWORKRESISTOR>
#1
#2
#3
#4
#5
7-685-793-09 SCREW+PTT2.6X8(S)
7-627-554-07 SCREW ,PRECISION+P2X2.2
7-627-852-37 SCREW ,PRECISION+P1.7X1.8 TYPE3
7-627-855-07 SCREW ,PRECISION+P2X5.5 TYPE3
7-627-852-27 +P1.7X3
RB200
RB300
RB301
1-233-576-11 RES,CHIPNETWORK 100
1-233-600-11 RES,CHIPNETWORK 2.2
1-233-600-11 RES,CHIPNETWORK 2.2
<SWITCH>
1-692-532-21 SWITCH,PUSH(1KEY)(LIMIT)
<VIBRA TOR>
#6
#7
7-627-552-18 SCREW ,PRECISION+P1.7X1.6
7-627-852-58 SCREW ,PRECISION+P1.7X5 TYPE3
S400
*************************************************************
PAR TSFORINST ALLA TIONANDCONNECTIONS
***************************************
X200
1-767-429-21 VIBRA TOR, CR YST AL(22.5792MHz)
*************************************************************
251
252
253
254
255
3-930-163-21 BASE(FITTING)
X-3371-178-1 BRACKETASSY
3-930-166-01 CUSHION(FITTING)
7-682-961-01 SCREW+PSW4X8
4-304-511-00 NUT(M5),FLANGE
MISCELLANEOUS
***************
53
61
106
204
! 221
1-776-474-11 CABLE, FLA T7P
1-668-438-11 MAINFLEXIBLEBOARD
1-668-264-11 SERVOFLEXIBLEBOARD
1-658-880-11 EHSFLEXIBLEBOARD
8-583-037-02 PICK-UP ,OPTICALKMS-241A/J2N
256
257
1-590-519-21 CORD(WITHCONNECTOR)(BUSCABLE)(5.5m)
1-777-284-11 CORD,CONNECTION(RCAPINCORD)(5.5m)
251
252
253
M901
A-3291-507-A MOTORBLOCKASSY ,SP(SPINDLE)
A-3291-508-A MOTORBLOCKASSY ,SL(SLED)
X-3371-508-2 MOTORASSY ,LD(LO ADING)
X-3374-812-1 MOTORASSY ,EL V(ELEV ATOR)
1-223-817-11 RES, VAR, SLIDE 10K(ELEV ATORHEIGHT
M902
M903
M904
RV901
254
255
256
257
SENSOR)
S901
S902
S903
1-570-771-21 SWITCH(HOMEPOSITIONDET)
1-570-771-11 SWITCH(LOADINGENDSENSORDET)
1-570-771-21 SWITCH(STOREENDSENSORDET)
*************************************************************
ACCESSORIES&P ACKINGMA TERIALS
********************************
3-865-667-11 MANU AL, INSTR UCTION, INST ALL(ENGLISH,
FRENCH,SP ANISH,CHINESE)
(US,Canadian,E)
3-865-928-11 MANU AL, INSTR UCTION(ENGLISH,SP ANISH,
SWEDISH,POR TUGUESE)(AEP ,UK)
3-865-928-21 MANUAL,INSTRUCTION(FRENCH,GERMAN,
DUTCH,IT ALIAN)(AEP ,UK)
3-865-928-31 MANUAL,INSTRUCTION(GERMAN,RUSSIAN)(G)
*************************************************************
The components identified by Les composants identifiés par une
mark !or dotted line with mark. marque !sont critiques pour la
!are critical for safety.
Replace only with part number Ne les remplacer que par une piéce
specified. portant le numéro spécifié.
sécurité.
– 47 –
Download from Www.Somanuals.com. All Manuals Search And Download.
MDX-65
Sony Corporation
Personal & Mobile Communication Company
99A0478-1
Printed in Japan C1999. 1
9-926-423-11
Download from Www.Som–anu4a8ls.c–om. All Manuals Search And DownPluobaldis.hed by Quality Assurance Dept.
|