Aqua Sub
Easy Load Water Cooler
Model No: WA2-02-50
3092402
WA2-02-50
© 2009 Soleus Air International
Download from Www.Somanuals.com. All Manuals Search And Download.
WARNING: This water cooler is for use on 120 volt
outlets only. The cord has a plug as shown in A. An
adapter as shown in C is available for connecting three-
blade grounding-type plugs to two-slot receptacles. The
grounding lug extending from the adapter must be con-
nected to a permanent ground such as a properly
grounded outlet box. The adapter should not be used if a
three-slot grounded receptacle is available.
DO NOT DEFEAT THE SAFETY PURPOSE OF THE
GROUNDED PLUG.
TECHNICAL SPECIFICATIONS
Model
WA2-02-50
115V, 60Hz
6.0 Amps, 580 Watts
R134a, 37g
Power Supply
Electrical Rating
Refrigerant and Quantity
Design Pressure (High Side)
188psig
Design Pressure (Low Side)
Dimensions
88psig
13.5"W x 17"D x 42" H
3
Download from Www.Somanuals.com. All Manuals Search And Download.
PRODUCT DIAGRAM
Top Cover
Power Switch
Located on back; used to power on/off the unit
Condenser
Located on back; do not touch when unit is running
Multi-color Display
Built-in Handle
One located on each side
Cold Water Dispenser
Hot Water Dispenser
Red Handle , includes child safety faucet. Squeeze
two handles together and press down to operate
Drip Tray
Automatic Reset Button
Automatic Reset after replacing the water bottle
Water Bottle Cap with Hose
Lower Cabinet Door
Water Bottle
(Not included)
Bottle Tray
4
Download from Www.Somanuals.com. All Manuals Search And Download.
CONTROL PANEL AND MULTI-COLOR DISPLAY
CONTROL PANEL
Multi-color Display
Child Safety Lock Button
Cold Water Dispenser Button
Hot Water Dispenser Button - Press
this button and the LOCK button at the
same time to dispense hot water
Water Bottle is Full
Water is Being Cooled
Water is Being Heated
Press Reset Button
Water Bottle is Empty
Water
Pump is
Running
Hot Water Temperature
Cold Water Temperature
5
Download from Www.Somanuals.com. All Manuals Search And Download.
UNPACKING THE WATER COOLER
1. Cut and remove the straps from the box. DO NOT turn the box upside down, or lay it on its
side. The bottom of the box is separate from the top section. Lift straight up on the top box
section to remove the top box section. Remove the Styrofoam packaging and plastic bag.
Lift the water cooler off the bottom of the box. Wipe it clean if necessary.
2. Place the machine on a hard, flat surface. Make certain the unit is level. The unit should not
be close to direct sunlight or other source of heat.
3. It is best to place the water cooler in an area with good air circulation. Make sure there is at
least 4 inches (10cm) of space between the back of your water cooler and the wall. Keep a
minimum distance of 2 inches (5cm) on each side of your water cooler.
WARNING: The drain cap on the back of the unit may become loose during shipping. Fasten
the drain cap tightly before you start to operate the unit. If the drain cap is loose, the unit may
leak and cause floor damage.
PREPARING THE WATER COOLER FOR USE
The Aqua Sub is different from a traditional water cooler. The water bottle does not need to be
placed upside down on the top of the unit. The water bottle is placed in the lower cabinet of the
unit, and then a pump draws the water up to the dispenser.
Much like a new refrigerator with an ice maker or water dispenser, it is recommended to
run 1 or 2 water bottles full of water through the system before use.
Figure 1
Figure 2
6
Download from Www.Somanuals.com. All Manuals Search And Download.
1. Make sure the water dispenser is not plugged into an electrical out-
let.
2. Open the door of the lower cabinet and pull the tray out from the
cabinet.
3. Place a full water bottle on the tray. Remove the plastic cover over
the mouth of the water bottle.
4. Put the hose inside the water bottle and place the water bottle cap
firmly over the mouth of the water bottle. （Figure 1）
5. Attach the hose to the water cooler by pressing in on the knob of the
hose cap and sliding over the connector at the top of the cabinet.
（Figure 2）
6. Push the tray inside the cabinet and close the lower cabinet door.
7. Plug the water cooler into a grounded power outlet and turn on the
power switch located on the back.
8. The unit will start to operate, but you should wait at least half an
hour before using the water cooler.
NOTE: If there is not a secure connection between the hose cap and the connector on the water cooler,
the water pump will operate but the water cooler will not dispense water. Make sure the hose is con-
nected to the water cooler correctly.
NOTE: Please wait until the water pump stops running before using the unit. If the water tank is not full, no
water will dispense from the cold water faucet and the hot water faucet.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
OPERATION
After the water bottle has been connected to the water cooler, the unit is ready for use. Turn the power switch
on the back of the unit to ON. The water cooler will start running. First the unit will pump the water from the
water bottle into the cooling and heating tanks, and then the unit’s compressor and heater will start to operate.
It will take approximately 30 minutes for the water cooler to provide hot and cold water when first plugged in
to an outlet.
• Cold Water - To dispense cold water, press the COLD water button on the control panel.
• Hot Water - To dispense hot water, press the HOT water button and the LOCK button on the control
panel.
• Reset - Once you have replaced an empty water bottle with a new full water bottle, the water cooler will
reset itself and begin pumping water as soon as the door closes.
CLEANING & MAINTENANCE
1. To avoid accidents, turn off and unplug the water cooler from the outlet before cleaning.
2. A soft damp cloth may be used to clean the surface of the water cooler. When necessary, a mild deter-
gent may be used. DO NOT use erosive chemical solvents to clean the unit, as this may damage the
surface of the water cooler.
3. DO NOT pour water on the exterior of the unit to avoid getting the internal electrical system damp. DO
NOT immerse the unit in water when cleaning.
4. The water bottle cap, hose, and drip tray may be washed in a dishwasher (top rack only).
5. Keep the water cooler 6 inches (15cm) away from the wall so it can work properly. Make certain all
ventilation openings are clear of obstruction.
6. Do not damage the heating or cooling system, paying particular attention to the black condenser or heat
radiator on the back of the water cooler.
7. If you will not use the water cooler for a long period of time, please unplug the power cord and drain
the water cooler. Drain the water from all faucets, then remove the drain cap on back and allow it to
drain. Make certain the drain cap is fastened tightly when finished.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
TROUBLESHOOTING
Please check the troubleshooting chart below. It includes several common problems, which you can correct at
home, making a customer service call unnecessary.
Problem
Possible Cause
Remedy
Unit is unplugged.
Main power supply is off.
Plug the power cord into an outlet.
Reestablish main power supply.
Unit does not dispense hot
and cold water.
The hose cap is not attached prop-
erly to the connector on the water
cooler.
Connect properly. There will be a
give when the hose cap slides prop-
erly over the connector.
The cold water thermostat is set at
too high a temperature.
Adjust the thermostat.
Over consumption of cold water in
a short time.
Wait a moment for the water to cool.
Unit does not dispense
cold water.
The ventilation around the unit is
insufficient.
Space the unit from the wall by more
than 15 cm.
The temperature of water in the wa-
ter bottle is too high. (When the
bottle is exposed to direct sunlight
for a long time.)
Place the water bottle in a cool loca-
tion out of direct sunlight.
Unit does not dispense hot Over consumption of hot water in a
Wait a moment for the water to heat.
Place the unit on a level, flat surface.
water.
short time.
The appliance is not level.
Unit is noisy during opera-
tion.
Move the unit away from other ob-
jects.
Unit is touching other objects.
The top portion of the faucet has
become loose.
Tighten the top threaded portion of
the faucet.
Water leaks from the fau-
cet.
Call the customer service telephone
number to repair the faucet.
The faucet has been damaged.
The bottle may have small pin-
holes.
Replace with a new water bottle.
Tighten the drain cap. If the sealing
silicon material inside the drain cap is
torn or damaged, then replace with a
new one.
Water is dripping out of
the water cooler and onto
the floor.
The drain cap on the back is not
fastened properly.
This is not uncommon with new
Clean the hose in the dishwasher (top
The water being dispensed water coolers. Do not worry, this is rack only) or let it soak in dish soap.
has a strange taste.
not dangerous to your health. This
water cooler is FDA approved.
The strange taste usually goes away
after the first bottle has been used up.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
WARRANTY
One Year Limited Warranty
Soleus International Inc. warrants the accompanying Soleus Air Water Cooler to be free of defects in material and
workmanship for the applications specified in its operation instruction for a period of ONE (1) year from the date of
original retail purchase in the United States.
If the unit exhibits a defect in normal use, Soleus International Inc. will, at its option, either repair or replace it, free of
charge within a reasonable time after the unit is returned during the warranty period.
As a condition to any warranty service obligation, the consumer must present this Warranty Certificate along with a
copy of the original purchase invoice.
THIS WARRANTY DOES NOT COVER:
•
Damage, accidental or otherwise, to the unit while in the possession of a consumer not caused by a defect in
material or workmanship.
•
Damage caused by consumer misuse, tampering, or failure to follow the care and special handling provisions
in the instructions. This includes dents, accidental or otherwise, to the base and head of the unit.
•
•
Damage to the finish of the case, or other appearance parts caused by wear.
Damage caused by repairs or alterations of the unit by anyone other than those authorized by Soleus
International Inc.
•
Freight and Insurance cost for the warranty service.
ALL WARRANTIES, INCLUDING ANY IMPLIED WARRANTY OF MERCHANT ABILITY ARE LIMITED TO
ONE-YEAR DURATION OF THIS EXPRESS LIMITED WARRANTY. SOLEUS INTERNATIONAL INC.
DISCLAIMS ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES AND IN NO EVENT
SHALL SOLEUS INTERNATIONAL INC’S LIABILITY EXCEED THE RETAIL VALUE OF THE UNIT FOR
BREACH OF ANY WRITTEN OR IMPLIED WARRANTY WITH RESPECT TO THIS UNIT.
This warranty covers only new products purchased from our authorized dealers or retailers. It does not cover used, sal-
vaged, or refurbished products.
As some states do not allow the limitation or exclusion of incidental or consequential damages, or do not allow
limitation on implied warranties, the above limitations and exclusions may not apply to you. This warranty gives you
specific legal rights, and you may also have other rights that vary from state to state.
For Technical Support & Warranty Service
Please Call (888) 876-5387
Or Write To:
Soleus International Inc.
20035 E Walnut Dr. North
City of Industry, CA 91789 USA
10
Download from Www.Somanuals.com. All Manuals Search And Download.
|