| ATTACHMENT   OPERATOR’S   MANUAL   Snow/Dozer   Blade & Hitch   Snow Plow/Dozer Blade   Mfg. No.   Description   1693754   42” Remote Angling Snow Plow/Dozer Blade   Hitch   Mfg. No.   Description   1693755   Hitch (for Express Series & Regent / 500 / 2500 Series)   1721301-02   Rev 1/2001   TP 100-2353-02-AT-SMA   Download from Www.Somanuals.com. All Manuals Search And Download.   Safety Rules   & Information   Read these safety rules and follow them closely. Failure to obey these rules could result in loss of control   of unit, severe personal injury or death to you, or bystanders, or damage to property or equipment.   The triangle in text signifies important cautions or warnings which must be followed.   GENERAL WARNINGS   PREPARATION   O Know the tractor controls and how to stop quickly.   O Disengage the PTO before making any adjustments.   READ THE TRACTOR OPERATOR’S MANUAL.   O Never attempt to make any adjustments while engine   O Read this manual and the tractor Operator’s Manual   carefully. Be thoroughly familiar with the controls and   the proper use of the equipment.   is running.   O Thoroughly inspect the area where the dozer is to be   operated and remove all foreign objects.   O Never allow children to operate the machine. Do not   O Adjust the skid shoe height to clear gravel or crushed   stone surface. See the Adjustments section for pro-   cedure.   allow adults to operate it without proper instruction.   O Do not carry passengers.   O Use only attachments or accessories designed for   your machine. See your dealer for a complete list of   recommended attachments or accessories.   OPERATING SAFETY   O Always clear snow up and down the face of slopes,   never across the face. Exercise extreme caution   when changing direction on slopes. Do not attempt to   clear steep slopes.   O Keep the area of operation clear of all persons, par-   ticularly small children, and pets.   O Never direct discharge towards bystanders.   O Make sure all hardware is secure and that dozer   O Exercise extreme caution when operating on, or   crossing, gravel drives, walks or roads. Stay alert for   hidden hazards or traffic.   blade is in good operating condition.   O Check to be sure all safety devices and shields are in   place.   O After striking an object or if unit starts to vibrate   abnormally, stop the engine and remove the key.   Check for the cause and any damage before restart-   ing. Before any inspection, make sure all moving   parts have stopped.   O Check that all adjustments are correct before using   this unit.   O Gasoline is highly flammable. Follow all precautions   listed in your tractor’s operator’s manual.   O Always wear eye protection while operating and per-   forming adjustments to protect eyes from debris   thrown by the dozer.   O Take all possible precautions before leaving opera-   tor’s position. Lower the attachment, set the parking   brake, stop the engine and remove the key.   O When cleaning, repairing, or inspecting the unit make   sure all moving parts have stopped. Disconnect and   secure the spark plug wires and remove the key to   prevent accidental starting.   O Never operate near glass enclosures, automobiles,   window wells, dropoffs, etc.   O Do not put hands or feet near or under the dozer   blade. Keep clear of the dozer blade at all times.   O Do not overload machine capacity by attempting to   clear too much material at too fast a rate.   DANGER   O Never operate unit at high transport speeds on slip-   pery surfaces. Use care when travelling in reverse.   OPERATING ON SLOPES   CAN BE DANGEROUS   For operation on slopes greater than 15% (8.5°),   weight box, tire chains, and wheel weights are   recommended. NEVER OPERATE ON SLOPES   GREATER THAN 17.6% (10°).   O Never operate the dozer blade without good visibility   or light. Always be sure your feet are properly placed   on the footrests and keep a firm hold on the steering   wheel.   O Do not run the engine indoors.   O Never allow anyone in front of the unit.   2 Download from Www.Somanuals.com. All Manuals Search And Download.   Features   & Controls   B CONTROL FUNCTIONS   A The information below briefly describes the   function of individual controls. Operating the   tractor and dozer require the combined use of   these controls and additional controls whose   operation is described in the tractor Operator’s   Manual.   Please Take a moment and   familiarize yourself with the   name, location, and function   of these controls so that you   will better understand the safe-   ty and operating instructions   provided in this manual.   Figure 1. Control Locations   A. Blade Angle Control Lever   B. Attachment Lift   A. Blade Angle Control Lever   The blade angle release lever controls a spring-loaded   plate which locks the blade in one of three positions.   Use an abrupt pushing/pulling motion to release the   angling mechanism and move the blade left or right.   Push the angling lever forward fully to lock the blade in   the left position. Pull the lever fully back to lock the   blade in the right position. Move the lever slowly past   center to lock in the centered position.   NOTE: It is easier to change the angle of the blade with   the attachment raised.   B. Attachment Lift   TRACTOR CONTROLS   The attachment lift lever raises and lowers the dozer   blade. To RAISE an attachment, depress the release   button on top of the lever and pull back. To LOWER an   attachment, depress the release button and move the   lever forward.   Before you begin operating the tractor with the dozer   blade attachment, make certain you have:   • Read and understood the instructions in the   tractor Operator’s Manual.   • Become thoroughly familiar with all of the   tractor controls and their operation, including   how to safely and properly start and stop the   unit.   The back notch suspends the blade for transporting to   and from the worksite. The middle notch is the “float”   position. The front notch applies downward pressure on   the blade. See the Adjustments section for proper blade   adjustment.   • Practice driving in an open area—without doz-   ing—to become accustomed to the unit.   3 Download from Www.Somanuals.com. All Manuals Search And Download.   General   Operating Instructions   Checks Before Starting   WARNING   1. Refer to the Maintenance & Adjustments sections of   this manual and perform any needed service. Also,   refer to the tractor Operator’s Manual and perform   any required service.   Perform the Safety System Interlock test found in   your tractor Operator’s Manual. If tractor does not   pass the test, do not operate the tractor. See your   authorized dealer. Under no circumstances   should you attempt to defeat the safety system.   2. Remove any objects from the work area which might   interfere with plowing activity.   Use caution when plowing a snow covered area.   Snow can cover objects such as curbs, drop-offs,   and other obstacles. Be familiar with the area you   are plowing.   3. Adjust the skid shoes to desired height. See Skid   Shoe Adjustment.   4. Make sure all hardware is present and secure.   To prevent an explosion or fire, never store the   tractor with fuel in the tank inside a building   where an ignition source is present.   Engine & Ground Speed Selection   Always run the engine at full throttle.   Set tractor speed to obtain the needed power to move   the material. Operate at a safe speed, depending on   conditions, so that you have complete control of the trac-   tor. Rear wheel weights and chains are recommended   for slippery surfaces.   IMPORTANT NOTE   To prevent damage to the unit, always   raise the dozer blade BEFORE turning or   backing up.   A rear weight carrier is recommended for additional trac-   tion.   DANGER   OPERATING ON SLOPES CAN BE DANGEROUS   Transporting   Never operate on slopes greater than 17.6% (10°)   which is a rise of 3-1/2 feet (106cm) vertically in   10 feet (607cm) horizontally.   For maximum ground clearance, transport the blade to   and from work areas fully raised and angled straight   ahead.   Operate the unit at a slow ground speed when   driving onto slope. Avoid using brakes to control   ground speed.   Starting & Stopping   When operating on slopes that are greater than   15 % (8.5°) but less than 17.6%, use additional   wheel weights or counterweights.   1. Start the tractor engine. Set engine throttle to full.   2. Raise the attachment lift and travel to the work site.   3. Set the angling control to the desired angle.   4. Lower the attachment lift and begin plowing.   5. Raise the plow before backing up.   In addition to counterweights, use extra caution   when operating on slopes. Drive UP and DOWN   the slope, never across the face, use caution   when changing directions and DO NOT START   OR STOP ON SLOPE.   6. To stop the tractor, set ground speed to neutral and   set the parking brake. Before leaving the seat, stop   the engine, set the parking brake, remove the key,   and wait for all moving parts to stop.   For additional traction, tire chains and a weight   box can be added. Maximum weight added to   tractor should not exceed 35 lbs. per wheel and   100 additional lbs. in weight box.   4 Download from Www.Somanuals.com. All Manuals Search And Download.   General Operating Instructions   Changing Angle of the Blade:   Snow Plowing Tips   See Figure 1 for location of Controls.   • Determine the best snow removal pattern before   beginning.   NOTE: It is easier to change the angle of the blade with   the attachment raised.   • Plan the pattern so that you avoid pushing snow onto   cleared areas.   1. Raise the attachment lift.   • When land contour permits, it is best to travel in the   longest direction to minimize turning.   2. Use an abrupt pushing/pulling motion to release the   angling mechanism and move the blade left or right.   Push the angling lever forward fully to lock the blade   in the left position. Pull the lever fully back to lock the   blade in the right position. Move the lever slowly over   center to lock in the centered position.   • In very deep or heavy snow, it may be necessary to   make the first pass with dozer blade partially raised,   then repeat each pass with the blade lowered to clear   the material left on the surface. Also, it may be nec-   essary to clear less than the full width of the dozer   blade or reduce ground speed.   Dozing Tips   • Snow tends to freeze into solid banks when plowed   off a driveway or other large area. Because of this   you may want to plow snow several feet past the   edge of the drive to allow space for future plowing to   build up.   • Determine the best dozing pattern before beginning.   • When land contour permits, it is best to travel in the   longest direction to minimize turning.   • In very deep snow or gravel, it may be necessary to   make the first pass with dozer blade partially raised,   then repeat each pass with the blade lowered to clear   the material left on the surface. Also, it may be nec-   essary to clear less than the full width of the dozer   blade or reduce ground speed.   • If pushing snow past the edges of driveways or side-   walks, be careful not to tear up the grass buried   under snow next to the drive or sidewalk. Lift the   blade several inches off the ground to avoid damag-   ing the grass.   • Spinning tires with tire chains can leave unsightly   marks or permanent damage to asphalt or concrete   driveways or sidewalks. Avoid sudden stops or   starts.   • When dozing, push the dirt to the desired location,   then drag the blade backwards for final leveling. Pack   down the dirt or gravel by driving the tractor over the   leveled area.   • Use any slight grade to your advantage, doze down-   hill, and set the blade angle so that the plowed mater-   ial is moving downhill as it leaves the blade.   Storage   Off-Season Storage   IMPORTANT NOTE   Refer to Tractor Operator’s Manual for   important information concerning safely   storing your tractor.   1. Remove dozer blade and hitch from the tractor.   2. Use water pressure or a brush to thoroughly clean   the dozer blade.   3. Paint, or lightly coat with oil, any area where paint   has been worn or chipped away.   Daily Storage   4. Lubricate the dozer blade.   1. Allow tractor engine to cool before storing in any   enclosure.   5. Store the dozer blade and hitch in a dry place.   2. After dozing or plowing jobs are completed, hose or   brush down the blade to remove excess dirt.   3. Lightly oil all pivot points. Coat bare metal surfaces to   prevent corrosion.   5 Download from Www.Somanuals.com. All Manuals Search And Download.   Maintenance   WARNING   Lubricate Dozer Blade   To avoid serious injury, perform maintenance on   the tractor or dozer blade only when the engine is   stopped, parking brake is set and all moving parts   have stopped. Always remove the ignition key   before beginning maintenance or adjustments to   prevent accidental starting of the engine.   Lubricate the dozer blade as shown in Figure 2. Where   an oil can is shown, wipe the area clean, apply a few   drops of oil (SAE 30), then wipe up drips or spills.   In general, linkage connections and other parts that have   partial rotational or sliding movement should be lubricat-   ed periodically with SAE 30 weight oil. Avoid applying   excessive amounts of oil since this may cause a build-up   of dirt around the lubricated area, making subsequent   lubrication more difficult to accomplish.   Schedule For Normal Care   Care Required   Schedule   Clean debris from   dozer blade.   After each use.   Lubricate dozer blade.   Every 10 hours or at   least once a year.   Figure 2. Lubrication Points   6 Download from Www.Somanuals.com. All Manuals Search And Download.   Adjustments   Skid Shoe Adjustment   Slotted holes are provided to permit adjustment of the   shoe assemblies for raising and lowering the blade to   various working heights (see Figure 3).   When cleaning snow from gravel or earth drives or   walks, the shoe assemblies should be lowered fully to   prevent blade contact with gravel or ground. When   cleaning smooth hard surfaces like concrete, the shoe   assemblies are normally placed fully up to allow the   blade to scrape the surface.   To adjust the skid, raise the blade off the ground and   block with a piece of wood. Loosen the bolts (B, Figure   3) and move the skid shoes (A) up or down to desired   height. Tighten the bolts securely.   Figure 3.   A. Skid Shoes   B. Bolts   Spring Tension   See Figure 4. This snow plow/dozer blade is spring   loaded so that when the blade strikes a solid object, the   springs will allow the blade to release as shown, rather   than cause damage. The blade will go back to its original   position after object is cleared.   Figure 4. Dozer Blade “Released”   See Figure 5. To adjust spring tension hold rear nut (B)   and loosen front nut (E). Tighten rear nut (B) to increase   spring tension, or loosen to decrease tension.   For initial adjustment, tighten nut (B) on each eyebolt   enough to expose about 3/4" (19mm) of thread. Tighten   front nut (E) against rear nut (B) to lock adjustment in   place.   Figure 5. Tension Springs   A. Eyebolt   B. Nut, 5/16   C. Spring   D. Pivot Frame   E. Nut, 5/16   7 Download from Www.Somanuals.com. All Manuals Search And Download.   Adjustments   Lift Rod Adjustment   A B The lift lever can be placed in one of three notches and   is held in position by the lever latch. (see Figure 7).   When the lever latch is placed in notch 1 the lift lever   should be applying downward pressure on the attach-   ment. In position 2, the “float” position, the attachment   should experience negligible upward or downward pres-   sure. Position 3 should raise the attachment approxi-   mately 6“ above the ground.   C D E NOTE: Always adjust the lift height before and after   adjusting the downward pressure.   LIFT HEIGHT ADJUSTMENT   1. Place the lever latch in notch 3 (see Figure 7). The   snowthrower should be approximately 6” off the   ground. If not, go to step 2.   Figure 6. Adjusting Lift Rod   A. Front Set Collar   B. Rod Guide   C. Spring   D. Rear Set Collar   E. Spring Clip   2. Lower the attachment and adjust the front set collar   (A, Figure 7) to achieve the correct lift height.   DOWNWARD PRESSURE ADJUSTMENT   Notch 1   IMPORTANT NOTE   Notch 2   Notch 3   DO NOT OVER-COMPRESS THE SPRINGS.   In addition to providing downward pressure,   the springs are an elastic medium that   absorbs shocks caused by bumps and   cracks in ground surfaces. Over-compress-   ing the springs defeats this and may cause   damage to the unit.   1. Move the lever latch from notch 2 to notch 1 (See   Figure 7).   2. The spring (C, Figure 6) should be slightly com-   pressed applying downward pressure to the   snowthrower. If not, adjust the rear set collar (D,   Figure 6) to achieve the desired amount of downward   force. Do not over-compress the lift rod spring.   Figure 7. Lift Lever Quadrant - Side View   8 Download from Www.Somanuals.com. All Manuals Search And Download.   Initial Setup   & Assembly   Packaged with Hitch   1 4 31   32   33   5 4 3 6 4 30   2 4 3 34   8 9 7 35   10   36   29   39   28   37   36   11   12   27   2 26   25   38   22   10   24   23   Control Rod Guide   Used with Snowcabs   40   41   34   21   20   42   19   16   34   18   17   43   13   15   14   16   Figure 8.   Ref Qty Description   Ref Qty Description   LOCKNUT, 1/2-13   1 2 3 4 5 6 7 8 9 10   11   12   13   14   15   16   17   18   19   20   21   22   1 6 2 4 2 1 1 1 1 3 1 1 1 6 ROD, Control Handle, Upper   NUT, Hex, 5/16-18   LOCKWASHER, 5/16   WASHER, 5/16   CAPSCREW, 5/16-18 x 1-1/4   ROD, Control Handle, Lower   CLEVIS   WASHER, 1/2   CLIP, Hair Pin   COTTER PIN   23   24   25   26   27   28   29   30   31   32   33   34   35   36   37   38   39   40   41   42   43   2 1 2 2 1 1 2 1 1 1 2 4 2 2 1 1 2 1 1 1 1 FRAME ASMY, Dozer   EYEBOLT   SPRING, Extension   CLIP, Hair Pin   PLATE ASMY, Latch   SPRING, Torsion   EYEBOLT, 1/4-20 x 1-1/2   LOCKNUT, Nylock, 1/4-20   BRACKET, Control Rod   CARRIAGE BOLT, 5/16-18 x 1-1/4   WASHER, 5/16   LOCKNUT, Center, 5/16-18   PIN, Clevis   PIN, Clevis   CLIP, Hair Pin   CLIP, Safety   CAPSCREW, 5/16-18 x 1-1/2   BRACKET, Control Rod   NUT, Hex, Full, 5/16   LOCKWASHER, 5/16   ROD & PLATE ASMY, Pivot   DOZER BLADE ASMY, 42”   SCRAPER BAR   CARRIAGE BOLT, 3/8-16 x 1   10 LOCKWASHER, 3/8   6 2 4 4 2 2 1 NUT, Hex, 3/8-16   SKID SHOE   WASHER, Plain, 3/8   CAPSCREW, 3/8-16 x 3/4   CAPSCREW, 1/2-13 x 1-1/2   SPACER, 1/2 ID x 3/4 OD x 5/16 LG   ROD, Latch Stop   9 Download from Www.Somanuals.com. All Manuals Search And Download.   Components   F C B C D E D M A L J K F Q P I N O G F H Q G Figure 9. Hitch Assembly   A. Hitch Assy.   J. Capscrew, 3/8-16 x 2   B. Rear Support Assy.   C. Washers (Qty. 2)   D. Hairpin Clip (Qty. 2)   E. Pin   K. Spacer, 25/64 x 5/8 x 17/64   L. Spacer, 13/32 x 1 x 13/16   M. Nut, Whizlock, 3/8-16   N. Lockwasher, 1/2   F. Safety Clip (Qty. 4)   G. Clevis Pin, 3/8 (Qty. 2)   H. Rod   O. Hex Nut, 1/2-13   P. Capscrew, 1/2-13 x 1-1/4   Q. Upstop (Qty. 2)   I. Spring Assist Bracket   10   Download from Www.Somanuals.com. All Manuals Search And Download.   Initial Setup & Assembly   Figure 10. Bar Stop   A. Bar Stop   B. Taptite Screw, 5/16-18 x 1   Figure 11. Tension Springs   A. Eyebolt   B. Nut, 5/16   C. Spring   D. Pivot Frame   E. Nut, 5/16   INITIAL SETUP & ASSEMBLY   NOTE: Some of the following setup procedures may   already be completed.   Assemble Blade   E 1. Place the blade on a flat surface.   2. See Figure 10. Install one bar stop (A) using the two   5/16-18 x 1 taptite screws (B). Do not install second   bar stop.   A 3. See Figure 11. Insert threaded end of eyebolt (A)   through lug on blade, and screw on 5/16 nut (B) just   far enough so that it is flush with the end of the eye-   bolt.   4. See Figure 11. Hook the springs (C) into the pivot   frame (D). Using a pliers, stretch the springs to hook   the opposite ends to the eyebolts (A).   B D C 5. See Figure 11. Tighten the nut (B) on each eyebolt   enough to expose about 3/4" (19 mm) of thread.   Figure 12. Spring Assist Bracket   A. Spring Assist Bracket   B. Capscrew, 1/2-13 x 1-1/4   C. Lockwasher, 1/2   D. Hex Nut, 1/2-13   E. Hitch   6. See Figure 11. Holding the first nut (B) with a   wrench,add a second nut (E) to each eyebolt, and   tighten securely against the first nut to act as a jam   nut.   Assemble & Install Hitch   1. See Figure 12. Assemble the spring-assist bracket   (A) to the hitch assembly (E). Secure with capscrew,   lockwasher, and nut.   11   Download from Www.Somanuals.com. All Manuals Search And Download.   Initial Setup & Assembly   2. Increase front tire pressure to 20 psi (138 kPa) to   compensate for added weight of the hitch, plus bar   and blade. Be sure both tires have equal pressure.   A 3. From the front of tractor, slide the hitch under the   tractor so that the hitch bar is positioned at the front of   the unit.   C 4. See Figure 13. Turn the wheels fully left and lift the   front hitch bar (A) up onto the tractor brackets (D).   Make sure it is fully seated into the tractor brackets.   Install the long hitch pin (B) through the bracket (bot-   tom rear holes) and up-stop brackets (E). Secure it   with the safety clip (C).   E B D NOTE: If your tractor is not equipped with the Large Lift   Lever, install it at this time. Follow the instructions sup-   plied with the kit.   Figure 13. Installing Hitch to Front of Tractor   A. Hitch Bar   B. Hitch Pin   C. Safety Clip   D. Tractor Brackets   E. Up-Stop Brackets   Note that the rear bracket (A, Figure 14) is mounted   using the lift lever rod (B). After installation, the lift lever   rod assy. can be removed by pivoting the lift lever fully   forward until it is parallel to the ground, and sliding it out   of the quadrant   5. See Figure 14. Slide the rear bracket (A), and wash-   ers (D), onto the lift lever shaft, and secure with the   hairpin clips (C).   K C 6. See Figure 14. Position the rear plate of the hitch   assembly between the hanger tabs on the rear brack-   et, and secure at the top mounting hole using the cle-   vis pin (F), and hairpin clip (K).   B A J D F 7. See Figure 14. Install the capscrew (G), spacers (H &   I), and whizlock nut (J) in the lower mounting hole as   shown, and tighten securely.   E G H I 8. The hitch assembly is now assembled to the unit, and   you may proceed to installation of the push bar and   blade.   Figure 14. Installing Hitch to Rear Bracket   A. Rear Bracket G. Capscrew, 3/8-16 x 2   B. Lift Lever Rod H. Spacer, 25/64 x 5/8 x 17/64   C. Hairpin Clip   D. Washer   E. Hitch   I. Spacer, 13/32 x 1 x 13/16   J. Nut, Whizlock, 3/8-16   K. Hairpin Clip   F. Clevis Pin   12   Download from Www.Somanuals.com. All Manuals Search And Download.   Initial Setup & Assembly   Install Push Bar   C 1. Drive the tractor over the push bar until the rear of the   push bar is positioned between the side rail exten-   sions on the front of the hitch.   2. Stop engine, remove key and set parking brake.   D 3. See Figure 15. Align the mounting holes in the rear   corners of the push bar (A) with the mounting holes in   the hitch (B), and secure the push bar to the hitch   with a clevis pin (C), and safety clip (D) at each cor-   ner.   B A Figure 15.   A. Push Bar   B. Hitch   C. Clevis Pin   D. Safety Clip   (Not shown)   4. See Figure 16. Insert front of push bar (A) into pivot   frame (B) on rear of blade. Then install the pivot pin   (C) down thru front holes in hitch and pivot frame.   Secure with spring clip (D).   Figure 16. Dozer Blade Assembled and Installed   A. Push Bar   B. Pivot Frame   C. Pivot Pin   D. Spring Clip   13   Download from Www.Somanuals.com. All Manuals Search And Download.   Initial Setup & Assembly   D C B C B A A Figure 17. Lift Rod Assembly   A. Set Collars   B. Rod Guide   C. Spring   D. Lift Rod   Figure 19. Installing Lift Rod to Manual Lift Lever   A. Lift Rod   B. Manual Lift Lever   C. Spring Clip   C B A E A Figure 18. Lift Rod Installation   A. Rod Guide   B. Push Bar   C. Spring Clip   C D B Figure 20. Install Lift Assist Chain   A. Clevis Pin   B. Spring   C. Chain   D. Safety Clip   E. 5/16 Washers   Install Lift Rod   4. Raise the dozer using the lift lever. Support the   1. Assemble lift rod as shown in Figure17.   weight of the blade using wood blocks. Install the lift   assist spring as shown in Figure 20.   2. See Figure 18. Insert the rod guide (A) through the   hole in the push bar (B), and secure with spring clip   (C).   3. See Figure 19. Connect rear of lift rod (A) to manual   lift lever (B), and secure with spring clip (C).   5. Perform lift rod adjustment (see Adjustments sec-   tion).   14   Download from Www.Somanuals.com. All Manuals Search And Download.   Initial Setup & Assembly   B A C B A Figure 21. Underside of Left Footrest.   A. Carriage Bolt, Lockwasher, & Nut   B. Pedal Plate   Figure 22. Control Rod Support   A. Support   B. 5/16-18 x 1-1/4 Carriage Bolts   C. 5/16 Lockwashers & Nuts   Install Angling Control Rod   NOTE: If installing the dozer attachment on a unit   equipped with a snowcab, replace the control rod sup-   port (A, Figure 22) with the hanging support (Ref. No. 41,   Figure 8). Mount the hanging support to the front cab   cross-bar.   D C B A E 1. Remove and discard the two rear nuts, lockwashers,   and carriage bolts (A, Figure 21) securing the back of   the foot pedal plate (B).   F 2. Using the foot pedal plate (B) as a guide, drill two   5/16” holes up through the foot pedal pad.   3. Set the angling control support (A, Figure 22) on the   foot rest pad. Insert two 5/16-18 x 1-1/4 carriage   bolts (B) through the support, footrest pad, footrest,   and foot pedal plate. Secure using new lockwashers   and nuts (C).   G 4. Connect the lower angling rod (F, Figure 23) to the   dozer release lever using a hair pin clip and washer   (G).   5. Insert the upper control rod (C) through the eyelet   (B), and secure the eyelet to the support using a 1/4-   20 nylock nut (A).   Figure 23. Assemble Control Rods   A. 1/4-20 Nylock Nut   B. Eyelet   NOTE: It may be necessary to leave the eyelet nut (A,   Figure 23) loose to prevent binding.   6 Secure the upper rod (C) to the lower rod (F) using   two 5/16-18 x 1-1/4 capscrews (D), washers (qty. 4),   lockwashers, and nuts (E). NOTE: Match offset to   offset so the rods form a straight line.   C. Upper Control Rod   D. 5/16-18 x 1-1/4 Capscrew   E. 5/16 Washers, Lockwashers, & Nuts   F. Lower Control Rod   G. Hair Pin Clip & Washer   15   Download from Www.Somanuals.com. All Manuals Search And Download.   Removing &   Attaching the Hitch & Blade   A B B C D F E F Figure 24. Dozer Removal   A. Support Arm   B. Hair Pin Clip   C. Pivot Pin   D. Hair Pin Clip & Washer   E. Clevis Pin   F. Clevis Pins   REMOVAL & INSTALLATION   Removing & Attaching Dozer Blade   5. Raise the push bar and remove pin (E) securing the   chain to the hitch bracket.   1. Lower the blade. Put the lift lever in the middle notch   (float position).   6. Lower the lift and remove the pins (B) securing the lift   rod to the push bar and lift rod.   2. Remove the hair pin clip and washer (D, Figure 24)   securing the angling control rod to the clevis.   Disconnect the angling control rod.   7. Remove the pins (F) securing the push bar to the   tractor hitch.   3. Remove the angling control rod from the   support arm (A).   8. Reinstall all pins for storage.   Install in reverse order of removal.   4. Remove the pivot pin (C) connecting the blade and   pushbar. Remove the blade.   16   Download from Www.Somanuals.com. All Manuals Search And Download.   Removing & Attaching   1 K C B J A D F 2 E G H I Figure 25. Installing Hitch to Rear Bracket   A. Rear Bracket G. Capscrew, 3/8-16 x 2   B. Lift Lever Rod H. Spacer, 25/64 x 5/8 x 17/64   3 C. Hairpin Clip   D. Washer   E. Hitch   I. Spacer, 13/32 x 1 x 13/16   J. Nut, Whizlock, 3/8-16   K. Hairpin Clip   F. Clevis Pin   A Figure 26. Lift Lever Removal   A. Capscrew Location (Remove)   Removing & Attaching Hitch   1. Remove the safety clip (K, Figure 25).   A 2. Remove the spring clips (C) securing the rear hitch   bracket (A) to the lift lever rod (B).   3. See Figure 26. Remove the caspcrew from location   (A). Depress the lift lever release button and rotate   the lever forward until the lever latch clears the   mounting bracket. Slide the lever and rod assembly   out of the hitch bracket and mounting bracket.   C E B D 4. See Figure 27. Remove the safety clip (C) and long   hitch pin (B) from the front of the hitch. Remove the   hitch from the front tractor brackets.   Install in reverse order of removal.   Figure 27. Installing Hitch to Front of Tractor   A. Hitch Bar   B. Hitch Pin   C. Safety Clip   D. Tractor Brackets   E. Up-Stop Brackets   17   Download from Www.Somanuals.com. All Manuals Search And Download.   Hardware Identification & Torque Specifications   Common Hardware Types   Torque Specification Chart   Hex Head Capscrew   FOR STANDARD MACHINE HARDWARE (Tolerance 20%)   Washer   No   Marks   Hardware   Grade   Lockwasher   Carriage Bolt   SAE Grade 2   SAE Grade 5   SAE Grade 8   Hex Nut   Size Of   in/lbs   in/lbs   in/lbs   Hardware ft/lbs   Nm.   2.1   2.3   3.1   3.5   7.6   ft/lbs   Nm.   3.4   3.5   4.9   5.5   10.9   13.6   23.1   25.8   40.8   ft/lbs   Nm.   4.6   4.9   6.8   7.7   16.3   19.0   34.0   34.0   61.2   Standard Hardware Sizing   8-32   8-36   19   20   30   31   43   49   8 10   17   19   30   35   50   55   75   41   43   60   68   12   14   25   27   45   When a washer or nut is identified as 1/2”, this is the   Nominal size, meaning the inside diameter is 1/2 inch; if a   second number is present it represent the threads per inch   10-24   10-32   1/4-20   1/4-28   5/16-18   5/16-24   3/8-16   3/8-24   7/16-14   7/16-20   1/2-13   1/2-20   9/16-12   9/16-18   5/8-11   5/8-18   3/4-10   3/4-16   7/8-9   27   31   66   76   11   12   20   23   30   35   50   55   65   75   90   100   160   180   140   155   220   240   When bolt or capscrew is identified as 1/2 - 16 x 2”, this   means the Nominal size, or body diameter is 1/2 inch; the   second number represents the threads per inch (16 in this   example, and the final number is the body length of the   bolt or screw (in this example 2 inches long).   8.6   15.0   16.3   27.2   31.3   40.8   47.6   68.0   74.8   88.4   102.0   122.4   136   217.6   244.8   190.4   210.8   299.2   326.4   The guides and ruler furnished below are designed to   help you select the appropriate hardware and tools.   47.6   68.0   74.8   50   70   80   68.0   95.2   108.8   149.6   163.2   204.0   231.2   299.2   326.4   525.0   571.2   816.0   897.6   102.0   122.4   149.6   163.2   204.0   244.8   353.6   408.0   544.0   598.4   788.8   110   120   150   170   220   240   386   420   600   660   Nut, 1/2”   90   Inside   110   120   150   180   260   300   400   440   580   640   Diameter   7/8-14   1-8   1-12   Screw, 1/2 x 2   900 1,244.0   Body   Diameter   870.4 1,000 1,360.0   NOTES   1. These torque values are to be used for all hardware   excluding: locknuts, self-tapping screws, thread forming   screws, sheet metal screws and socket head setscrews.   Body   Length   2. Recommended seating torque values for locknuts:   a. for prevailing torque locknuts - use 65% of grade 5   torques.   b. for flange whizlock nuts and screws - use 135% of   grade 5 torques.   3. Unless otherwise noted on assembly drawings, all torque   values must meet this specification.   Wrench & Fastener Size Guide   1/2   7/16   DIA.   DIA.   3/8   5/16   1/4   1/4” Bolt or Nut   Wrench—7/16”   5/16” Bolt or Nut   Wrench—1/2”   3/8” Bolt or Nut   Wrench—9/16”   7/16” Bolt or Nut   Wrench (Bolt)—5/8”   Wrench (Nut)—11/16”   1/2” Bolt or Nut   Wrench—3/4”   Download from Www.Somanuals.com. All Manuals Search And Download.   Simplicity Mfg. Inc.   500 N Spring Street / PO Box 997   Port Washington, WI 53074-0997 USA   © Copyright 2000 Simplicity Manufacturing, Inc.   All Rights Reserved. Printed in USA.   Download from Www.Somanuals.com. All Manuals Search And Download.   |