OWNER’S MANUAL
For Model: GP200RED
TM
GEORGE FOREMAN
™
Portable Propane Grill
Download from Www.Somanuals.com. All Manuals Search And Download.
IMPORTANT SAFEGUARDS
READ AND SAVE THESE INSTRUCTIONS
WARNING: A risk of fire or explosion exists in all propane grills.
Read this manual before use. Failure to follow all instructions
may result in serious personal injury, property damage, or death.
When using propane grills, basic safety precautions should always be
followed to reduce the risk of fire and injury to persons, including the
following:
1. Read all instructions before using the grill.
2. Do not touch hot surfaces. Use handles or knobs and oven mitts or
pot holders.
3. Keep children and pets away from the grill at all times.
4. This grill is not for use by children.
5. Do not leave this grill unattended while in use.
6. Do not move the grill when in use. Allow to cool before moving,
putting on or taking off parts, and before cleaning and storing the
grill.
7. To disconnect, turn Temperature Control Knob to LOCK/OFF.
8. Do not operate any grill after the grill malfunctions, or has been
dropped or damaged in any manner. Contact Consumer Service for
return authorization, examination, repair or adjustment.
9. The use of accessory attachments not recommended by the grill
manufacturer may cause injuries.
10. This grill is for outdoor use only. NEVER operate grill in enclosed
areas, as this could lead to gas accumulating from a leak, causing
an explosion or a carbon monoxide buildup which could result in
injury or death. DO NOT USE in garages, sheds or any enclosed
areas.
11. Do not use grill for other than intended use.
12. Extreme caution must be used when moving a grill containing hot oil
or other hot liquids. Allow liquid to cool before removing and empty-
ing Drip Tray. Do not remove Grill from Base until Grill is cool.
13. Do not attempt to dislodge food or clean the grill when it is hot.
14. Fuel, such as charcoal briquettes, is not to be used with this grill.
SAVE THESE INSTRUCTIONS
THIS GRILL IS NOT FOR COMMERCIAL USE.
FOR OUTDOOR USE ONLY.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Additional Important Safeguards
1. CAUTION: This grill generates heat and escaping steam during use.
Proper precautions must be taken to prevent the risk of burns, fires or
other damage to persons or property. Use of protective oven mitts or
gloves is recommended.
2. All users of this grill must read and understand this Owner's Manual before
operating or cleaning this grill.
3. When using this grill, provide adequate air space above and on all sides for
air circulation. Do not allow this grill to touch clothing, dish towels or other
flammable materials during use.
4. IMPORTANT: Minimum clearance of 16 inches around all sides of the grill
should always be maintained and the appliance shall not be located under
overhead unprotected combustible construction.
5. If this grill begins to malfunction during use, immediately turn the
Temperature Control Knob to LOCK/OFF. Do not use or attempt to repair the
malfunctioning grill.
6. This outdoor cooking gas grill is not intended for use in or on recreational
vehicles and/or boats.
7. The use of alcohol, prescription or non-prescription drugs may impair the
consumer’s ability to properly assemble or safely operate the grill.
8. When cooking with oil/grease, fire extinguishing materials shall be readily
accessible. In the event of an oil/grease fire do not attempt to extinguish
with water. Use Type BC dry chemical fire extinguisher or smother fire with
dirt, sand or baking soda.
9. In the event of rain while cooking with oil/grease, turn off the grill burner
and gas supply, and immediately cover the Grill Plate. Do not attempt to
move the grill or Grill Plate.
10. When cooking, the grill must be on a level and stable surface in an area
clear of combustible materials. An asphalt surface (blacktop) may not be
acceptable for this purpose.
11. Make sure the grill is in the LOCK/OFF position when placing the Grill Plate
into position.
12. The grill is not intended for and should never be used as a heater.
13. Keep grill area clear and free from combustible materials, gasoline and
other flammable vapors and liquids.
14. Do not obstruct the flow of combustion and ventilation air.
15. Always remove lid before lighting your grill.
16. Do not attempt to disconnect the regulator or any gas fitting while the unit
is in operation.
17. Do not wear clothing with loose flowing sleeves while lighting or using the
grill.
18. Use barbecue tools with long, heat-resistant handles.
19. The grill should never face directly into the wind.
20. Do not operate Grill in a high-traffic area.
21. After use, allow Grill to cool completely before cleaning.
22. We recommend storing Grill indoors or, if unable to store indoors, always
cover Grill with protective cover. Always keep out of the reach of children.
4
Download from Www.Somanuals.com. All Manuals Search And Download.
Special Instructions for the Use of Regulator
and LP (Propane) Cylinders
•
The propane grill is equipped with a regulator
having a CGA No. 600 cylinder connection
device which is for connecting to a one pound
PROPANE cylinder ONLY. See Illustration.
Grill installation must conform with local
codes, or in the absence of local codes, with
the National Fuel Gas Code, ANSI Z223.1,
Storage and Handling of Liquefied Petroleum
Gases, ANSI/NFPA 58 or CSA B149.1, Natural
Gas and Propane Installation Code.
CGA No. 600
.550 Min
(13.96mm)
•
.666 - .750
(16.92 - 19.05mm)
.850 - .935
(21.58 - 23.75mm)
•
Use grill only with LP (propane) gas. Use grill only with the regulator/valve
assembly supplied.
•
•
•
•
•
•
•
Never use charcoal briquettes or lighter fluid in a gas grill.
Discard used and empty fuel cylinder in a safe place.
Store spare fuel canisters in a well-ventilated area away from the grill.
Do not puncture or burn fuel canister.
Do not operate the grill if there is a gas leak present.
Do not enlarge orifice or burner ports when cleaning the regulator and burner.
If you smell gas, turn Temperature Control Knob to LOCK/OFF to shut off gas to
the grill. Extinguish any open flame and open Lid. If odor continues, immedi-
ately call your gas supplier or your fire department.
•
•
•
Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other grill.
An LP cylinder not connected for use shall not be stored in the vicinity of this
or any other appliance.
The LP-gas supply cylinder to be used must be constructed and marked in
accordance with the specifications for LP-gas cylinders of the U.S.
Department of Transportation (DOT) CFR 49 or the National Standard of
Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation
of Dangerous Goods.
•
•
If the grill is not in use, the Temperature Control Knob must be turned to
LOCK/OFF to shut off the gas cylinder. Storage of a grill indoors is permissible
only if the cylinder is disconnected and removed from the grill. Cylinders must
be stored outdoors out of the reach of children and must not be stored in a
building, garage or any other enclosed area.
The regulator may make a humming or whistling noise during operation. This
will not affect safety or use of grill.
Save cylinder cap and reinstall when not in use.
Cylinder supply system must be arranged for vapor withdrawal. The gas cylin-
der must be upright in use. Do not block the pressure relief valve during use
or storage.
Always remove one pound cylinder from grill when transporting and when not
in use.
•
•
•
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Getting To Know Your GP200RED Propane Grill
1
2
}
3
24
4
23
5
22
6
21
20
7
8
19
9
18
17
16
10
11
12
15
14
13
1. Lid Handle/Vent (P/N 21659)
2. Lid Assembly (P/N 21680)
3. Screw/Washer (P/N 21661)
4. Ignitor Assembly (P/N 21648)
5. Ignitor Button
14. Securing Rod (P/N 21686)
15. Apron
16. Storage Arm (2) (P/N 21682)
17. Storage/Leg Frame (P/N 21685)
18. Base Plate (P/N 21683)
6. Temperature Control Knob (P/N 21647) 19. Burner Assembly
7. Regulator (P/N 21663)
8. Side Tray, Left (P/N 21688)
9. Flame Viewing Hole
10. Match Holder (P/N 21656)
11. Transport Handle (P/N 21684)
12. Wheel/Leg Frame (P/N 21681)
13. Wheel (2) (P/N 21687)
20. Side Tray, Right (P/N 21689)
21. Grill Base
22. Side Tray Support Tube/Locking Clip
(P/N 21690)
23. Drip Tray (P/N 21646)
24. Grill Plate (P/N 21645)
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Before First Use
1. Remove the Grill and any packaging materials.
2. Place the Base Frame on a flat, level surface.
3. Lift off the Side Trays and set them to the side. Disconnect the Storage
Arms from the Wheel/Leg Frame to allow access to the Grill Assembly.
4. Remove the Grill Plate, Grill Base, Lid and Drip Tray. Wipe the Grill Base and
Lid with a damp cloth to remove any dust. Wash the Grill Plate and Drip
Tray in warm, soapy water. Rinse
Handle/Vent
and dry thoroughly.
5. The Handle/Vent and mounting
hardware, (Screw/Washer) are
shipped in an inverted fashion,
requiring minor assembly.
Vent Slot
Lid
Remove the Handle/Vent from
the inside of the Lid by unscrew-
ing the Screw/Washer. Remove
all parts, then properly position
the Handle/Vent on the top of the
Screw/Washer
Figure 1
Lid. Make sure the Handle/Vent stop pin enters the Vent slot in the Lid. From
the inside of the Lid, place the Screw/Washer through the hole in the Lid
and Handle/Vent. Securely fasten with a Phillips head screw driver. See
Figure 1.
6. Slide the Drip Tray into the slots in the Grill Base.
7. See "Grilling Positions" on the following pages and place the Grill Base on
the Base Frame.
8. Place the Grill Plate on the Grill Base and place the Lid over the Grill Plate.
Grill Positions
™
The Wheel-It and Grill-It Portable
Propane Grill is compact enough to
transport to any grilling location.
Wheel-It from the storage shed to the
patio, to a picnic in the park, or off on
a camping trip. The Portable Propane
Grill easily transforms from storage to
transport and to high or low Grill-It
positions.
Storage Position: This position
makes the Grill compact enough for
space saving storage. The Side Trays
are stored on the Leg Assemblies and
the Transport Handle slides into the
top of the Frame.
Figure 2
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Grill Positions (Cont.)
Transport Position: To
transform the Grill from
the Storage Position to
the Transport Position,
slide out the Transport
Transport
Handle
Handle from the closed
position and roll away
.
Figure 3
Low Grilling Position:
Using the Grill in the
Low Position is great
for beach barbeques,
camping sites, tail-gate
parties or picnics in the
park.
To transform the Grill
Slots For
Drip Tray
from the Transport Position to
the Low Grilling Position, slide
the Transport Handle into the
Frame, remove both Side
Trays, then lay the GP200RED
down.
Disconnect the Storage Arms
from the Leg Assemblies. Lift
the Grill Assembly from the
Base Frame and set it to the
side, then reconnect the
Storage Arms.
Locator Pegs
Figure 4
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Grill Positions (Cont.)
Low Grilling Position, Continued: . Place the
Grill Base on the Base Frame by placing the
"slot" of the Hook Bracket around the Locator
Peg under the Base Frame. Align the hole in
the front of the Grill Base with the Locator Peg
on the front side of the Base Frame. Make
sure the Grill Base is secure. Place the Grill
Plate on the Grill Base. Slide the Side Trays
into position and attach the Drip Tray into the
slots. Attach the Propane Cylinder. See
'Attaching Propane Gas Cylinder' for details.
The Grill is ready for use.
Upright Grilling Position: This position is ideal
for patio use or any time you feel more com-
fortable Grilling in the standing position.
Figure 5
To transform the GP200RED from the Storage Position to the Upright Grilling Position, lay
unit down, with wheels on ground as seen in
Figure 4. Remove the Side Trays and discon-
nect the Storage Arms. Pull the Securing Rod
from its storage position. Raise the
Storage/Leg Frame upwards and hook the
Securing Rod into the opposing leg. Lift the
Grill Assembly. from the Base Frame, set it to
the side then raise the Frame upright,as seen
in Figure 6.
Place the Grill Base on the Leg Frame with the
Regulator on the same side as the wheels.
Hook the underside of the Grill Base to the
Frame with the Hook Bracket, then press down
evenly and firmly on the Base until the Spring
Figure 6
Lock 'snaps' into place. See Figure 7. Make sure
the Grill Base is secure. Place the Grill Plate,
Side Trays and Drip Tray in position. Attach the
'Slot'
Propane Cylinder as instructed in 'Attaching
Propane Gas Cylinder'. The Grill is ready for use.
Make sure the Drip Tray is in proper position,
and remember that the Grill should always be
operated with the Regulator on the left and the
Drip Tray in the rear.
Hook
Bracket
NOTE: If the Lid is to be removed temporarily it
can be placed on the Base Frame as shown in
Figure 6.
Spring Lock
CAUTION: Never use the Frame as a chair.
Never load anything on the frame except the
Grill. Never load over 6 1/2 lbs. (3kg) on each
Side Tray. It is advisable that two persons
assemble the grill.
Figure 7
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Attaching Propane Gas Cylinder
Turn the Temperature Control Knob to the
LOCK/OFF Position. Push the one pound
propane cylinder slightly into the valve
while turning counterclockwise until a snug
fit is obtained.
Regulator
Assembly
(P/N 21663)
Testing for Leaks
SAFETY PRECAUTIONS:
•
Test all gas connections for leaks before
using your propane grill.
Test for leaks every time you connect
the gas supply.
•
•
•
Do not smoke while checking for leaks.
DANGER - Do not use an open flame to
check for gas leaks. Be sure there are
no sparks or open flames in the area
while you check for leaks. This will
result in a fire or explosion which can
cause serious bodily injury or death,
and damage to property.
•
Test for leaks outdoors in a well venti-
lated area.
1. Mix a couple tablespoons of liquid
detergent with an equal amount of
water. Use mild soap and water. DO
NOT USE HOUSEHOLD CLEANING
AGENTS.
2. Be sure that the Temperature Control
Knob is in the LOCK/OFF position.
Propane
Cylinder
Figure 8
3. Use a clean paint brush to brush soapy solution onto connection
between gas cylinder and Regulator orifice, and watch for bubbles.
4. If bubbles form or if a bubble grows, there is a leak. Retighten connec-
tion and repeat steps (2) and (3).
NOTE: If you cannot stop a leak, remove gas cylinder and check for dam-
aged threads, dirt and debris at the connection and gas cylinder. Also check
to see if anything is obstructing flow of gas at the connection and gas cylin-
der openings. Remove any obstruction that may be found and repeat leak
test.
Checking the Ignitor:
•
The Temperature Control Knob must be in the “LOCK/OFF” position.
Press the Ignitor button rapidly. A “CLICK” should be heard and spark
seen through Flame Viewing Hole.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
How To Use the George Foreman
GP200RED Propane Grill
IMPORTANT: Make sure the Drip Tray is in proper position before use.
Lighting Burner with Ignitor:
1. Turn Temperature Control Knob counterclockwise to “OFF“, push in, and
then turn the Temperature Control knob to your desired setting.
2. To light, rapidly push the Ignitor button down until it "clicks". Use Flame
Viewing Hole to be sure all burner ports light and stay lit.
3. If Ignitor does not work, turn the Temperature Control Knob to OFF/LOCK.
Remove the Lid and Grill Plate to allow the gas to dissipate. Wait five
minutes, then follow match lighting instructions below.
Lighting Burner with Matches:
1. Secure a paper match to Match Holder,
light the match, and place lit match through
the Flame Viewing Hole to the nearest burn-
er ports.
Figure 9
2. Turn Temperature Control Knob counter-
clockwise to “OFF”, push in, and then turn
the Temperature Control Knob to “HIGH”.
WARNING: If burner does not light within 5 seconds, turn Temperature
Control Knob to the LOCK/OFF position. Remove the Lid and Grill Plate to
allow the gas to dissipate. Wait 5 minutes, then try again.
Grilling Instructions:
High
1. Light burner and turn the Temperature
Low
Control Knob from HIGH to LOW. Check
the flame through the Flame Viewing
Figure 10
Hole making sure the burner is lit.
2. To preheat: Place the Lid over the Grill Plate and preheat on HIGH for 8
minutes. During the first use, you may notice a slight odor caused by the
curing of paint and parts. IMPORTANT: Do not leave lid on the Grill Plate
for more than 8 minutes, or without food loaded on the Grill Plate. The
non-stick coating may be damaged.
3. After the 8 minute preheat period, carefully remove the Lid and place
food onto the Grill Plate. Cook until done, turning at least once halfway
through cooking time for most foods. Adjust flame with Temperature
Control Knob as needed.
4. You can control the moisture of foods to some extent by opening or clos-
ing the Lid Vent. Turning the Lid Handle/Vent clockwise will open the
vent for drier cooking. Turning the Lid Handle/Vent counter-clockwise
will reduce the vent opening and retain moisture within the food.
CAUTION: Condensation may collect on the inside of the Lid when
cooking. Use caution when removing Lid.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
How To Use the George Foreman
GP200RED Propane Grill (Cont.)
Grilling Instructions Continued:
5. When the food is cooked, remove with heat resistant plastic or wood-
en spatula or other utensil. Be sure to always use either plastic or
wooden utensils so as not to scratch the non-stick surface. Never use
metal tongs, forks or knives as these can damage the coating on the
Grill Plate.
CAUTION: Do not leave any utensils on the Grill Plate surface while
it is hot.
6. When finished cooking, or when the propane cylinder is empty, turn
the Temperature Control Knob to the LOCK/OFF position and remove
the propane cylinder.
7. Allow the Grill to cool before disassembling and cleaning.
8. When cool, the Drip Tray may be removed and emptied. Be sure the
liquid has cooled before removing Drip Tray.
Grilling Hints and Tips
•
•
•
•
Use tender cuts of meat for grilling.
Marinate tougher cuts of meat to tenderize them before grilling.
To avoid drying out meat and fish, turn only once and do not pierce.
To turn meat and fish, use a large flat plastic or wooden spatula to
support the food.
•
Place meat or chicken to be roasted in a shallow baking pan. Using
oven mitts carefully place pan on preheated Grill, taking care not to
scratch the non-stick surface. Place Lid on the Grill Plate.
NOTE: Just resting a baking container on top of the non-stick sur-
face will not damage it. Do not use saucepans or plates.
•
•
Do not cut food on non-stick surface.
Use only heat resistant plastic or wooden utensils on non-stick sur-
faces.
•
•
Adjust heat setting gradually and only as necessary. Cooking foods at
too high a temperature can cause them to dry out.
When grilling fish or chicken breast fillets, tuck extremely thin parts
under to prevent over cooking.
12
Download from Www.Somanuals.com. All Manuals Search And Download.
Grilling Guide
The following times are to be used as a guideline only. Preheat the Grill for eight minutes.
Cooking times will vary due to the cut or thickness of the meat being cooked. To be sure
that the food is done, use a meat thermometer. If the food is not quite done, continue to
cook and check periodically so it is not over cooked.
Food &
Quantity
Temperature Approximate
Special
Instructions
Setting
Cooking Time
Beef
Hamburgers,
4 oz. each, 3/4" thick
Hamburgers,
8 oz. each, 1" thick
Ribeye Steak,
12 oz. each, 1/2" thick
Medium High
Medium High
Medium High
12-15 min.
Turn halfway
through cooking time.
Turn halfway
15-18 min.
through cooking time.
Med.-Rare 4-5 min. Turn halfway
Medium 5-6 min.
Well 6-7 min.
through cooking time.
Ribeye Steak,
Medium High
Medium High
Medium High
Medium
Med.-Rare 7-8 min. Turn halfway
8 oz. each, 1" thick
Medium 8-9 min.
through cooking time.
Well 9-10 min.
Med.-Rare 5-6 min. Turn halfway
T-bone Steak,
6 oz. each, 1/2" thick
Medium 6-7 min.
Well 7-8 min.
through cooking time.
T-bone Steak,
8 oz. each, 1" thick
Med.-Rare 8-9 min. Turn halfway
Medium 9-10 min. through cooking time.
Well 10-11 min.
Beef Kabobs
Well 15-20 min.
Marinate in oil and
seasoning. Turn often
during cooking time.
Pork
Pork Chops, bone-in,
Medium Low
Med. 6-7 min.
Well 8-9 min.
Med. 16-17 min.
Well 18-19 min.
Well 9-15 min.
Turn halfway
through cooking time.
Turn halfway
through cooking time.
Turn frequently while
cooking
4-6 oz. each, 1/2" thick
Pork Chops, boneless, Medium Low
8 oz. each, 1 1/4" thick
Bacon
Medium
Medium
Low
Pork Sausage Patties,
1 1/2 oz. each, 1/2" thick
Spare Ribs, 1 slab,
Well 6-8 min.
Turn halfway
through cooking time.
Parboil for 15 minutes
before putting on grill.
Cook 30 minutes,
turn halfway through
cooking time. Add
barbeque sauce. Turn
after 10-15 minutes
and add sauce to
other side. Cook
another 10-15 min.
Well 50-60 min.
each pc 3 rib sections
PLEASE NOTE: The USDA recommends that meats such as beef and lamb, etc. should be cooked to an
internal temperature of 145˚ - 170˚F, pork should be cooked to an internal temperature of 160˚F -170˚F,
and poultry products should be cooked to an internal temperature of 170˚F - 180˚F to be sure any harm-
ful bacteria has been killed. When reheating meat/poultry products, they should also be cooked to an
internal temperature of at least 165˚F.
13
Download from Www.Somanuals.com. All Manuals Search And Download.
Grilling Guide (Cont.)
Food &
Quantity
Temperature Approximate
Special
Instructions
Setting
Cooking Time
Chicken
Whole Chicken,
3 1/2 - 5 lbs.
Low
1 - 1 3/4 hrs.
Brush with oil,
Kitchen Bouquet®
and seasonings.
Place in a large size
Reynolds® Hot
Bag™. Follow direc-
tions for whole roast
chicken on the grill.
Turn halfway through
cooking time.
Whole Chicken,
cut into pieces
Chicken Breast,
boneless-skinless,
6 oz. each
Medium High
Medium High
Well 17-35 min.
Well 15-18 min.
Turn as necessary
during cooking time.
Turn halfway
through cooking time.
Chicken Wings
Medium High
Medium High
Medium
Well 15-18 min.
Well 25-35 min.
Well 15-20 min.
Turn as necessary
during cooking time.
Leg Quarters
Turn halfway
through cooking time.
Chicken Kabobs
Marinate in oil and
seasoning. Turn often
during cooking time.
Seafood
Tuna Steak,
Medium
6-9 min.
Turn halfway
through cooking time.
Turn halfway
through cooking time.
Tuck under thin parts.
Turn halfway through
cooking time.
1" thick
Salmon Steak,
1" thick
Orange Roughy Fillet,
1" thick
Medium
7-9 min.
Medium Low
10-13 min.
Large Black Tail Shrimp, Medium Low
deveined-split shell
4-6 min.
Turn halfway
through cooking time.
Miscellaneous
Corn on the Cob
Low
40-50 min.
Soak in husk for 20
min. and wrap in foil.
Turn halfway through
cooking time.
Baked Potatoes
High
1 - 1 1/4 hrs.
10-15 min.
Pierce potatoes, oil
and season skins.
Wrap in foil. Turn
halfway through
cooking time.
Pineapple Slices,
1/2" thick
Medium
Turn halfway through
cooking time.
14
Download from Www.Somanuals.com. All Manuals Search And Download.
Grilling Guide (Cont.)
Food &
Quantity
Temperature Approximate
Special
Instructions
Setting
Cooking Time
Miscellaneous
Zucchini, 1/2" thick,
sliced from end to end
Medium
10-15 min.
Brush with oil,
and seasonings.
Turn halfway through
cooking time.
Peppers,
(red, yellow & green),
rings & slices, 1/2" thick
Medium
Medium
10-12 min.
15-20 min.
Marinate in oil and
seasoning. Turn
halfway through
cooking time
Marinate in oil and
seasoning. Turn
halfway through
cooking time
Turn halfway through
cooking time.
Turn halfway
through cooking time.
Turn halfway through
cooking time.
Turn halfway through
cooking time.
Peppers,
(red, yellow & green),
quartered, sliced
from end to end
Bratwurst, 1" thick
Medium
High
Well 15-20 min.
12-15 min.
12-15 min.
12-15 min.
8-10 min.
Cooked Ring Polish
Kielbasa, 1 1/2" thick
Cooked Beef Bratwurst, High
1" thick
Cooked Kielbasa,
1" thick
Hot Dogs, 3/4" thick
High
High
High
Turn halfway through
cooking time.
Turn halfway through
cooking time.
Jumbo Hot Dogs,
1" thick
10-12 min.
15
Download from Www.Somanuals.com. All Manuals Search And Download.
Instructions For Cleaning
CAUTION: Grill surfaces are hot during use. Allow Grill Plate, Drip Tray, Lid
and Grill Base to cool completely before handling and cleaning.
1. Turn the Temperature Control Knob to the LOCK/OFF position and allow the
Grill to cool before disassembling and cleaning.
2. Remove the propane cylinder.
3
Remove the Grill Plate and empty the Drip Tray.
4. Wash the Grill Plate and Drip Tray with warm, soapy water and a plastic
scouring pad. Rinse and dry thoroughly. Do not use steel wool, coarse
scouring pads or harsh or abrasive cleaners. If necessary, use a nylon
bristle brush to loosen hardened food particles.
5. Wash the inside of the Lid with a solution of mild detergent and water or
use a grill cleaner with nylon bristle brush. Rinse and allow to completely
air dry. Do not use a caustic grill cleaner.
6. Wash exterior parts with a soft sponge and warm clear water.
Nonabrasive cleaners may also be
used.
Bottom View of
Regulator Assembly
7. Use a damp cloth to clean the inside
of the Grill Base.
Cleaning the Burner Assembly
IMPORTANT: Clean burner assembly
prior to use after storing, at the beginning
of grilling season or an inactive period of
one month. Spiders and insects like to
build nests in burner tubes, especially
Clip
during colder months. The nests can
(P/N 21643)
cause fires in burner tubes or under grill.
In order to clean the inside of the burner
tubes, the Burner Assembly must be
removed from the Grill. Make sure the
propane cylinder, Lid, Grill Plate and Drip
Tray have been removed before proceed-
ing.
Figure 11
Venturi
Hex Nut
1. Turn the Grill Base upside down.
Refer to Figure 11 and locate the clip
that holds the venturi to the Regulator
Assembly. Pull straight up on the clip
and set it to the side.
2. Refer to Figure 12 and locate the two
machine screws that secure the
Burner Assembly to the Grill. Loosen
and remove these screws, making
sure you retain the screws, washers
and hex nuts for reassembly.
Machine Screw
and Washer
Figure 12
16
Download from Www.Somanuals.com. All Manuals Search And Download.
Instructions For Cleaning (Cont.)
3. Carefully pull back on the Burner Assembly, disengaging the venturi from
the Regulator Assembly. Please see Figure 12. Since the Ignitor is still
attached to the Burner Assembly, use care to avoid stressing the cable.
There is enough slack available to allow you to look into the end of the
venturi and clean with a pipe cleaner if needed.
4. When clean, carefully reassemble the Burner Assembly, making sure the
mounting screws are tight and the venturi tube and clip are properly con-
nected to the Regulator Assembly.
5. Clean the outside of the Burner Assembly with a paper towel or damp
sponge. Open any clogged holes with a thin wire.
Storing Your Propane Grill
1. Clean the Grill as instructed above.
2. Store the propane cylinder outdoors in a well-ventilated space and out of
reach of children.
3. Cover Grill when stored outdoors.
4. Store Grill indoors only if the propane cylinder is turned off and discon-
nected, removed from Grill and stored outdoors.
5. When removing Grill from storage, follow the "Cleaning the Burner
Assembly" instructions before starting the Grill.
Any servicing requiring disassembly other than the above cleaning must be
performed by an authorized appliance repair technician.
Do NOT ship gas cylinder if product needs service or repair.
17
Download from Www.Somanuals.com. All Manuals Search And Download.
Recipes
The Champ’s Sausage Without Guilt
Try this sizzling sausage patty that not only tastes good, but is also good
for you. Choose ground turkey breast, which is lower in fat than ground
turkey containing dark meat and skin. Turkey, especially the light meat, is
a good source of niacin, which is an important B vitamin needed to
maintain a healthy nervous system. Early symptoms of niacin deficiency
that appear in the nervous system are apprehension, irritability, depres-
sion, weakness, and loss of memory. To prevent niacin deficiency,
include plenty of lean turkey, fish, whole wheat, potatoes, corn flower,
eggs, broccoli, tomatoes, and carrots.
2 slightly beaten egg whites
2/3 cup finely chopped onion
1/2 cup finely snipped dried apples or 1 cup finely chopped fresh red
Delicious apple
1/2 cup seasoned bread crumbs
4 Tbsp. snipped fresh parsley
1 tsp. sea salt
1 tsp. ground sage
1/2 tsp. ground nutmeg
1/2 tsp. black pepper
1/4 tsp. cayenne pepper
1 lb. lean ground turkey breast
• In a medium bowl, combine all ingredients except turkey. Add the
ground turkey and mix well.
• Shape the mixture into sixteen to eighteen 2-inch wide patties.
• Preheat the Grill on MED for 8 minutes.
• Place sausage on the Grill. Cover and cook for 6-7 minutes.Turn and
cook another 6-7 minutes or until the meat is no longer pink and the
juices run clear.
• Serves 8
This recipe is from "The Healthy Gourmet" (Clarkson Potter) by Cherie
Calbom.
18
Download from Www.Somanuals.com. All Manuals Search And Download.
George’s Sausage Texas Style
A spicy sausage with true Southwestern zip! These breakfast sausages
are great served with a sautéed vegetable or fresh salsa and scrambled
eggs. Buy 90% lean ground beef for the least-fat sausage. Ninety per-
cent lean beef has 9 grams of fat with 4 of those grams being saturated
fat; whereas 73% lean beef has 18 grams of fat with 7 of the grams being
saturated.
2 slightly beaten egg whites
2/3 cup finely chopped onion
1/2 cup seasoned bread crumbs
1/2 cup diced green chili peppers
2 cloves (large) garlic, finely minced
4 Tbsp. snipped fresh cilantro
2 Tbsp. apple cider vinegar
1 Tbsp. chili powder
1/2 tsp. sea salt
1/4 tsp. cayenne pepper
1 lb. lean ground beef
• In a medium bowl, combine all ingredients except ground beef. Add
the ground beef and mix well.
• Shape the mixture into sixteen 3-inch wide patties.
• Preheat the Grill on MED/HIGH for 8 minutes.
• Place the patties on the Grill.
• Cover and cook for 5-6 minutes. Turn and cook for another 5-6 min-
utes or until meat is no longer pink and the juices run clear.
• Serves 8
This recipe is from "The Healthy Gourmet" (Clarkson Potter) by Cherie
Calbom.
19
Download from Www.Somanuals.com. All Manuals Search And Download.
Recipes (Cont.)
George Foreman’s Power Burger
A flavorful hamburger that we think tastes even better than its all-meat
cousin! It pays to eat meals that minimize meat. To reduce saturated fat
in a typical burger, you can cut back on the amount of meat and make up
for it with plant-based ingredients. Bread crumbs and chopped vegeta-
bles have been added in this recipe. You could also try cooked rice, other
grains or cereal. In addition, choose whole wheat buns; they typically
contain one less fat gram than regular or even reduced-calorie buns.
If you settle for nothing less than a cheeseburger, Swiss cheese is 1
gram lower in fat than Cheddar, American or Monterey Jack with 8
grams of fat versus 9 in each ounce of cheese. However, reduced fat
cheeses like Cheddar or Swiss contain half the fat with 4 grams per
ounce. Mustard contains 1 gram of fat per tablespoon versus a whop-
ping 11 grams of fat in a tablespoon of mayonnaise.
Top your burger in healthful style with dark, leafy green lettuce, shredded
cabbage, fresh cilantro, basil or spinach.
3/4 cup chopped vegetables such as yellow onions,
green onions, zucchini, parsley (can be sautéed)
3/4 cup seasoned bread crumbs
2-1/4 lbs. lean ground beef
• In a medium-size mixing bowl, combine the vegetables and bread
crumbs. Add the ground beef and mix well.
• Shape the mixture into twelve 4-inch wide patties.
• Preheat the Grill on MED/HIGH for 8 minutes.
• Place the patties on the Grill.
• Cover and cook 6-8 minutes. Turn and cook another 6-7 minutes or
until the meat is no longer pink and the juices run clear.
• Serves 12
This recipe is from "The Healthy Gourmet" (Clarkson Potter) by Cherie
Calbom.
20
Download from Www.Somanuals.com. All Manuals Search And Download.
Grilled Vegetables
12 slices eggplant (or 8 baby eggplants)
4 small onions
4 small tomatoes
2 small zucchini
8-12 mushrooms
8 large cloves of garlic, peeled and sliced 1/4" thick
2/3 cup olive oil
4 tablespoons Italian seasoning
• Slice all vegetables 1/2 inch thick.
• Brush vegetables and garlic lightly with olive oil.
• Sprinkle Italian seasoning on both sides of vegetables and garlic.
• Preheat the Grill on MED for 8 minutes.
• Place vegetables and garlic on Grill. Cover and cook for 7-8 minutes.
Turn and cook another 10-15 minutes or until desired doneness is
achieved.
• Serves 6-8
Serve as an accompaniment to meat and pasta, or stuff them into a piece
of pita or French bread for a grilled vegetable sandwich.
Mustard Lemon Chicken Breasts
4 tablespoons mustard
4 tablespoons balsamic vinegar
6 tablespoons lemon juice
4 cloves garlic, minced
2 tsp. paprika
8 6-oz. chicken breast, halved, boneless and skinless
• In a medium non-metal bowl, combine all ingredients except chicken.
• Add chicken breast and let it marinate for at least 1/2 hour in the
refrigerator.
• Preheat the Grill on MED for 8 minutes.
• Place chicken on Grill. Cover and cook for 9-10 minutes. Turn and
cook another 9-10 minutes or until meat is no longer pink and the
juices run clear.
• Serves 8
21
Download from Www.Somanuals.com. All Manuals Search And Download.
Recipes (Cont.)
Rosemary Lamb Chops
16 loin lamb chops (1/2" thick)
4 tsp. chopped fresh rosemary
ground black pepper to taste
• Sprinkle chops with rosemary and pepper.
• Preheat Grill on MED/HIGH for 8 minutes.
• Place meat on Grill. Cover and cook 3-4 minutes. Turn and cook for
another 3-4 minutes or until desired doneness.
• Serves 8
22
Download from Www.Somanuals.com. All Manuals Search And Download.
23
Download from Www.Somanuals.com. All Manuals Search And Download.
LIMITED ONE YEAR WARRANTY
™
Warranty: This George Foreman product is warranted by Salton, Inc. to be free from defects in
materials or workmanship for a period of (1) year from the original purchase date. This product
warranty covers only the original consumer purchaser of the product.
Warranty Coverage: This warranty is void if the product has been damaged by accident in ship-
ment, unreasonable use, misuse, neglect, improper service, commercial use, repairs by unautho-
rized personnel, normal wear and tear, improper assembly, installation or maintenance abuse or
other causes not arising out of defects in materials or workmanship. This warranty is effective only
if the product is purchased and operated in the USA, and does not extend to any units which have
been used in violation of written instructions furnished with the product or to units which have
been altered or modified or to damage to products or parts thereof which have had the serial num-
ber removed, altered, defaced or rendered illegible.
Implied Warranties: ANY IMPLIED WARRANTIES WHICH THE PURCHASER MAY HAVE ARE LIMIT-
ED IN DURATION TO ONE (1) YEAR FROM THE DATE OF PURCHASE. Some states do not allow limi-
tations on how long an implied warranty lasts, so the above limitation may not apply to you.
Warranty Performance: During the above one-year warranty period, a product with a defect will
be either repaired or replaced with a reconditioned comparable model (at our option) when the
product is returned to the Repair Center, or the purchase price refunded. The repaired or replace-
ment product will be in warranty for the balance of the one-year warranty period and an additional
one-month period. No charge will be made for such repair or replacement.
Service and Repair: Should the appliance malfunction, you should first call toll-free 1 (800) 937-
3883 between the hours of 9:00 am and 5:00 pm Central Standard Time and ask for CONSUMER
SERVICE stating that you are a consumer with a problem. Please refer to model number GP200RED
when you call.
In-Warranty Service (USA): For an appliance covered under the warranty period, no charge is
made for service or postage. Call for return authorization (1 800 937-3883).
Out-of Warranty Service: A flat rate charge by model is made for out-of-warranty service. Include
$20.00 (U.S.) for return shipping and handling. We will notify you by mail of the amount of the
charge for service and require you to pay in advance for the repair or replacement.
For Products Purchased in the USA, but Used in Canada: You may return the product insured,
packaged with sufficient protection, and postage and insurance prepaid to the USA address listed
below. Please note that all customs duty / brokerage fees, if any, must be paid by you and we will
require you to pay the cost of customs duty / brokerage fees to us in advance of our performing
any service.
Risk During Shipment: We cannot assume responsibility for loss or damage during incoming ship-
ment. For your protection, carefully package the product for shipment and insure it with the carrier.
Be sure to enclose the following items with your appliance: any accessories related to your prob-
lem, your full return address and daytime phone number, a note describing the problem you experi-
enced, a copy of your sales receipt or other proof of purchase to determine warranty status. C.O.D.
shipments cannot be accepted.
To return the appliance, ship to:
To contact us, please write to, call, or email:
Attn: Repair Center
Salton, Inc.
Salton, Inc.
P.O. Box 1526
708 South Missouri Street
Macon, MO 63552
Columbia, MO 65205-1526
1(800) 937-3883
Email: [email protected]
Limitation of Remedies: No representative or person is authorized to assume for Salton, Inc. any
other liability in connection with the sale of our products. There shall be no claims for defects or
failure of performance or product failure under any theory of tort, contract or commercial law
including, but not limited to negligence, gross negligence, strict liability, breach of warranty and
breach of contract. Repair, replacement or refund shall be the sole remedy of the purchaser under
this warranty, and in no event shall Salton be liable for any incidental or consequential damages,
losses or expenses. Some states do not allow the exclusion or limitation of incidental or conse-
quential damages, so the above limitation or exclusion may not apply to you.
Legal Rights: This warranty gives you specific legal rights, and you may also have other rights
which vary from state to state.
™
George Foreman is a trademark of Salton, Inc.
“© 2002 Salton, Inc.
All Rights Reserved”
P/N 60906 Rev. 2
Printed in China
Download from Www.Somanuals.com. All Manuals Search And Download.
|