IMPORTANT NOTICES
The Razor electric scooter must reach a speed of three miles per hour before the motor
will engage.
Owner’s Manual
+ Safety Handbook
Ride only on smooth hard and dry surfaces. The Razor was not intended for off-road or
hilly terrain. Use caution when approaching curbs, uneven pavement, potholes or
similar conditions. Avoid water. The tires are extremely slippery when wet. You could
lose traction and fall.
The Razor is designed for only one rider. Do not attempt to ride with more than one person
or attempt to tow anything behind your scooter.
Not recommended for children under 16 without adult supervision.
Maximum weight capacity on flat and level ground: 120 pounds.
WARNING: Intermittent motor operation is an indication of low charge. When this occurs,
turn the unit off and charge the battery.
Be sure to read and understand this manual thoroughly before operating your scooter.
Additional warnings enclosed.
To obtain service under this warranty you must, within the warranty period, contact Razor
USA LLC directly by e-mail at warranty@ razorusa.com. Razor will provide repair parts
and or replacement at its sole discretion. Authorized warranty service is ONLY available
from Razor USA LLC or its authorized Repair Center(s).
©2002 Copyright Razor USA LLC. All rights reserved. Rev 7.15.02 RAH
Specifications subject to change without notice.
Photos by Arthur Cambridge.
Razor USA LLC
Cerritos, California 90703
Download from Www.Somanuals.com. All Manuals Search And Download.
2. Slip the peg slots, which are located on either side of the
XLR8R Motor, onto the mounting pegs, which are located on
either side of the mounting bracket.
Attaching the power control
Attaching the motor
3. Insert the handle hooks into the mounting slots and press the
handle downward until it comes in contact with the XLR8R Motor
housing.
Final connection of the wiring (right)
Charging the Battery
4. Attach the Power Control to the scooter's handlebars by first
placing the steerer tube clip around the steering tube and then
sliding the Power Control up until the handlebar clip attaches onto
the handlebar. Then plug the power cord into the XLR8R Motor
cord. Make sure the plug is fully inserted. A partially inserted plug
may cause erratic operation.
The XLR8R Motor comes with a 12V battery. The unit can be
charged on the scooter or it can be removed from the scooter
during the recharging process.
4
5
Download from Www.Somanuals.com. All Manuals Search And Download.
warranty and may damage the battery or cause a fire hazard. Do
not use the XLR8R charger to charge anything other than the
XLR8R battery. Stop using the charger if its wires become worn or
damaged in any way. Replace the charger with a new XLR8R
battery charger.
To operate the XLR8R motor
1. Turn the XLR8R's power switch to the On position.
2. Grasp the scooter's handlebars firmly.
3. Position one foot on the scooter's deck.
4. Pull the XLR8R trigger switch. DO NOT USE THE BRAKE
AND TRIGGER AT THE SAME TIME.
5. Using your other foot, give a strong push so as to propel the
scooter at a rate of 3 mph.
Charger port and on/off switch
Note that the XLR8R motor will not engage until the scooter is
traveling 3 mph. This approach extends battery run time, prolongs
motor life, and enables children to learn to start off on a XLR8R
powered scooter more easily.
The battery must be fully charged before initial use.
Initial charging time on the XLR8R battery may be a few minutes
to up to 8 hours. Only charge the battery indoors in a dry location.
Note: If the XLR8R does not turn on,
WARNING: The battery charger is not intended for use by
children. The XLR8R battery should always be charged by an
adult. Children should be kept away from the battery and charger
during the charging process. Only use XLR8R-brand battery
packs. Do not disassemble, incinerate or dispose of the battery in
fire. Dispose of used battery properly. There is a danger of
explosion if battery is incorrectly replaced. The battery may
present a risk of fire or chemical burn if mistreated.
1. Check to see that the battery is charged
2. Check to make sure the battery is connected inside the case.
3. Check to make sure the power switch is in the on position.
WARNING: Do not allow the XLR8R to “run on” if the drive
system slips on the wheel and forward speed has slowed or
stopped. Release the trigger before you come to a stop when
slowiing down. DO NOT USE THE BRAKE AT THE SAME TIME
AS THE TRIGGER.
CAUTION: Do not charge the XLR8R battery in wet
conditions. Only use the battery charger that accompanies your
XLR8R Motor. Use of any other charger voids the XLR8R
6
7
Download from Www.Somanuals.com. All Manuals Search And Download.
XLR8R Motor Limited Warranty
General Terms
WARNING: Intermittent motor operation is an indication of
low charge. When this occurs, turn the unit off and charge the
battery.
Commencing on the date of purchase, your XLR8R Motor has a
60-day (the "Warranty Period") Limited Warranty, which covers the
XLR8R against defects in materials, components, and
Maintenance of Your XLR8R Motor
workmanship. This Limited Warranty applies only to the original
consumer and is not transferable to any other person. This
warranty gives you specific legal rights, and you may also have
other rights, which may vary from state to state.
Your XLR8R Motor contains no user-serviceable parts. Never
attempt to service your XLR8R by yourself. Servicing or modifying
any of the XLR8R's internal components by yourself may damage
the XLR8R and will void your warranty. Service by anyone other
than the XLR8R service center will void the warranty agreement.
Exclusive Remedies
This Limited Warranty is limited to the repair or replacement of any
components of the XLR8R Motor found to be defective within the
Warranty Period. Some states do not allow limits on how long an implied
warranty lasts so the above limit may not apply to you.
WARNING: Intermittent motor operation may be an
indication of low charge. When this occurs, turn the unit off and
charge the battery.
The manufacturer is not liable for incidental or consequential loss or
damage due directly or indirectly from the use of this product. Some
states do not allow exclusions or limitations of incidental or consequential
damages, so the above limitation or exclusion may not apply to you.
Removing the XLR8R
PUSH THE RELEASE BUTTON AS SHOWN IN THE PHOTO
BELOW TO RELEASE THE LATCH MECHANSIM. FAILURE
TO USE THE RELEASE BUTTON MAY DAMAGE THE LATCH.
LATCH DAMAGE DUE TO IMPROPER USE IS NOT
COVERED UNDER THE XLR8R WARRANTY.
This Limited Warranty is the only warranty for your XLR8R Motor. No
other warranties exist that extend beyond the description on the face
hereof.
Limitations
The XLR8R Motor is designed for recreational use only. This warranty
does not cover ordinary wear and tear or maintenance. Any damage,
failure or loss caused by improper assembly, maintenance, use, or
storage of the XLR8R Motor by an party voids this Limited Warranty.
Failure to comply with the instructions and safety information in the
owner's manual voids this Warranty. Any evidence of consumer repair
voids this Warranty.
Push button to release the lever (arrow)
8
9
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty Service
If your XLR8R Motor requires service due to a defect in material or
workmanship during the Limited Warranty period, contact Razor USA via
SB 1918 (California) declaration:
If you require Warranty service, you will be responsible for paying for the
entire cost of shipping your XLR8R to the service center. You must
include within the package your name, address, daytime telephone
number, and a receipt showing the date of purchase.
YOUR INSURANCE POLICIES MAY NOT PROVIDE COVERAGE FOR ACCIDENTS
INVOLVING THE USE OF THIS SCOOTER. TO DETERMINE IF COVERAGE IS
PROVIDED, YOU SHOULD CONTACT YOUR INSURANCE COMPANY OR AGENT.
10
11
Download from Www.Somanuals.com. All Manuals Search And Download.
|