¨
ª
Patent Pending
Model No. PFAW75072
Serial No.
Write the serial number in the space
above for future reference.
Serial Number Decal
QUESTIONS?
As a manufacturer, we are com-
mitted to providing complete
customer satisfaction. If you
have questions, or find that
there are missing or damaged
parts, we will guarantee com-
plete satisfaction through direct
assistance from our factory.
TO AVOID UNNECESSARY
DELAYS, PLEASE CALL DIRECT
TO OUR TOLL-FREE CUS-
TOMER HOT LINE. The trained
technicians on our customer hot
line will provide immediate
assistance, free of charge.
CUSTOMER HOT LINE:
1-800-999-3756
Mon.ÐFri., 6 a.m.Ð6 p.m. MST
CAUTION
Read all precautions and in-
structions in this manual before
using this equipment. Save this
manual for future reference.
USER'S MANUAL
Download from Www.Somanuals.com. All Manuals Search And Download.
BEFORE YOU BEGIN
Thank you for selecting the innovative PROFORM¨
AIR WALKER. The AIR WALKER blends advanced
engineering with contemporary styling to provide you
with a no-impact, total body workout in the conve-
nience and privacy of your own home.
(excluding holidays). To help us assist you, please
note the product model number and serial number
before calling. The model number is PFAW75072. The
serial number can be found on a decal attached to the
AIR WALKER (see the front cover of this manual for
the location of the decal).
For your benefit, read this manual carefully before
using the AIR WALKER. If you have questions after
reading the manual, call our Customer Service
Department toll-free at 1-800-999-3756, Monday
through Friday, 6 a.m. until 6 p.m. Mountain Time
Before reading further, please review the drawing
below and familiarize yourself with the parts that are
labeled.
Electronic Monitor
Crossbar Cover
Handle
Lock Knob
Resistance Dial
Resistance Cylinder
Frame
Leg
Upright
Round Tube
Wheel
Pedal
3
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY
Place all parts of the AIR WALKER in a cleared area and remove the packing materials. Do not dispose of the
packing materials until assembly is completed. Read through all assembly steps before you begin.
Assembly requires an allen wrench
and an adjustable wrench
(included), a phillips screwdriver
(not included).
,
1. Refer to figure 1b. Move to the front of the AIR
WALKER and place your hands on the Frame (1)
in the indicated locations. Hold the AIR WALKER
in the position shown in figure 1a. Put your foot on
the round tube. Using your foot, pull the round
tube toward you until the Uprights (5, 6) come to
rest against the stops. Make sure that the Uprights
are completely extended and are resting against
the stops before you proceed with assembly.
Fig. 1b
Fig. 1a
Back
Hands
Front
1
5
6
Foot
Stop
1
Round
Tube
2. Slide a Lock Washer (16) onto the Lock Knob (32).
Insert the Lock Knob (32) into the hole near the
top of the Left Leg (2). Tighten the Lock Knob into
the Link Plate (7).
Fig. 2
32
16
7
2
3. The Electronic Monitor (9) requires two ÒAAÓ
batteries (not included). Alkaline batteries are
recommended. Press the tab on the battery cover
and remove the battery cover from the Monitor.
Insert two batteries into the Monitor. Make sure
that the negative (Ð) ends of the batteries are
touching the springs in the Console. Close the
battery cover.
Fig. 3
9
Batteries
Battery
Cover
Tab
4
Download from Www.Somanuals.com. All Manuals Search And Download.
4. Connect the Reed Switch Wire (12) to the wire on
the Electronic Monitor (9). Feed any excess wire
into the Crossbar Cover (19). Press the Monitor
onto the Crossbar so the Fasteners (48) on the
Monitor snap into the holes in the Crossbar.
Fig. 4
9
48
48
12
19
5. Slide one of the Handles (8) onto the Left Leg (2).
Attach the Handle with two Button Head Screws
(50) and two 1/4Ó Locknuts (23). Tighten the
Locknuts until the Handle cannot move. The
Handle will be deformed slightly when the
Locknuts are properly tightened.
Fig. 5
8
Attach the other Handle (8) to the Right Leg (3) in
the same manner.
50
23
8
3
Holes
2
6. The decal shown at the right is found in the indi-
cated location on the AIR WALKER. If the decal
is missing, or if it is not legible, call our
Fig. 6
!
Customer Service Department, toll-free, to
order a free replacement decal (see ORDER-
ING REPLACEMENT PARTS on the back of this
manual). Apply the decal in the location shown.
Do not allow children on or
around machine.
Keep hands and feet away
from moving parts and contact
points.
Read owner's manual and
follow instructions.
Make sure that all parts are properly tightened before
you use the AIR WALKER.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
HOW TO USE THE AIR WALKER
ELECTRONIC MONITOR MODES
CAUTION: When mounting and dismounting
the AIR WALKER, adjust the resistance to a
high setting, hold the handles firmly, and be
sure that your body weight is centered direct-
ly over the pedals.
The simple-to-operate electronic monitor offers
five different modes to provide instant exercise
feedback. The five modes are described below:
SpeedÑDisplays the number of repetitions you are
performing per minute.
EXERCISING ON THE AIR WALKER
TimeÑDisplays the length of time you have exer-
cised. Note: If you stop exercising for ten seconds or
longer, the time mode will pause until you resume.
Make sure that the lock knob is tightened into the left
leg and link plate (see assembly step 2 on page 4).
Adjust the resistance to a high setting, hold the han-
dles, and step onto the pedals. The proper form for
exercising on the AIR WALKER is similar to the
motion of walkingÑmove one leg forward as you
move the other leg back.
DistanceÑDisplays the total number of repetitions
you have completed, up to Ò999.Ó The display will then
reset to Ò0Ó and continue counting.
CaloriesÑDisplays the approximate number of
Calories you have burned. Note: If the resistance is
near the highest or lowest setting, the actual number
of Calories you have burned will be slightly higher or
lower than the number displayed.
For a full body workout, hold the handles as you walk
and move your arms and legs in motion with the han-
dles and pedals. To vary the effect of the exercise on
your muscles, change your stance on the AIR
WALKER. For example, change the position of your
hands on the handles, or bend your legs slightly
instead of keeping them straight.
ScanÑDisplays the speed, time, distance, and calo-
ries modes, for approximately 5 seconds each,
in a repeating cycle.
For a lower body workout, rest your hands on the
crossbar cover for balance as you move the pedals.
DIAGRAM OF THE ELECTRONIC MONITOR
RESISTANCE ADJUSTMENT
To vary the intensity of your workout, the resistance of
the AIR WALKER can be adjusted. To change the
resistance, turn the resistance dials on the resistance
cylinders. There are twelve different resistance levels.
Arrows on the resistance cylinders will show which
resistance level is selected. Select the same resis-
tance level on both cylinders.
1
2
CAUTION: The resistance cylinders become very
hot during use. Allow the resistance cylinders to
cool before touching them. When adjusting the
resistance, touch only the resistance dials.
3
4
1. LCD displayÑDisplays all modes.
2. Mode indicatorsÑShow which mode is selected.
3. Mode buttonÑSelects all modes.
Resistance
Dial
4. On/Reset buttonÑTurns the power on and resets
all modes.
6
Download from Www.Somanuals.com. All Manuals Search And Download.
BATTERY INSTALLATION
Speed, time, distance, or calories modeÑ
These modes can be individually selected by
Before the electronic monitor can be operated, two
ÒAAÓ batteries must be installed. If you have not
installed batteries, see assembly step 3 on page 4.
repeatedly
pressing
the mode
button. The
OPERATING THE ELECTRONIC MONITOR
mode indi-
cators will
1. To turn on the power, press the on/reset button or
simply begin exercising on the AIR WALKER. The
entire display will appear for two seconds. The
electronic monitor will then be ready for operation.
show which
mode has
been
selected.
(Make sure
2. Select one of the five modes:
that the scan mode is not selected.) The modes
will be selected in the following order: speed, time,
distance, calories, scan.
Scan modeÑWhen the power is turned on, the
scan mode will be selected automatically. The
scan mode
can also be
selected by
repeatedly
pressing the
mode but-
3. The monitor has an auto-off feature to turn off
the power. If the pedals are not moved and the
monitor buttons are not pressed for four minutes,
the power will turn off automatically in order to
conserve the batteries.
ton. One
mode indi-
To reset the LCD display, press the on/reset button.
cator will
show that
the scan
mode has been selected, and a second mode indi-
cator will show which mode is currently displayed.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
STORAGE AND TROUBLE-SHOOTING
Inspect and tighten all parts of the AIR WALKER reg-
ularly. Replace any worn parts immediately.
HOW TO FOLD THE AIR WALKER FOR STORAGE
When the AIR WALKER is not in use, it can be folded
for storage. To fold the AIR WALKER, first remove the
lock knob from the left leg. Next, move to the front of
the AIR WALKER and place one foot on the round
tube. Firmly grasp the frame with your hands in the
locations indicated below. While holding the round
tube stationary with your foot, pull the top of the AIR
WALKER toward you until the uprights fold against
the frame. Place the AIR WALKER in a location
where it cannot fall.
The AIR WALKER can be cleaned with a soft, damp
cloth. Keep liquids away from the electronic monitor.
Keep the monitor out of direct sunlight or the display
may be damaged. Remove the batteries when storing
the AIR WALKER.
REPLACING THE BATTERIES
If the display of the electronic monitor becomes dim,
or if the monitor does not function properly, the batter-
ies should be replaced. To replace the batteries, first
lift the monitor from the crossbar cover (see assembly
step 4 on page 5). Make sure that the reed switch
wire is fully connected to the wire on the monitor. To
replace the batteries, refer to assembly step 3 on
page 4.
Lock
Knob
Front
Hand
Back
Frame
Round
Tube
Upright
8
Download from Www.Somanuals.com. All Manuals Search And Download.
CONDITIONING GUIDELINES
The following guidelines will help you to plan your
exercise program. Remember that proper nutrition and
adequate rest are essential for successful results.
your body begin to use stored fat calories for energy. If
your goal is to burn fat, adjust your pace until your
heart rate is near the lowest number in your training
zone as you exercise. It may also be helpful to set the
dials on the resistance cylinders at level 1, 2, 3, or 4.
WARNING: Before beginning this or any exer-
cise program, consult your physician. This is
especially important for persons over the age
of 35 or persons with pre-existing health
problems.
For maximum fat burning, adjust your pace until your
heart rate is near the middle number in your training
zone as you exercise.
Aerobic Exercise
EXERCISE INTENSITY
If your goal is to strengthen your cardiovascular sys-
tem, your exercise must be Òaerobic.Ó Aerobic exercise
is activity that requires large amounts of oxygen for
prolonged periods of time. This increases the demand
on the heart to pump blood to the muscles, and on the
lungs to oxygenate the blood. For aerobic exercise,
adjust your pace until your heart rate is near the high-
est number in your training zone. It may also be help-
ful to set the dials on the resistance cylinders at level
5, 6, 7, or 8.
Whether your goal is to burn fat or strengthen your
cardiovascular system, the key to achieving the
desired results is to exercise with the proper intensity.
The proper intensity level can be found by using your
heart rate as a guide. The chart below shows recom-
mended heart rates for fat burning, maximum fat burn-
ing, and cardiovascular (aerobic) exercise.
Strength Training
To strengthen and tone your muscles, you must exer-
cise your muscles at a moderate to high percentage of
their capacity. Set the dials on the resistance cylinders
at level 9, 10, 11, or 12.
HOW TO MEASURE YOUR HEART RATE
To measure your heart rate, first exercise for at least
four minutes.
Then, stop
exercising and
place two fin-
gers on your
To find the proper heart rate for you, first find your age
near the bottom of the chart (ages are rounded off to
the nearest ten years). Next, look above your age and
find the three numbers in light grey boxes. The three
numbers are your Òtraining zone.Ó The lowest number
is the recommended heart rate for fat burning; the
middle number is the recommended heart rate for
maximum fat burning; the highest number is the rec-
ommended heart rate for aerobic exercise.
wrist as
shown. Take a
six-second
heartbeat
count, and
multiply the
result by 10 to
find your heart
rate. For example, if your six-second heartbeat count
is 14, your heart rate is 140 beats per minute. (A six-
second count is used because your heart rate will
drop rapidly when you stop exercising.)
Fat Burning
To burn fat effectively, you must exercise at a relative-
ly low intensity level for a sustained period of time.
During the first few minutes of exercise, your body
uses easily accessible carbohydrate calories for ener-
gy. Only after the first few minutes of exercise does
Adjust the intensity of your exercise until your heart
rate is at the desired level. You can adjust the intensity
of your exercise by adjusting the resistance or by
changing your pace.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
WORKOUT GUIDELINES
when you stop exercising suddenly. Stretching for
increased flexibility is also most effective after exercis-
ing. A proper cool-down should leave you relaxed and
comfortably tired.
Each workout should include the following three parts:
A warm-up, lasting 5 to 10 minutes. Begin with slow,
controlled stretches, and progress to more rhythmic
stretches to increase the body temperature, heart rate,
and circulation in preparation for strenuous exercise.
EXERCISE FREQUENCY
To maintain or improve your condition, plan three
workouts each week, with at least one day of rest
between workouts. After a few months of regular exer-
cise, you may complete up to five workouts each
week, if desired.
Training zone exercise, consisting of 20 to 30 min-
utes of exercising with your heart rate in your training
zone.
A cool-down, with 5 to 10 minutes of stretching.
Thorough stretching helps to offset problems caused
Remember, the key to success is make exercise a
regular and enjoyable part of your everyday life.
PART LISTÑModel No. PFAW75072
R0497A
Key No. Qty.
Description
Key No. Qty.
Description
1
2
3
4
5
6
7
8
1
1
1
1
1
1
1
2
1
1
1
1
2
2
4
1
4
1
1
1
1
2
4
1
1
2
Frame
Left Leg
Right Leg
Rocker Arm
Left Upright
Right Upright
Link Plate
Handle
Electronic Monitor
Adhesive Tool Clip
Magnet
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
#
1
1
4
2
2
1
2
6
1
2
2
3
2
2
2
2
2
1
2
8
2
2
1
4
2
1
Right Pedal Cover
Left Pedal Cover
#8 x 3/4Ó Screw
Resistance Cylinder
Tree Fastener
Lock Knob
Button Head Screw
Upright Endcap
1/2Ó x 2Ó Bolt
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
1/2Ó Axle Cap
1/2Ó x 3 3/4Ó Bolt
1/2Ó Nylon Locknut
1/2Ó Flat Washer
Wheel Screw
3/8Ó Nylon Locknut
Wheel
3/8Ó Flat Washer
5/8Ó Axle Cap
Frame Endcap
#8 x 1/2Ó Screw
Handle Grip
Double Tree Fastener
Star Washer
Button Head Screw
3/8Ó Push Nut
UserÕs Manual
Reed Switch Wire
Link Arm
Link Arm Joint
Small Bronze Bushing
Lock Washer
Large Bronze Bushing
ÒDÓ Bushing
Crossbar Cover
Left Leg Cover
Right Leg Cover
Axle Cover
1/4Ó Locknut
Left Axle Spacer
Right Axle Spacer
Rocker Arm Spacer
Note: Ò#Ó refers to a non-illustrated part. Specifications are subject to change without notice. See the back cover
of this manual for information about ordering replacement parts.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
EXPLODED DRAWINGÑModel No. PFAW75072
R0497A
8
47
9
48
35
49
19
50
11
34
22
34
47
23
26
18
1
10
12
17
33
4
34
36
37
39
17
26
38
29
38
36
29
17
30
50
22
8
6
23
14
51
33
40
30
34
13
15
25
42
44
45
31
21
32
15
43
39
41
20
45
51
34
43
42
40
37
24
15
16
28
14
13
3
15
5
7
2
34
27
46
46
11
Download from Www.Somanuals.com. All Manuals Search And Download.
HOW TO ORDER REPLACEMENT PARTS
To order replacement parts, simply call our Customer Service Department toll-free at 1-800-999-3756, Monday
through Friday, 6 a.m. until 6 p.m. Mountain Time (excluding holidays). To help us assist you, please be pre-
pared to give the following information when calling:
¥ The MODEL NUMBER of the product (PFAW75072).
¥ The NAME of the product (PROFORM¨ AIR WALKER).
¥ The SERIAL NUMBER of the product (see the front cover of this manual).
¥ The KEY NUMBER and DESCRIPTION of the part(s) from page 10 of this manual.
PROFORM is a registered trademark of ICON Health & Fitness, Inc.
LIMITED WARRANTY
ICON Health & Fitness, Inc. (ICON) warrants this product to be free from defects in workmanship and
material, under normal use and service conditions, for a period of ninety (90) days from the date of pur-
chase. This warranty extends only to the original purchaser. ICON's obligation under this warranty is lim-
ited to replacing or repairing, at ICON's option, the product at one of its authorized service centers. All
products for which warranty claim is made must be received by ICON at one of its authorized service cen-
ters with all freight and other transportation charges prepaid, accompanied by sufficient proof of purchase.
All returns must be pre-authorized by ICON. This warranty does not extend to any product or damage to
a product caused by or attributable to freight damage, abuse, misuse, improper or abnormal usage or
repairs not provided by an ICON authorized service center, to products used for commercial or rental pur-
poses, or to products used as store displays. No other warranty beyond that specifically set forth above
is authorized by ICON.
ICON is not responsible or liable for indirect, special or consequential damages arising out of or in con-
nection with the use or performance of the product or damages with respect to any economic loss, loss
of property, loss of revenues or profits, loss of enjoyment or use, costs of removal, installation or other
consequential damages of whatsoever nature. Some states do not allow the exclusion or limitation of inci-
dental or consequential damages. Accordingly, the above limitation may not apply to you.
The warranty extended hereunder is in lieu of any and all other warranties and any implied warranties of
merchantability or fitness for a particular purpose is limited in its scope and duration to the terms set forth
herein. Some states do not allow limitations on how long an implied warranty lasts. Accordingly, the above
limitation may not apply to you.
This warranty gives you specific legal rights. You may also have other rights which vary from state to state.
ICON HEALTH & FITNESS, INC., 1500 S. 1000 W., LOGAN, UT 84321-9813
Part No. 138193 G01447AC R0497A
Printed in USA © 1997 ICON Health & Fitness, Inc.
Download from Www.Somanuals.com. All Manuals Search And Download.
|