Model #WMT-1390S-1
13' x 10' Screenhouse
OWNER’S MANUAL
Download from Www.Somanuals.com. All Manuals Search And Download.
REPLACEMENT PARTS
5B
1
5
GBLT-03
5B
1B
1B
5
1
GBLR-03
2
GBLL-03
1
2B
GBLT-03
2B
1B
1B
2B
GBLR-03
1B
GBLL-03
4
Model # WMT-1390S-1
HOW TO ORDER REPLACEMENT PARTS
Always mention the Model number in all correspondence regarding your tent and when ordering
replacement parts. To order replacement parts listed below, or for any questions regarding your tent,
call 1-800-775-1965 Mon.–Fri, 8:00 a.m. to 5:00 p.m. (PST-West Coast)
or write to: Ozark Trail • 3333 Yale Way • Fremont, CA 94538-6169
WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFORMATION:
1. Model Number 2. Part Number 3. Part Descriptions
QTY. REQ.
DESCRIPTION
PART NO.
RPL2-03
RP2B-03
SPL1-03
MPL5-03
MP5B-03
LPL4-03
PL1B-03
GBLL-03
GBLR-03
GBLT-03
CBAG-03
PBAG-03
SBAG-03
UN-GROPE
Roof pole “2”
Roof pole “2B”
Side pole “1”
3
9
4
2
2
4
12
2
2
2
1
1
1
Middle (roof) pole ”5” with hook
Middle (roof) pole “5B” with hook
Leg pole “4” with holes
Pole “1B” used on side and leg
3 way hub Gable L
3 way hub Gable R
3 way hub Gable T
Carry bag
Pole bag
Stake bag
Guy rope
4
UN-75ABSSTK 7.5" Steel Stake
18
8
4
UN-DRING
Steel D-ring
Steel S-hook
UN-STSHOOK
PSET-03
SSET-03
Poles/ set of 36
Stakes/ set of 18
1
1
Download from Www.Somanuals.com. All Manuals Search And Download.
ASSEMBLY INSTRUCTIONS: WMT-1390S-1
IMPORTANT: WE ADVISE YOU TO ASSEMBLE THE TENT ONCE BEFORE GOING CAMPING TO ASSURE THAT
ALL PARTS ARE PRESENT AND TO BECOME FAMILIAR WITH THE ASSEMBLY OF THE TENT.
To prolong the life of the tent floor, select a level, clean area for the campsite.
Insert the leg poles into the hubs to raise the
screenhouse frame. Make sure that the pole
Step 1 – Lay Out the Screenhouse and Poles
Select a smooth, level site and spread out your
screenhouse.
end with the holes in the sides ( ) is pointing
C
down. See Diagram 3.
Sort the poles by number and connect the
sections together. See diagrams below for
Step 3 –Secure the Screenhouse
Drape the screenhouse body over the frames.
numbering.
R
Hook the S-Hooks into one of the holes
C
B
2
T
2B
2B
located at the bottom of the leg poles.
2B
2B
2
L
2B
2B
2B
Wrap the velcro tape , located inside the
D
2
2B
screenhouse, around the poles to secure them.
2B
When the screenhouse is in its proper location,
stake it down by driving stakes through the
L
Diagram 1
T
T
E
four D-rings
located on at the corners.
R
hub
Step 4 – Install the Guy Lines
Tie the loose end of a guy line through D-ring H
Repeat for the other three guy lines.
1
5B
5
T
5B
1B
2
1B
Make a loop at the end of the guy line with the
slider. Stake the looped end of the line out
about 3' from the base of the pole. Adjust the
5
L
R
1
1
2B
1B
2B
Diagram 2
slider until the line is taut
.
G
L
2B
R
2
2
2B
2B
2B
1B
2B
2B
2B
1B
slider for adjusting
guy line tension
1B
1B
1B
1B
C
1B
4
4
4
1B
Diagram 3
4
Step 2 – Install the Poles
Insert the ends of each of the three roof poles
into the 3-way hubs A . See Diagram 1.
Insert the four side roof poles into the 3-way
hubs. See Diagram 2.
Download from Www.Somanuals.com. All Manuals Search And Download.
D
(inside screenhouse)
H
G
E
B
Taking Down Your Tent
–
Place pole bag on back end of tent (trapped air is
more easily forced out of the open door when
you are rolling up the tent.) The folded tent
should be the width of the pole bag.
–
–
–
–
Unzip doors and windows and collapse the tent,
removing and disassembling the poles. Place
poles in the pole storage bag and tie shut.
Remove stakes. Do not remove stakes from the
ground by pulling on the stake loops. This may
cause the stake loops to tear out of the seam.
front of tent
(door unzipped)
Spread tent out flat with all loose fabric and
rainfly (if tent has one) within the edges of the
tent base. Try to flatten tent as much as possible.
–
–
Beginning at the back end, roll your tent tightly
around the pole bag, forcing out excess air as you
roll. Keep tent edges straight and pole bag
centered as you roll.
Fold tent in half, thirds or quarters. (Folding
depends on the length of the tent pole sections.)
Dimension A should
When tent is rolled up, tie strap around it and
place into tent carry bag with stake bag, instruc-
tion sheet, and other miscellaneous parts. If tent
won’t fit into bag, unroll and reroll more tightly.
Fold tent into a
rectangular shape.
be close to but not
exceed the length of
the pole bag.
A
Download from Www.Somanuals.com. All Manuals Search And Download.
CAMPER’S CHECKLIST AND HELPFUL HINTS
SAFETY AND HEALTH AIDS
• Insect repellents
• Suntan lotions
KITCHEN EQUIPMENT
• Camp stove
• Grill top and charcoal
• Fire starter
• First aid kit
• Life preservers
• Fry pan
• Sauce pans
CAMP NEEDS
• Coffee pot
• Axe or hatchet
• Pocket knife
• Heavy-duty aluminum foil
• Pot holders
• Sewing kit
• Mixing and serving spoons
• Cooking fork, tongs, spatula
• Kitchen knives
• Can/bottle opener
• Storage containers
• Cooler
• Heavy-duty tape
• Rope and clothes pins
• Small shovel (to extinguish fires)
• Fishing rod and other sporting gear
• Broom
• Whisk broom
• Ice pack
• Compact tool kit
• Hammer or mallet
• Insulated jug
• Water container
• Tablecloth, napkins, plates
• Mugs, glasses
• Table knives, forks, spoons
• Dish pan
• Detergent
• Pot scrubbers
• Plastic garbage bags
• Paper towels
CAMPING EQUIPMENT
• Tent
• Sleeping bags
• Ground sheet
• Air mattress and repair kit
• Portable stove
• Cooler
• Water jug
• Pail
TRAVEL AIDS
• Toilet tissue
• Road maps
• Wash basin
• Sunglasses
• Mirror
• Litter bags
• Folding table
• Games
• Lounge chairs
• Funnel for fueling appliances
• Camp lantern with extra mantles
• Flashlight
• Binoculars
• Camera and film
• Waterproof tarpaulins
• Waterproof matches
• Small fire extinguisher
• Rain coats
• Waterproof tarpaulins
• Waterproof matches
Download from Www.Somanuals.com. All Manuals Search And Download.
THANK YOU FOR PURCHASING A SUPERIOR QUALITY OZARK TRAIL TENT. THIS TROUBLESHOOTING GUIDE IS
DESIGNED TO GIVE YOU YEARS OF FUN AND ENJOYMENT FROM YOUR CAMPING EQUIPMENT.
TROUBLESHOOTING GUIDE
PROBLEM
SOLUTION
1. CONDENSATION
THIS IS CAUSED BY LOWER TEMPERATURES ON THE OUTSIDE OF THE TENT
COMBINED WITH BODY HEAT ON THE INSIDE OF THE TENT. WHEN THIS OCCURS,
AVOID TOUCHING WALLS TO REDUCE CONTACT LEAKAGE. LEAVING THE DOORS
AND WINDOWS OPEN WILL REDUCE CONDENSATION OF MOISTURE .
2. SEAM LEAKAGE
3. MILDEW
TO PROTECT AGAINST SEAM LEAKAGE, APPLY A GENEROUS AMOUNT OF SEAM SEALER
ON ALL INTERIOR SEAMS.
TO AVOID MILDEW, NEVER PUT YOUR TENT AWAY WET OR DAMP. HOWEVER, IF
MILDEW OCCURS, USE A SOFT BRISTLE BRUSH OR SPONGE WITH MILD DISH
WASHING SOAP OR FELS NAPTHA SOAP TO CLEAN. LET THE TENT DRY IN THE
SUNLIGHT AND APPLY SEAM SEALER COMPOUND ON INSIDE SEAMS.
4. REPAIRING A TEAR
5. FAULTY ZIPPER
FOR SMALL TEARS USE A SELF-ADHESIVE PATCH KIT. WE RECOMMEND A CANVAS
OR AWNING REPAIR SHOP FOR LARGER TEARS.
ALL OF OUR TENTS ARE MANUFACTURED WITH ZIPPERS WHICH, IF THE ZIPPER
SEPARATES, CAN BE FIXED BY MOVING THE SLIDER TO THE BEGINNING OF THE ZIPPER
TAPE AND REWORKING THE ZIPPER. IF THIS DOESN’T WORK, A REPLACEMENT ZIPPER
MAY BE ORDERED FROM OUR PARTS DEPARTMENT, AND MAY BE INSTALLED BY A LOCAL
CANVAS OR AWNING REPAIR SHOP IN YOUR AREA.
6. FLOOR CONDENSATION
7. REMOVING STAKES
A GROUND CLOTH UNDER THE TENT PREVENTS THE FLOOR FROM FEELING DAMP
AND HELPS PROLONG ITS LIFE. THE CLOTH SHOULD BE SMALLER THAN THE TENT
FLOOR TO PREVENT RAIN FROM RUNNING UNDER THE TENT.
STAKE SHOULD BE PULLED WITH ANOTHER STAKE, HAMMER OR STAKE PULLER,
BUT NEVER BY PULLING ON THE TENT. AVOID STAKING TENT SO TIGHT THAT IT
STRETCHES THE FABRIC. OVERSTRETCHING MAY CAUSE STAKE LOOPS TO TEAR.
PERHAPS WE’VE MISSED SOMETHING IN OUR TROUBLESHOOTING GUIDE. FEEL FREE TO GIVE US YOUR IDEAS ON
“TRICKS OF CAMPING”, REPAIR PROCEDURES, FEATURES YOU’D LIKE TO SEE, OR JUST YOUR THOUGHTS. SEND THEM TO:
TENT CUSTOMER SERVICE
3333 YALE WAY
FREMONT, CA 94538-6169
To order replacement parts, call toll free
1-800-775-1965 Mon.– Fri, 7:00 a.m. to 4:00 p.m. (PST-West Coast).
Mention complete model numbers.
Download from Www.Somanuals.com. All Manuals Search And Download.
|