Download from Www.Somanuals.com. All Manuals Search And Download.
STEP BY STEP INSTALLATION
Step 1: Determine where the speaker will be mounted. Make sure there is a flat area large
enough for the speaker to fit properly. An uneven mounting surface can damage the
driver.
Step 2: Check to make sure the space you have chosen for the speaker will not interfere with
the operation of the vehicle.
Step 3: Using the plastic grille ring as a template, mark the speaker hole with a pen.
Step 4: Cut the hole for the speaker. When using factory locations, this step can be passed. A
hole can be cut either with a pair of metal tin snips or a hole saw corresponding to the
size of the speaker listed below.
• 4 3/4" (120mm) hole saw (C53)
• 5 1/2" (140mm) hole saw (C63)
Step 5: Run the speaker wire to the speakers. Make sure to keep wires away from sharp metal
or other edges. When passing through metal ,use a protective grommet.
Step 6: Using the plastic grille ring as a template, mark the mounting holes with a pen.
1
Step 7: Pre-drill mounting holes using a /8" drill bit.
Step 8: The C-series coaxial speaker is placed in the grille ring from the front. Place the speaker
and the grille ring in the installation hole. Align the mounting screw holes and drive
in the four mounting screws. Push the perforated metal grille back into the grille ring.
Step 9: Pull the wire through the speaker opening and connect to the speaker. Be sure to
match the crossover wires to the speaker correctly, HF to HF and LF to LF of the speaker.
WARNING: Window mechanisms and electrical wires have a nasty habit of hiding
where you least expect. CHECK BEFORE YOU DRILL!
Coaxial Speaker Specifications
Model
Nominal
Power
Frequency Sensitivity Mounting
Mounting
Diameter
C-series Impedance Continuous/
Maximum
Response
Depth
C53
3ohms
3ohms
3ohms
3ohms
3ohms
40/80
45/90
40/80
45/90
50/100
90Hz to 20kHz
60Hz to 20kHz
85Hz to 20kHz
80Hz to 20kHz
55Hz to 20kHz
91dB
91dB
91dB
91dB
92dB
2 1/4”
(57mm)
4 3/4”
(120mm)
C63
2 7/8”
(73mm)
5 1/2”
(140mm)
C463
C573
C693
2 1/4”
(57mm)
5.9/16” x 3 3/8”
(142mm x 86mm)
2 3/16”
(56mm)
5 1/16” x 7 3/16”
(129mm x 183mm)
3 1/8 ”
(80mm)
8 7/8” x 6”
(226mm x 153mm)
* ALL SPECIFICATIONS ARE SUBJECT TO CHANGE WITHOUT NOTICE.
Download from Www.Somanuals.com. All Manuals Search And Download.
Warranty
LIMITED TWO YEAR CONSUMER WARRANTY:
Directed Electronics, Inc. promises to the original purchaser, to replace this product should it prove
to be defective in workmanship or material under normal use, for a period of two years from the
date of purchase from the dealer as indicated by the date code marking of the product PROVIDED
the product was installed by an authorized Directed dealer. During this two-year period, there will
be no charge for this replacement PROVIDED the unit is returned to Directed, shipping pre-paid.
If the unit is installed by anyone other than an authorized Directed dealer, the warranty period will
be one year from the date of purchase by the dealer as indicated by the date code marking of the
product. This warranty is non-transferable and does not apply to any unit that has been modified
or used in a manner contrary to its intended purpose, and does not cover damage to the unit
caused by installation or removal of the unit. During this one-year period, there will be no charge
for this replacement PROVIDED the unit is returned to Directed, shipping pre-paid. This warranty
is void if the product has been damaged by accident or unreasonable use, neglect, improper service
or other causes not arising out of defects in materials or construction. Units which are found to be
damaged by abuse resulting in thermally damaged voice coils are not covered by this warranty but
may be replaced at the absolute/sole discretion of Directed. ALL WARRANTIES INCLUDING BUT
NOT LIMITED TO EXPRESS WARRANTY, IMPLIED WARRANTY, WARRANTY OF
MERCHANTABILITY, FITNESS FOR PARTICULAR PURPOSE, AND WARRANTY OF NON-
INFRINGEMENT OF INTELLECTUAL PROPERTY ARE EXPRESSLY EXCLUDED TO THE
MAXIMUM EXTENT ALLOWED BY LAW, AND DIRECTED NEITHER ASSUMES NOR
AUTHORIZES ANY PERSON TO ASSUME FOR IT ANY LIABILITY IN CONNECTION WITH THE
SALE OF THE PRODUCT. DIRECTED HAS ABSOLUTELY NO LIABILITY FOR ANY AND ALL ACTS
OF THIRD PARTIES INCLUDING ITS AUTHORIZED DEALERS OR INSTALLERS. Unit must be
returned to Directed, postage pre-paid, with bill of sale or other dated proof of purchase bearing
the following information: consumer's name, telephone number, and address, authorized dealer's
name and address, and product description. Note: This warranty does not cover labor costs for the
removal and reinstallation of the unit. IN ORDER FOR THIS WARRANTY TO BE VALID, YOUR
UNIT MUST BE SHIPPED WITH PROOF OF INSTALLATION BY AN AUTHORIZED DIRECTED
DEALER. ALL UNITS RECEIVED BY DIRECTED FOR WARRANTY REPAIR WITHOUT PROOF OF
DIRECTED DEALER INSTALLATION WILL BE COVERED BY THE LIMITED 1 YEAR PARTS AND
LABOR WARRANTY. Note: This warranty does not cover labor costs for the removal and
reinstallation of the unit. BY PURCHASING THIS PRODUCT, THE CONSUMER AGREES AND
CONSENTS THAT ALL DISPUTES BETWEEN THE CONSUMER AND DIRECTED SHALL BE
RESOLVED IN ACCORDANCE WITH CALIFORNIA LAWS IN SAN DIEGO COUNTY, CALIFORNIA.
© 2002 Directed Electronics, Inc. All rights reserved. G37001/06/11/16/21 12-02
Download from Www.Somanuals.com. All Manuals Search And Download.
|