Electric built-in oven
Instructions for installation and use
FE 10 K GB
Download from Www.Somanuals.com. All Manuals Search And Download.
Important
To maintain the EFFICIENCY and SAFETY of this appliance, we recommend:
•
•
call only the Service Centers authorized by the manufacturer
always use original Spare Parts
1 This appliance is intended for non-professional use
within the home.
11 The ventilation and heat dispersion outlets should
never be obstructed.
2 Before using the appliance, carefully read the
instructions contained in this manual, as they
provide important information for ensuring safe
installation, use and maintenance. Keep this
manual as a reference guide..
3 After unpacking the appliance, check that it is
undamaged and that no parts are missing. If you are
in any doubt, do not use the appliance and call a
qualified technician. All packaging (plastic bags,
polystyrene foam, nails, etc) should be kept out of the
reach of children as it could be dangerous.
12 Never replace the power supply cable yourself.
Damaged cables may be replaced only by an
authorised servicing centre.
13 This appliance must only be used for the purpose for
which it was designed. Any other use (for example:
heating the room) must be considered improper and,
therefore, dangerous.The manufacturer cannot be held
responsible for any injuries or damages resulting from
improper, incorrect and negligent use.
14 The use of any electrical appliance involves the
observance of some basic rules. In particular:
4 The appliance must be installed according to the
manufacturer’s instructions by a qualified technician.
Improper installation may cause damage to persons,
animals or property for which the manufacturer declines
all reponsibility.
·
do not touch appliance with wet or damp hands or
feet
do not use the appliance while bare-footed
do not use extension leads other than with the
utmost caution
·
·
5 The electrical safety of this appliance is guaranteed
only if it has been correctly connected to an efficiently
earthed system which complies with safety standards
in force. This fundamental safety requirement is to be
verified in any case. If in doubt, consult a qualified
technician. The manufacturer is not responsible for
damage or injuries caused by an appliance which has
not been earthed.
6 Before connecting the appliance check that the
information on the data plate correspond to the electric
and gas mains of your home.
7 Check that the supply voltage of the system and
sockets correspond to the maximum power of the
appliance indicated on the data plate. If you have any
doubt, call a qualified technician.
8 When installing, an omnipolar circuit-breaker with a
contact opening of at least 3 mm must be used.
9 Should the socket and the plug of the appliance be
incompatible, the socket must be replaced by a skilled
electrician, who should also check that the cross-
section of the socket cables will support the absorbed
power of the appliance.Adaptors, multiple sockets and/
or extension leads should generally not be used.
However, if necessary, only use single or muyltiple
adaptors and extension leads which comply with
current safety standards. Make sure not to exceed the
current rating limit marked on single adaptors and
extension leads or the maximum power limit indicated
on multiple adaptors.
·
·
·
do not pull the power supply cable or the appliance
itself to disconnect the plug from the socket.
do not expose the appliance to weather agents
(raing, sun, etc)
do not allow unsupervised children or inexperienced
persons to use the appliance.
15 Disconnect the appliance before cleaning it or carrying
out maintenance work by turning off the mains switch
or removing the plug from the socket.
16 If you decide to stop using any type of electrical
appliance, it is recommended that the supply cable is
cut and that all parts be removed, particularly for the
safety of children who might use the appliance as a
toy.
17 Remember that children’s skin is much more sensitive
than adults’and burns more easily.Keep children away
from the appliance during or immediately after use while
it is still hot. Be careful in particular about the oven
door during long cooking times at high temperatures
when it becomes extremely hot.
18 Never use flammable liquids such as alcohol or
gasoline, etc. near the appliance when it is in use.
19 Wear oven gloves when placing coockware in the oven
or removing it.
20 Never use the oven as place to store flammable
material.
21 When using small electric appliances near the hob,
keep the supply cord away from the hot parts.
22 Make sure the knobs are in the “•”/”O” position when
the appliance is not in use.
23 Remember to keep children away from the
appliance when you use the grill or oven, since
these parts become very hot.
10 Do not leave the appliance connected unnecessarily.
Always switch off at the mains when the appliance is
not in use.
3
Download from Www.Somanuals.com. All Manuals Search And Download.
Installation
Important: The power supply to the appliance must be
cut off before any adjustments or maintenance work is
done on it.
Unpacking
560 mm.
Remove the outer packing from the oven. Open the door
outwards and remove packing from the shelves.Take out
the plastic envelope containing instruction book, guarantee
card and 4 fixing screws.
Installation of Built-in Ovens
In order to insure that the built-in appliance functions
properly, the cabinet containing it must be appropriate.
The figure below gives the dimensions of the cutout for
installation under the counter or in a cabinet wall unit.
To fasten the oven to the cabinet, open the door of the
oven and fasten it by inserting the 4 wood screws into the
4 holes locate on the perimeter of the frame.
The panels of the adjacent cabinets must be made of
heat resistant material.In particular, cabinets with a veneer
exterior must be assembled with glues able to withstand
temperatures of up to 100°C.
Once the appliance has been installed, the electrical parts
must be totally protected from all contact, according to
current safety regulations.
All protecting parts should be firmly fixed and should
require the use of a tool for removal.
When installing below a built-in hob, ensure that there are
air inlets and outlets for ventilating the interior of the cabinet
adequately. Assembly examples are given in figs.
Electrical connection
Ovens with a three-pole power supply cable are designed
to operate with alternated current at the supply frequency
and voltage indicated on the data plate (at the bottom of
the oven dashboard).The earthing conductor of the cable
is the yellow-green conductor.
In order to ensure adequate ventilation, the back panel of
the cabinet must be removed.Installing the oven so that it
rests on two strips of wood is preferable.In the case where
the oven rests on a continuous, flat surface, there must
be an aperture of at least 45 x 560 mm.
Two types of connection are provided:
Connection n° 1
Connecting the power supply cable to the mains.
Fit a normalized plug to the cable, which corresponds to
the load indicated on the data plate; if the cooker is
connected directly to the mains, an omnipolar circuit-
4
Download from Www.Somanuals.com. All Manuals Search And Download.
breaker with a minimum opening of 3 mm between the
contacts, suitable for the load indicated and complying
with current directives, must be installed between the
appliance and the mains (the earthing wire must not be
interrupted by the circuit-breaker).The power supply cable
must be positioned so that it does not exceed room tem-
perature by 50°C at any point of its length. Before making
the connection check that:
Connect Green &Yellow wire to terminal marked “E” or
or coloured Green or Green & Yellow.
Connect Brown wire to terminal marked “L” or coloured
Red.Connect Blue wire to terminal marked “N”or coloured
Black. If a 13 amp plug (BS 1363) is used it must be fitted
with a 13 amp fuse.
A 15 amp plug must be protected by a 15 amp fuse, either
in the plug or adaptor or at the distribution board.If you
are in any doubt about the electrical supply to your
machine, consult a qualified electrician before use.
• the limiter valve and the home system can support
appliance load (see data plate);
How to connect an alternative plug
The wires in this mains lead are coloured in accordance
with the following code:
• the power supply system has an efficient earthing
connection which complies with the provisions of
current regulations and the law;
BLUE
BROWN
“NEUTRAL” (N)
“LIVE” (L)
• there is easy access to the socket or the omnipolar
circuit-breaker once the cooker has been installed.
GREEN ANDYELLOW
“EARTH” (E)
N.B.: do not use reducers, adapters or shunts as these
could cause heating or burning.
GREEN &
YELLOW
Connection n° 2
Disposing of the plug.
13 amp fuse
BROWN
WARNING:THIS APPLIANCE MUST BE EARTHED.
Ensure that before disposing of the plug itself, you make
the pins unusable so that it cannot be accidentally inserted
into a socket. Instructions for connecting cable to an alter-
native plug:
CROSS-BAR
CORD GRIP
BLUE
Important: the wires in the mains lead are coloured in
accordance with the following code:
Disposing of the appliance
When disposing of the appliance please remove the plug
by cutting the mains cable as close as possible to the
plug body and dispose of it as described above.
Green & Yellow
Blue
Brown
-Earth
-Neutral
-Live
If the colours of the wires in the mains lead do not
correspond with the coloured markings identifying the
terminals in your plug, proceed as follows.
5
Download from Www.Somanuals.com. All Manuals Search And Download.
Oven description
A Panel
B Dripping-pan or cooking shelf
C Oven grill shelf
D Holes for fixing screws
E Selection knob
F Thermostat knob
G The red oven operating pilot lamp
A
D
D
C
B
D
G
D
E
F
Technical caracteristics
Oven size:
- width: cm 40
- depth: cm 39
- height: cm 34
This appliance conforms with the following European
Economic Communitary directives:
-
-
73/23/EEC of 19/02/73 (LowVoltage) and subsequent;
89/336/EEC of 03/05/89 (Electromagnetic
Compatibility) and subsequent;
Oven size:
53 lt
230V~ 50/60Hz
2300 W
-
93/68/EEC of 22/07/93 and subsequent.
Voltage and frequency:
Power supply:
6
Download from Www.Somanuals.com. All Manuals Search And Download.
Instructions for use
The different functions offered by the oven are selected
3.The grill
by operating the controls and devices situated on the oven
panel.
- Knob “E” setting:
- Knob “F” setting: Max
The oven light turns on and so does the infra-red ray grill.
The rather high and direct temperature of the grill permits
browning the outside of meats immediately thus keeping
in the juices and assuring tenderness.
Attention: before using the oven and grill for the first time,
turn the oven on for approximately one half hour. Make
sure that the oven is empty, the thermostat on high, the
door open, and the room properly ventilated. The odor
which can be detected at times is due to the evaporation
off the substances used to protect the oven and the grill
during the period between the and installation of the
appliance.
4.The double grill
- Knob “E” setting:
- Knob “F” setting: Max
The oven light turns on and so does the double heating
element of the grill. This grill is larger than the average
and has a completely new design: cooking performance
is increased 50%. The double grill makes sure that even
the corners are touched by heat.
Attention: Only use the bottom shelf of the oven when
using the rotisserie to cook (where present). For all other
types of cooking, never use the bottom shelf and never
place anything on the bottom of the oven when it is in
operation because this could damage the enamel.Always
place your cookware (dishes, aluminium foil, etc. etc.) on
the grate provided with the appliance inserted especially
along the oven guides.
The oven-operating pilot lamp (G)
Signals when the oven is heating.It switches off when the
temperature inside the oven reached the temperature
selected by the knob. At this point the alternate turning on
and turning off of this light indicates that the thermostat is
operating correctly to keep the oven temperature constant.
The oven knobs
With these two controls you can select the different
functions of the oven and choose the cooking temperatu-
re suitable for the food you are preparing. The different
cooking functions are set up by operating the two knobs:
Handle
Attention: when the oven is on steam escapes from the
slot on the right end of the handle. Keep hands away from
this area.For ovens with tubular handles, there is a special
protective device which is fitted during cooking to keep
steam away from the front of the cooker.
E - the selection knob (identified by the symbol
)
F - the thermostat knob (identified by the symbol
) on
the oven panel.
For any selection-knob setting different from idle, identified
1
by the “0”, the oven light turns on;the knob setting marked
permits turning on the oven light without any heating
element being switched on.
2
1. Coventional
- Knob “E” setting:
- Knob “F” setting: anywhere between 60°C and Max
The oven light turns on and the top and bottom heating
elements (resistors) switch on.The temperature, fixed by
the thermostat knob, is reached automatically and kept
constant by the thermostat control. This function permits
cooking and type of food thanks to excellent temperature
distribution.
Forced Air Ventilation
In order to reduce the external temperature of the oven,
some models have been equipped with a cooling fan which
comes on when the "E" knob is turned to a cooking setting.
The fan remains on during the cooking process and a flow
of air can be heard exiting between the oven door and the
control panel.
2. Pastry
- Knob “E” setting:
- Knob “F” setting: anywhere between 60°C and Max
Note: When cooking is over, the fan remains on for a few
minutes, in order to enable the oven to cool down quickly.
The oven light turns on and so does the bottom heating
element. The temperature, fixed by the thermostat knob,
is reached automatically and kept constant. This setting
is recommended for finishing the cooking of foods (placed
in pans) that are well done on the outside but still not done
inside or for desserts covered with fruit or jam which require
a light browning on top. Note that this function does not
permit reaching the maximum (250°C) temperature inside
for cooking foods always on this oven setting unless the
foods are cakes which only require temperatures below
or equal to 180°C.
3rd glass-door
You can buy a special kit to reduce door temperature when
the oven is on and save energy. If there are little children
in the house, this kit is a must. The kit code number is
074657 and it may be purchased for installation from an
authorised dealer or aTechnical Assistance Service centre
indicated in the list included with the appliance documents.
7
Download from Www.Somanuals.com. All Manuals Search And Download.
Recommendations for baking in the oven
When using the oven, only one rack or dripping-pan should
Pastry is too dark on top
be used at a time.The rack or pan should be inserted into
the bottom or top guides depending on whether the food
needs more heat from the top or bottom.
Place it on a lower rack, lower the temperature, and
increase the cooking time.
Preheating
If the oven must be preheated (this is generally required
for leavened foods), we recommend using the
"conventional" oven feature which makes it possible to
reach the temperature desired in a very short time. After
the oven has been preheated, the red indicator light (G)
will turn off. At this point, you can select the most suitable
setting to cook the dish.
Cooked well on the inside but sticky on the outside
Use less liquid, lower the temperature, and increase the
cooking time.
The pastry sticks to the pan
Grease the pan well and sprinkle it with a dusting of
flour.
Cooking Fish and Meat
Meat must weigh at least 1 Kg in order to prevent it from
drying out. When cooking white meat, fowl and fish, use
low temperature settings (150°C-175°C). For red meat
that should be well done on the outside while tender and
juicy in the inside, it is a good idea to start with a high
I used more than one level and they are not all at
the same cooking point
Use a lower temperature setting. It is not necessary to
remove the food from all the racks at the same time.
temperature setting (200°C-220°C) for a short time, then
turn the oven down afterwards. In general, the larger the
roast, the lower the temperature setting. Place the meat
on the centre of the rack and place the dripping pan
beneath it to catch the fat.
Make sure that the rack is inserted so that it is in the centre
of the oven. If you would like to increase the amount of
heat from below, use the low rack heights. For savory
roasts (especially duck and wild game), dress the meat
with lard or bacon on the top.
Using the Grill
The oven allows you to use two different grilling methods.
Use the
“grill” setting for small portions. Energy
consumption for this feature is only 1200 W; however, it is
ideal for grilling small dishes or portions, e.g. toast,
frankfurters, etc.
Place the food in the centre of the grill, as only the centre
of the heating element is turned on.Food in the corners of
the oven will not be cooked.
Cooking Pastries
Always preheat the oven when cooking pastries. Do not
open the door in order to prevent the pastry from dropping.
The batter or dough should not be too liquidy so that the
cooking time is not excessive. In general:
The
“double grill” setting allows you to grill along the
entire surface area of the grill itself.Use this feature when
you have food distributed uniformly beneath the grill.
Important:grilling must be done with the door partially
open to avoid increasing the grilling time.
When using the grill settings, it is recommended that the
thermostat be set to maximum, as this is the optimal setting
for the grill, which utilizes radiation produced by infrared
rays.However, this does not mean that lower temperature
settings cannot be used when necessary.
Pastry is too dry
Increase the temperature by 10°C and reduce the
cooking time.
Pastry dropped
When utilizing the grill, place the rack at the lower levels
(see cooking table). To catch grease or fat and prevent
smoke, place a dripping-pan at the bottom rack level.
Use less liquid or lower the temperature by 10°C.
8
Download from Www.Somanuals.com. All Manuals Search And Download.
Routine maintenance and oven cleaning
Before each operation, disconnect the oven from the
Replacing the oven lamp
electricy. To assure the long life of the oven, it must be
thoroughly cleaned frequently, keeping in mind that:
·
·
·
Unplug the oven from the mains;
Remove the glass cover of the lamp-holder;
Remove the lamp and replace with a lamp resistant to
high temperatures (300°C) with the following
characteristics:
·
·
·
the enamelled parts and the self-cleaning panels are
washed with warm water without using any abrasive
powders or corrosive substance which could ruin them;
the inside of the oven should be cleaned fairly often
while it is still warm using warm water and detergent,
followed by careful rinsing and drying;
Stainless steel may become marked if it comes into
contact with very hard water or harsh detergents
(containing phosphorous) for long periods of time.After
cleaning, it is advisable to rinse thoroughly and dry. It
is also recommended to dry any water drops;
-
-
-
Voltage 230V
Wattage 25W
Type E14
·
Replace the glass over and connect the oven to the
mains.
Pratical advice for oven cooking
Knob Setting
Food to be
Prepared
Weight Rack Position Preheating
Thermostat
Knob Setting
Cooking Time
(minutes)
(Kg)
from the
Bottom
Time
(minutes)
Ribs
Veal Roasts
Duck
Meringues
Biscuits
0.5
0.5
0.5
-
2
2
1-2
2
15
15
15
10
10
200
200
200
100
140
35
30
30-35
60-75
15-20
1 Conventional
-
2
Cakes
Tarts
Fruit Pies
Brioches
0.5
1
1
3
3
2
2
15
15
15
15
160
180
180
160
30-40
35-40
50-60
40-45
2 Pastry
3 Grill
0.5
Sogliole e seppioline
Spiedini di calamari
e gamberi
Cod Steaks
Grilled Vegetables
1
4
5
Max
8
1
1
1
4
4
3-4
5
5
5
Max
Max
Max
4
10
8-10
Veal Cutlets
Chops
Hamburgers
Mackerel
Veal Sshish Kabobs
Roasted Chicken
1
1.5
1
1
1
4
4
3
4
2
2
5
5
5
5
5
5
Max
Max
Max
Max
Max
Max
15-20
25
7
20-25
60
60
4 Double Grill
1
Note: cooking times are only indicative and may vary depending on personal preferences.
9
Download from Www.Somanuals.com. All Manuals Search And Download.
10
Download from Www.Somanuals.com. All Manuals Search And Download.
11
Download from Www.Somanuals.com. All Manuals Search And Download.
Merloni Elettrodomestici
Viale Aristide Merloni 47
60044 Fabriano
Italy
Tel +39 0732 6611
Fax +39 0732 662501
Download from Www.Somanuals.com. All Manuals Search And Download.
|